Ford Super Duty (1999-2016) :: 2006 F250 - Rattling Sound Coming From Engine?
I have an 06 f250 6.0 when I'm driving and let off the throttle and coast I hear a rattling sound like a spray paint can being shaked sounds like its coming from engine compartment.
View 6 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Ticking Noise Coming From Underneath
I have a 2003 F250 4wd with a 5.4 and 6 spd and 175,000 miles. Yesterday I came out to start it and noticed it had a ticking noise coming from underneath. According to the stock gauge it had normal oil pressure and the oil looked nice and clean and was full. I checked it while running and was able to verify that it is coming from the bottom oil pan/bell housing area. Before anybody says exhaust leak, I just put on JBA headers a few months ago and verified it wasn't an exhaust leak. I was assuming it was a rod bearing so I figured I would let it get to operating temp and see what happens. Once it started getting warm it started getting quiet and finally it just stopped once it hit full operating temp. Took it for a drive and found that it does it when in gear no matter what but stops when I put it in neutral and let out on the clutch. it makes the noise in neutral with clutch pushed in, but stops as soon as you let it out.
View 5 RepliesFord Super Duty (1999-2016) :: 2005 F250 - Buzzing Sound Coming From Near Fuel Filter Area In Engine Bay
I have an 2005 F250 4.2tdi XLT. There is a buzzing sound coming from somewhere near the fuel filter area in the engine bay. This started after changing the fuel filter during a service. Its also difficult to start now. It has to swing for 10 secs before the engine fires. What it could be?
View 4 RepliesFord Super Duty (1999-2016) :: Ticking Sound From The Right Side When Engine First Cranked
I'm assuming its a valve.
2004 F250 with 5.4L. 128,000 miles. Oil changed every 4K but its my work truck. She works hard for a living towing landscape trailers 98% of the time.
When the engine is first cranked, there is a ticking sound from the right side. Its quite noticeable but only does this until I get going. Once I get to driving, it fades away. If I turn the engine off and let it sit for a little while, when I start it, the ticking is back again. As long as I keep it running, it stays quiet.
If this is a valve or rocker arm, how big of a repair is it? What happens if I don't deal with it until the winter (off-season)?
I've tried Marvel Mystery Oil and now with this oil change, I have Rislone in there. Both have made no difference.
Ford Super Duty (1999-2016) :: 2002 F250 - Intermittent Noise Coming From Front End
I have a 2002 F-250 7.3. I was driving home from work on Tuesday (highway), I heard an intermittent noise coming from the front end, sounded like a rubbing/grinding noise. Yesterday on my way to wok, same thing, on and off. Yesterday on my way home the noise was constant, didn't go away. The noise comes at about 45mph and stays until I'm back under about 45mph, so mainly just on the highway. I put the truck in neutral and let off the pedal and the noise is still there which tells me it isn't engine related.
Yesterday after work I jacked up the front end, spun the tires, no noise. No play in the tires top/bottom or side/side. Took the tires off and what I did notice is the right axle u-joint is shot. I am hearing the noise in 2wd so I don't know if its the u-joint that's making the noise. Could it be a bad wheel hub bearing? Is it the u-joint? Maybe needle bearing??
Ford Super Duty (1999-2016) :: 2002 F250 - Second 110V Plug Coming Out Of The Grill
Just picked up a 2002 F-250 Super Duty. I have a second 110V plug coming out of the grill. The first, on the drivers side, I know is for the block heater through the oil filter housing. The second is attached to a device that is inline of the lower coolant hose. Is this a warming device also?
View 2 RepliesFord Super Duty (1999-2016) :: 2011 F250 - Clunking / Loose Sound Coming From Front End
My 11 cc lb 4x4 6.2 has a clunking/loose sound coming from the front end. It is prominent when going over small/medium bumps but not so much large bumps. I have had my local dealer and a couple local shops look at it and they all say everything checks out. It definitely seems like something is loose in the front suspension. I just put new Gabriel max control shocks on all four corners. I have no play in wheel bearings or ball joints. Tie rod ends also look fine.
View 12 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Loud Blower Sound Cycle On And Off Constantly When Towing
What will make a loud blower sound cycle on and off constantly when towing if i turn the ac off it stops....
View 7 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Rattling Noise Coming From Front Suspension When Going Over Small Bumps
2002 F-250 7.3 4x4 ...
I have a rattling noise coming from the front suspension (both sides) when going over small bumps. Most people point to ball joints, but I find my case odd because I just replaced
Upper/Lower ball joints
Track bar
Tie rod ends
Shocks
Front U joints
Drag link
I did not touch the leaf springs or the sway bar, except to grease the links, which otherwise looked good.
Ford Super Duty (1999-2016) :: 2002 Expedition 5.4 Engine To 1997 F250
I have a ford f250 1997 with a 5. 4 triton engine in I bought a 02. 5.4. Out if a ford expedition he said it would fit but my mechanic is not sure . Would the engine out if the 02 fit in the 1997 and what would need to be done.
View 7 RepliesFord Super Duty (1999-2016) :: 2002 F350 - Popping Sound Coming From Exhaust And Lose Power
I have a 2002 F350 with the triton 5.4. For the last week it has been running like crap. I just did my plugs about a month ago. I don't know if it's a miss fire or bad fuel or I don't know what it could be. It's a popping sound coming from my exhaust and when it happens I lose power. It happens off and on. One second it will run fine and normal and the next runs bad. What it could be. Today I just changed my fuel filter and added STP octane boost and fuel injector cleaner. Haven't seen a difference yet.
View 4 RepliesFord Super Duty (1999-2016) :: 2014 F250 - Engine Fan Winding Sound
Why does my engine fan run when truck is cold? I hate it, anoying winding sound. It will run that way for up to ten miles sometimes. My other trucks never did this. This is the 6.2 gas.
View 7 RepliesFord Super Duty (1999-2016) :: 2002 F250 V10 Exhaust Flutter Sound At Shift Points Around 1800 - 2200 Rpms
Is there truely no cure for exhaust flutter on a 2002 f250 V10, bedsides putting on headers??? I have the the sound at shift points around 1800-2200 rpms. Sounds great before and after these points....
View 14 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Engine Running Rough And Vibrating
I have an 02 f250 5.4. I just did the intake manifold. I also changed the spark plugs and the valve cover gasket. Following this I drained the oil and filled it with fresh oil.
It started right up but it felt like the engine was really vibrating and running rough. The check engine light than came on. I don't have one of those tools to diagnose it.
What could be wrong?
Ford Super Duty (1999-2016) :: 2002 F250 - Diesel Leak On The Back Of The Engine
I have a 2002 Ford F2 50 that has a diesel leak on the back of the engine. I've already replaced the drain valve that was leaking. Then I noticed that the front of the engine was dry now but the back of the engine still has some pooling With a very small drip off the back of the engine between the transmission housing and engine. Not as bad as it was of course But still a small drip. Where this may be coming from? And how to fix it?
View 4 RepliesFord Super Duty (1999-2016) :: F250 5.4L - Engine Making Puffing Sound Out Of Exhaust
Here's a link to a video where you can hear what I'm describing. The noise is most noticeable around the start (first 18 seconds) and the end of the video when I'm closest to the exhaust pipe:
YouTube ....
You may need headphones to hear it, but the engine seems to be making a bit of a puffing sound during idle. It happens completely randomly and I'm not quite sure what could be causing it.
Aside from this noise, the engine seems to idle normally, and the check engine light isn't on. I had all of the injectors out a few weeks ago for cleaning. They all appear to be working fine. I also cleaned the throttle body at that same time and ensured there were no obstructions for the air intake and filter.
What might be causing this sound? 1999 Ford F250 Super Duty 5.4L
Ford Super Duty (1999-2016) :: 2002 - Humming Noise Coming From Engine
2002 5.4L... I have a humming noise that comes from my engine and wanted to see if any of yall knew anything about it. I sounds like it's on the other side on the driver side firewall near the brake booster. Once the engine runs for a bit it tends to start then. It'll start to hum then ill tap the gas to get the RPMs up a bit then its gone for couple miles then its right back on.
View 2 RepliesFord Super Duty (1999-2016) :: 2002 F250 V10 - Engine Just Cranks With No Fire Or Even Hint If Starting
Need to diagnose my truck issues. On my 2002 F250 V10, when I try to start it, the engine just cranks and cranks and cranks with no fire or even hint if starting. I am not sure if it has no spark or isn't getting any fuel. I just replaced all ten spark plugs and coils less than 500 miles ago. I want to perform the fix myself, but I need to get the problem diagnose the issue first.
View 8 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Vacuum Leak But No Check Engine Light
2002 F250 SD 4X4 5.4L. 4.5 inch pro comp lift tire size 305/75/R16. K&N cold air set up. 208,000kms
I know the truck does horrible on gas but lately is been getting worse, maybe I am getting 350km to a tank. Mixed highway city driving. Sounds like I might have a vacuum leak somewhere but I have no engine light. I've had the truck since last year and put about 10,000km. on it done regular oil changes .. brake maintenance no motor work so far.