Ford Super Duty (1999-2016) :: Increased Temps - Clogged Radiator?
My radiator has been leaking very little for some time and it is stock after 250k so im sure it is plugged....my engine has been running 202 .... My tranny only goes over 200 while towing...otherwise if is under 190
View 14 RepliesFord Super Duty (1999-2016) :: 2005 F250 6.0 - High Temps With A/C On
I've been battling this high temp issue for a bit now. Here's the recap on my truck.
2005 F250 6.0
120k miles
Edge insight CTS2
New factory Oil cooler
motorcraft coolant -system flushed
Stock EGR- No leakage
Deltas 3-5 degree apart no A/C on
A/C works great!
-Issue- When I turn the A/C on city on normal driving no loads or towing. The temps have gone up as high as 230 eot 230 etc. Ambient temps 83-90F ....
Ford Super Duty (1999-2016) :: 2012 F350 - Running Temps For Trans
What are the normal running temps for the tranny of a 2012 f350 6.7?
View 3 RepliesFord Super Duty (1999-2016) :: 2002 F250 Will Not Start In Below Freezing Temps At Random
I have an 02 250 5.4. 103,000 miles. My truck at random times will not start in below freezing temps. Turns over just fine but Acts as if a frozen fuel line. I can get it running by pouring hot water on the fuel rail or a shot of starting fluid or sometimes both. It's been going on about 3 or 4 weeks now and I have ran through 4 bottles of dry gas with about 15 gallons each time. Also have replaced fuel filter and fuel pressure regulator. I'm 99.9% positive the pump is working and there are no leaks in the lines or holes in tank that I can see. My next step is to drop the tank and clean it out but trying to avoid that.
View 14 RepliesFord Super Duty (1999-2016) :: 2008 - High Oil Temps / Cooler Is Fully Or Partially Clogged
2008 6.4L .... My ECT 191-197 and EOT 220-230 high side on interstate no load on truck air temp 70 degrees. Is this a sign thermostat failing. Is there a certain temp to determine if your cooler is fully clogged or just partially clogged? I plan on doing a flush with restore then restore plus. Is there any point in using restore with temps this high. Or do I have to break down and buy the half kit to bypass OEM oil cooler? I need this fixed ASAP hauling the RZR to arkansas in a week. I know ill mess something up if i try to pull a load with those temps.
View 2 RepliesFord Super Duty (1999-2016) :: Oil Leaking On The Transmission
I am not positive where it could be but I have a good bit of oil on the transmission (i think) i was trying to replace the strarter and noticed it. Where the possible leak could be from? No oil on the ground under the truck.
View 3 RepliesFord Super Duty (1999-2016) :: Transmission Will Not Go Into Forward Gears
I have a 1999 F-250 4X4 7.3 lit Diesel engine. My problem is my transmission will go into reverse great no problem but it won't go forward. I have no problem rebuilding the transmission if that's what it needs, I just want to make sure there isn't a electrical issue from the PCM first?
View 14 RepliesFord Super Duty (1999-2016) :: 2003 - Transmission Won't Working?
Yesterday my transmission on my work truck decides to fail. 2003 Ford F350 7.3 diesel auto with 4wd, 85k
Started the truck to allow it to warm up. We have been getting 38 to 45 degree weather. Proceeded to drive the truck for about 8 miles and come up to a red light and stopped. When the light changes to green, I hit the accelerator and the motor just free revs. Look down to make sure that the truck is in drive. No go.
I did check the following, I have no leaks whats so ever. I checked the auto tranny oil level and that was fine. The check engine light did not come on. I checked to make sure that the 4wd system was not engaged nor sitting in neutral. No warning signs or noises, the tranny was pulling normal up until I stopped,' All gears are showing the same signs. When you move the gear selection to all the other gears, it seems as if it's disconnected.
Before when I changed from drive gear to reverse gear I would place my foot on the brake and change to a different gear. You would get a slight hesitation knowing the gear was selected. Now when I move the gear I do not get anything. This has me baffled. I really like this truck and has been pretty much been trouble free.
Ford Super Duty (1999-2016) :: Transmission Whine While Accelerating
The truck is a 2012 f250 6.2 flex fuel from alberta canada. This isn't the first tranny form out there that I've heard do this. Tranny seems fine shifts all right just a whine while accelerating.
View 7 RepliesFord Super Duty (1999-2016) :: Transmission Slipping In 3rd Gear?
Truck is slipping in/out of gear in 3rd gear. Shut it off and the problem may not come back for several days, but in general it is getting more frequent. No codes are registering for the transmission. Curious the wisdom of performing a simple fluid/filter change vs taking it to the transmission shop. Fluid basically looks/smells good, and is full.
View 14 RepliesFord Super Duty (1999-2016) :: Transmission Line Removal?
OK, so I ordered in the new lines and have them. BUT my problem is snaking the factory transmission line out from under the truck. I have pictures to show my struggles.
How do I pull this:
Out of here???
Towards the front of the motor
Front passenger side cab corner
Replacing these lines? I don't care about breaking the old one, but I still need to find a way to install the new one.
Ford Super Duty (1999-2016) :: Transmission Swap Of V10 To 7.3L Powerstroke?
Can I take the tranny out of a v10 and put it in my 7.3L Powerstroke?
Both are 1999 f250's.
From what I've read they should both be 4r100's.
Ford Super Duty (1999-2016) :: Transmission Temperature Reading Low?
With the colder temperature, I noticed the temperature for the transmission is not getting up to normal as quickly as before. Yesterday I switched to gauge mode and it showed 145 degrees after 20 miles of driving at an outside temperature of 42 degrees. What the minimum temperature should be? It's not showing a check engine light and shifts good.
View 8 RepliesFord Super Duty (1999-2016) :: How To Read Transmission Dipstick
Just did a drop an refill of my trans fluid. Put in a little under 8 qts.
My question is where should the fluid read ? Is half way between full and E good or should it be right up to the line ?
Obviously I'm reading it while trans is warm and in nuetral, engine running
Ford Super Duty (1999-2016) :: Transmission Line Removal?
I have replaced both the transmission lines except the one that connects the two. It is the one near the top of the transmission that is about a foot long and goes from the fitting of the one transmission line to the other fitting for the other line. My questions is how do I remove it? It seems to be permanently affixed to the fittings, so those it come attached to new fittings?
View 2 RepliesFord Super Duty (1999-2016) :: Transmission Whining Intermittently?
A few weeks ago I was towing my 16 X 7 about 300 miles and I noticed that the transmission was whining.
Driven it about 600 miles unloaded with no issues. I do notice when I hit the gas it takes a second to engage..a little jerky...but normal otherwise. I don't drive the truck as a DD, so I tend not to notice things as easily.
Towed it 100 miles yesterday, and 100 miles back home today. Was silent until the last 20 miles...whining again.
What gives? I did have it serviced and inspected a few months ago because I felt like it was a little jerky. Got a clean bill of health from the local diesel shop.
Ford Super Duty (1999-2016) :: Leak At PTO Cover On Manual Transmission
I see an oil stain on/surrounding the lower half of what I'm guessing is the PTO cover on the side of my manual transmission. (rectangular plate bolted to side of tranny) I couldn't find a gasket at any autoparts stores. Is there a gasket or did Ford just use a sealer? Would red RTV work ok here instead of a gasket? Or should I use something else?
2004 F250 SuperDuty 4x4 CC, V10, 6 speed manual tran
Ford Super Duty (1999-2016) :: 2008 F250 Transmission Slipping When Doing 55 MPH
I been having a issue with my truck lately. It's a 2008 with only 88,000 miles. When doing 55mph it feels like the transmission is slipping. Sometimes it will do it over and over. If I speed up to about 60mph it goes away.its has gotten worse in the last month or so. Hoping it's nothing major.
View 6 RepliesFord Super Duty (1999-2016) :: Transmission Fluid Shooting Out From Right In Front Of Oil Pan
I have 460 7.5L gasoline engine on a RV. After driving 300 miles straight and the front start smoking and I pulled over and saw the transmission fluid just shooting out from right in front of the trans oil pan, hot and steaming. Also saw the trail of oil a mile from where I stopped. All oil are gone. Next day go back and put in 2.5 gallons of oil until I see the oil dripping down the bottom. Drove to Aamco transmission, 12 miles down in 20 min. Nothing happen, not a drop coming out.
I left it there in the parking lot on Sunday. Today the shop called and said they found nothing wrong. They said I just overfill it and they drain down 1.5 quart, it is all fine now. Then I told them the story. I said the oil were shooting out and all empty out. I put in 2.5 gallons , not quarts. They said it didn't make any sense. I don't know what to tell them. The RV is still in his shop and he said he will look at it more and see what he find.