Ford Super Duty (1999-2016) :: 2002 F250 - Ticking Sound Coming From Engine
Just noticed a ticking sound coming from my engine... just turned 160,000. Hoping nothing serious...
View 11 RepliesFord Super Duty (1999-2016) :: Ticking Noise From Passenger Side Follows Engine Speed
I have a tick in my 2001 V10, 190,000 (mostly easy) miles. I've changed oil/filter regularly at 3,000 mile intervals using Valvoline 5W20.
The tick seems to be on the passenger side of the engine, and is loudest when the engine is cold. It follows engine speed. The tick seems to be loudest as the engine transitions from acceleration to deceleration when I lift the throttle--I've NOT seen that posted before.
So, an exhaust manifold leak seems to be the most obvious? I installed a Banks Power Pack with Torque Tube headers in 2009 (about 90,000 miles ago) using thread lock compound on the supplied bolts and torqued to the instructions--I don't' remember the torque setting, but will look it up. I've listened to each exhaust port with a mechanic's stethoscope, all I hear is a smoothly running rotating assembly! Same result with the stethoscope on either side of the front cover (for timing chain slap.) NO tick through the stethoscope! I plan to check all the header bolts' torque this weekend, but don't really expect to find a problem. I will also scoot under the truck and recheck all the exhaust pipe clamps.
I've also listened to all the injectors--two of them (#3 and #4) were noticeably quieter than the other eight. But, none of them stood out as being particularly noisy. I've seen a couple of threads here that asked what a normal injector should sound like, but never an answer. How they should sound?
I've listened to each coil. I can hear a slight arc on #3. I believe the spring in the boot is not seated on the coil tab correctly (happened before.) I will correct that this weekend also. Nothing sounded like a loose plug, though I don't really know what that would sound like with the stethoscope.
What else could/should I check to avoid removing the valve/cam covers? (For cam follower or rocker trouble). I don't mind doing that, but don't want to go to the trouble and then find it wasn't necessary. I may spin on a Motorcraft filter (I'm just 800 miles into the last oil change now, I usually use Fram) but the tick stays with me until the engine is normal operating temperature, so I don't think it is from bleed back.
Ford Super Duty (1999-2016) :: 2004 F250 V10 - Ticking On Driver Side When First Takeoff
I have a v10 ticking on drivers side when I first take off in it. It doesn't do it idling and stops after you drive about a mile. I just had ford tune it up before this started so I took it back to have them check the plugs and they said it was a rod! Didn't sound right too me but I did check manifold bolts and they all was in place. Also if it was a rod would the noise go away???
View 6 RepliesFord Super Duty (1999-2016) :: Ticking Noise Coming From Right Side When Push The Accelerator
2002 Ford F-250 5.4l ... What is the difference in sound between a lifter tick and an exhaust leak? I have a ticking noise, almost sounds more like a puff of air noise, it only makes the noise when I push the accelerator and is coming from the right side. Noise is most noticeable if I put my head under the passenger side front fender. I am guessing I have an exhaust leak somewhere between the heads at cat but just wondering about the difference in sound. I'd think if it were the lifters they would tick at idle, right? The truck sounds great at idle (after doing a tune up) I just want to get rid of this annoying tick when I accelerate.
View 3 RepliesFord Super Duty (1999-2016) :: 2008 V10 - Ticking Noise In Upper Engine
Ive been looking around for Pickups for a wile now and found one (at the manheim auto auction) and it is a beauty. Crew Cab Long Box lariant with every factory option available for a 2008 6.8L Triton V10 truck. AND it only has 64,000 miles on it!!!
Pre Sale Inspection told us the truck has the upper engine tick that is heard sometimes in the V10. Doesn't seem to at all affect drive ability. Block announcement would be Green light, yellow light for upper engine noise. Truck has been priced accordingly. Look at what MMR is.
What this is, id like to put an offer in on the truck but if at 19,600 dollars if i am gonna have to do a lot of motor work or put a new motor in it i dont see it being worth it.
Ford Super Duty (1999-2016) :: New Long Block / Truck Still Smokes When Cranked
I have recently placed a new shortblock from Nashville engines. My retired ford diesel mechanic said it was the best shortblock he has ever seen. Since working on my truck he has ordered 6 small block from them. I used reman'd Ford heads after going through three sets of heads from Clearwater heads and one set from ProMaxx Cylinder Heads out of rainbow AL.
Since putting in new long block the truck smokes a puff of white smoke each morning. Enough smoke that it bothers me. A new longblock with new injectors should not be smoking. I have changed the fuel filters thinking the 5 sets of heads previously put on the truck may have gummed the motor up and have ran octane boost for the last 500 miles. I ran a 2000 mile road trip and the truck still smokes when cranked. sometimes a lot and sometimes a little. What could be causing this?
Ford Super Duty (1999-2016) :: F250 V10 Cranked Fine But No Hint Of Starting
1999 F250 SD V10 I recently replaced the in-tank fuel pump and filter. I operated the truck briefly after and everything was normal. I parked it with about 1/4 tank of new fuel and put it on a battery tender. It was parked in a garage on level ground in temperate weather(Southern Calif.). Two months later I tried to start it and it acted like it did when the fuel pump was bad. Cranked fine but no hint of starting. Could it be the fuel lines have become full of air and need purging through Schrader valve ? I haven't begun to troubleshoot but what to check other than pushing the fuel relay reset button.
View 5 RepliesFord Super Duty (1999-2016) :: Metal On Metal Ticking Sound
I thought i heard this yesterday when i left work but i was tired and said its in my head, THEN i go to leave right now and sure enough its a real sound, you can hear it very well through the front grill and then if you turn the volume up you can hear a ticking sound ever half a second or so, it also speeds up when i was pulling on the throttle cable. And after the truck fully warms up it goes away.......
View 14 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Truck Cranked And Batteries Died
My truck ran and drove then I changed my Steering Gearbox. After all that, I went to go start it, the trucked cranked and the batteries died. Hooked up the charger then and nothing, No start no crank. F250 2006 diesel 6.0 ...
View 14 RepliesFord Super Duty (1999-2016) :: Loud Squealing Sound On Driver Side / Lift Pump?
Truck details:
2008 f350 6.4 290,000 klm
DPF and full EGR delete
K&N intake
IDP custom street tune
Loud squealing noise that happens when cold or at temp.
2000 to 2500 rpm's to 3000 rpm then it goes away
Happens only when accelerating over 50% anything under and the noise doesn't happen.
15 to 20 pounds of boost
Turbo sounds good
No codes
All plumbing looks sealed and tight
Fuel coolant res is full and clean
I'm thinking it could be the lift pump dying or having trouble supplying the fuel demand. Started after I did the cold air intake....
Ford Super Duty (1999-2016) :: 2011 F250 - Knocking Sound From Rear Passenger Side Cab Corner
Just became the proud owner of a used 2011 F-250 Supercab, 6.2L. Overall the truck is great but it does have a-few things that need fixing, the most annoying of which is a knocking sound from the rear passenger side cab corner. Sounds like the exhaust vibrating and smacking up against the floorboard but that's not it. Everything seems tight, even the front suspension.
The only thing I can see that may be the cause is the rear passenger cab mount seems worn. I can rotate the bottom rubber portion without too much effort and when I feel for the top rubber portion all I feel is the metal cup on the top, like the rubber has collapsed and the metal cup is sitting directly on the frame mount.
So... how many cab mounts there are for the Supercab? I think there are two on each side and two in the front. All of the information & videos I've seen describe the locations for the crew cab. Also, is it possible to replace the cab mounts and not have to mess with the ones in the front? I hear those are the real buggers.
Ford Super Duty (1999-2016) :: 6.2L Engine - Whistling Sound When Cold
I've noticed during the winter my 2012 6.2L engine seems to 'whistle' when it is cold. It also seems to do it intermittently...that is, it always whistles when cold, but it might stop for 30 seconds and then do it again. It does it at idle, and also when driving, just until it warms up.
What is it, and do other people's trucks here do that? I was thinking maybe the engine fan, but why would it cycle on and off for maybe 30 seconds. My other thought was A/C pump.
Ford Super Duty (1999-2016) :: 2005 - Air Hissing Sound On Passenger Side / Black Smoke Pouring From Tailpipe
2005 6.0l PSD. Driving flat road pulling 8K trailer. Not pushing it at all. Sudden air hissing sound on (seems like) passenger side of truck. Black smoke pouring from tailpipe. Check intercooler pipe and is ok. Can't see anything that is loose. Only 8 miles to the campground so limp down the road at 30 MPH which is all it will do. Hissing sound is remarkable predictable in that it is repetitive every 5 seconds or so. Lasts for maybe 2 seconds then stops the repeats.
There is no turbo boost either on the dash gauge or the Scan II gauge. Shutting the engine down, there is no turbo wind down. Scan II show no codes. Check everything I can reach and find nothing extraordinary. Tried starting a driving it today and had boost for a minute only then nothing. Blowing white smoke too. Check the oil and it is oil. Check the radiator fluid and it is oil free. Running low on fuel and wonder if I have a water in the fuel problem. However, don't think that should effect the non functioning turbo...
Ford Super Duty (1999-2016) :: 2003 F250 Making Recurring Clicking Sound From Under The Dash On Left Side
My 2003 F-250 5.4l gas started making a recurring clicking sound from under the dash on the left side. It started last summer and would repeat numerous times each time I had the truck out. It's the kind of sound the turn signal makes. Always 5 clicks. It stopped happening when the weather got cold here in Canada, but started again this week (maybe because of the the warm weather we're having). How do I troubleshoot what the issue is? If the headlights are off it also flashes the lights in the instrument cluster five times.
View 4 RepliesFord Super Duty (1999-2016) :: 2010 - Screeching Sound Form Engine?
My F450 2010 class C motor home has the V10 engine. In the RPM range of about 2200 - 2300, there is a screeching sound I believe is from the engine area. It does not matter what transmission gear I'm in thus the vehicle speed is not a factor - only happens in that engine RPM range. Seems to happen when slowly accelerating or decelerating through the 2200 - 2300 RPM range or continues to screech if I maintain that RPM. If I drop back or increase RPM out of the range it quits. If I accelerate thru the range a little quicker it doesn't happen. Also does not happen when parked and the engine is sped up.
View 7 RepliesFord Super Duty (1999-2016) :: 2014 F250 - Engine Fan Winding Sound
Why does my engine fan run when truck is cold? I hate it, anoying winding sound. It will run that way for up to ten miles sometimes. My other trucks never did this. This is the 6.2 gas.
View 7 RepliesFord Super Duty (1999-2016) :: Ticking Loudly At Idle
My 5.4 is ticking loudly at idle. It's from the passenger wheel well. It doesn't seem to speed up with rpm. Maybe tick goes away with throttle? I did recently change plugs. So maybe coil pack? Cam phaser? Exhaust manifold? How do I troubleshoot?
View 8 RepliesFord Super Duty (1999-2016) :: F250 5.4L - Engine Making Puffing Sound Out Of Exhaust
Here's a link to a video where you can hear what I'm describing. The noise is most noticeable around the start (first 18 seconds) and the end of the video when I'm closest to the exhaust pipe:
YouTube ....
You may need headphones to hear it, but the engine seems to be making a bit of a puffing sound during idle. It happens completely randomly and I'm not quite sure what could be causing it.
Aside from this noise, the engine seems to idle normally, and the check engine light isn't on. I had all of the injectors out a few weeks ago for cleaning. They all appear to be working fine. I also cleaned the throttle body at that same time and ensured there were no obstructions for the air intake and filter.
What might be causing this sound? 1999 Ford F250 Super Duty 5.4L
Ford Super Duty (1999-2016) :: 2006 F250 - Rattling Sound Coming From Engine?
I have an 06 f250 6.0 when I'm driving and let off the throttle and coast I hear a rattling sound like a spray paint can being shaked sounds like its coming from engine compartment.
View 6 Replies