Ford Super Duty (1999-2016) :: 2003 F250 - No Heat And Coolant Flow Restriction
I have a 2003 F250 Super Duty 5.4L V8 with no heat. It wasn't missing, running funny or blowing white smoke out of the tailpipe and there were no coolant leaks nor did it overheat. Thermostat has been replaced twice, heater core flushed twice, water pump replaced, fan clutch replaced and blend door works...Cabin airflow gets colder when turned from hot to cold. This thing is sitting in my driveway and I am about to push it over a cliff. Did I mention it only has 56,000 miles on it?
Coolant was drained to replace water pump and flush heater core (again, water ran through in both directions with no stoppage). 3 gallons of undilluted antifreeze was put into the overflow bottle to be topped off with water...the coolant went in and stopped. Engine was started to force coolant from bottle...coolant backed up into the bottle and out the top. Heater core inlet hose is hot and outlet hose not very warm if at all. Upper radiator hose is soft. Didn't check lower radiator hose as I was a bit peeved and slammed the hood closed and called it a night. I have been throwing money at this thing that I do not have and am at my wits end with it.
Ford Super Duty (1999-2016) :: 2000 - Smelling Rear End Dope - No Leaks?
I have a 2000f 350I have a strong smell of rear end dope I have replaced the brakes and calipers and do not see any leaks why am i smelling a very strong smell....no leaks and pig is full?
View 8 RepliesFord Super Duty (1999-2016) :: Coolant Smell After Driving / Radiator Leak
About a week ago I began smelling coolant after driving my 2012 F350 6.7. Yesterday I noticed a small amount of coolant on the ground and decided to take it to the dealer. As soon as I told the Service Manager what was going on he said......"You need to leave it......there is no doubt in my mind it needs a radiator". They pressure tested and and sure enough it does. He said they are replacing about 2-3 a month but there is no recall.
Here is where it gets fun. Apparently radiators fall off at 36,000 miles and are not included in the 100,000 Power Train Warranty. It gets better. The Radiator is on national back order for 5-6 weeks.
Ford Super Duty (1999-2016) :: Strong Coolant Odor After Driving But No Steam Or Visible Leaks
OK so I have a 2010 6.4 fully deleted. I have noticed that after driving my truck and parking it there is a strong coolant odor but no steam or visible leaks. the truck runs as good as ever and I can't seem to find the source.
View 5 RepliesFord Super Duty (1999-2016) :: A/C Turning On With The Heat?
Just noticed something funny yesterday while flushing my radiator. I have an 04 F350 with the 6.0. When I have the heat set to come out both high and low vents, the A/C compressor also kicks on. The pipes by the passenger side firewall get cold. If I set the heat to just come out high or low, it turns off. This is not with the defroster on. Why does this happen? Is it supposed to happen?
View 5 RepliesFord Super Duty (1999-2016) :: AC And Heat Only Blows Out The Defrost
I bought a used 99 f250 v10, i went to turn on the a/c today, and it only blows where the defrost is toward the window. it gets cold after awhile, but nothing out the vents, the heat either.
View 9 RepliesFord Super Duty (1999-2016) :: Heat Only Blows Through The Defroster
2002, F250, 5.4, ZF6, 140k.
My heat only blows through the defroster. I was looking for my vacuum pump, but can't seem to find it. I find plenty of diesel threads where they show it, but mine isn't in the same location. I can actuate the diverter by hand and it will make the heat stop at the defroster and come out at your feet.
I have attached images of my rig.
Were to look for the vacuum pump? Any key spots to look for failed vacuum lines? What is this?
This is where most threads say the vacuum pump should be.
This switches from defrost to floor when operated manually.
Ford Super Duty (1999-2016) :: Heat Stopped Working
My heater stopped working.
View 9 RepliesFord Super Duty (1999-2016) :: Heat Only Works At 70 Mph But Not While Idling
I have an F-250 Ford, 2006, 6.0 turbo-diesel. Started noticing that my heat only works while running at 70 mph or more and the turbo is at around 15-20 psi. Now that it has gotten cold it is definitely an issue. Truck does not overheat, I am not able to feel heat on the hose after control vlave and I do not feel any vacuum on the line (grey) to the control valve. I have checked for leaks, changed out the fill cap, checked anti-freeze level, pulled control valve just to verify its position when opened (which it seems to stay open). It's getting really cold in the cab of that truck now.
View 4 RepliesFord Super Duty (1999-2016) :: Heat From Hub / Brakes Burning Smell
I have a 2000 F250 SD 4x4. I noticed the other day that after driving the truck for 10 miles or more and then stopping and getting back in it feels like the parking brake is on. I drove the truck home and on my way back I smelled brakes burning but it wasn't pulling while driving or braking. When I got home I put my head in the wheel well to get a look at the brakes on the drivers side it seemed ok, but when I did it on the passenger side it was hot as Hades! It's been my experience that if the caliper is hanging up it will pull either while braking or regular driving. I just want a better idea before I go ahead and buy a new caliper and hose and tear the dang thing apart.
View 8 RepliesFord Super Duty (1999-2016) :: No Air Blowing Out Of Vents Or Defrost For AC Or Heat
I have a 2008 F350 and there is nothing blowing out of the vents or defrost for AC or heat. It doesn't matter what fan speed is set. Would this indicate a blower motor? Where exactly is it located and how to change?
View 8 RepliesFord Super Duty (1999-2016) :: Heat Went Out - Replaced Thermostat And Gasket?
So my issue, had heat last year, turned on first time this year and its cold. So I did some research on the site and have done a few things but still no heat
First thing I did was flushed coolant system and add new coolant as I have 235,000 miles on the truck and it looked rough
Ran the truck for a while and checked heater core hoses, they were both warm, not hot by any means so I pulled the thermostat and replaced the thermostat and gasket
Now the hoses to heater core are both hot and my temp gauge went up about 1/4" higher than it ever has, but still no heat.
Blows fine, just cold or sometimes luke warm. I pulled the glove box back to try and see I I could hear anything when I change from hot to cold and I hear or see nothing. Only movement I see is when changing cycles from defrost, heater, ac... So could this be a blend door issue an how do I get to the blend door, is it behind the big plastic plenum box?
Ford Super Duty (1999-2016) :: Water In Heat / AC Vents After Rain?
Don't get much rain here in SoCal except during the winter. After the last rain I noticed that there was water in the heating/ac vent system - or at least that's where I think it was.
When I made a right hand turn some water slopped out onto my foot and gave me quite a shock for a second till I figured out what had happened.
I suspect that there must be some kind of drain tube for the vent system that's become clogged, but before I start crawling around under the truck and dash I figured I would ask here first. Any useful tip on clearing the clog?
Ford Super Duty (1999-2016) :: Luke Warm Air Blowing When In Max Heat
My manual heat/cold adjustment dial is working fine and transitions from heat to cold readily. However when in max heat, it is blowing luke warm. The higher the RPMs going down the road the warmer it blows (still not near as hot as normal), then idling at stop lights or in park it goes back to warm only.
My engine temperature is running normal at all RPM levels while driving and idling. Partially clogged heater core maybe, where higher RPMs force more water through it? I assume its not the water pump or thermostat since my operating temperature is staying normal...
Ford Super Duty (1999-2016) :: 2006 F250 - No Heat At Idle
Having problems with no heat at idle or low heat in the cab. I just bought this truck a couple weeks ago and have a limited warranty on it. The truck makes no heat at idle. I start it and let it just run, engine temp gauge goes up to normal operating temp in 15 min or so, still nothing from the vents but cold air. If I drive it I get a "little" heat, at idle, cold air again. I believe the thermostat is working because like I said, engine temp stays right in the middle.
Brought it to local ford dealer, their diagnosis was heat core clogged and needed to be flushed, had that done. truck has been running 40 minutes in the driveway now, engine temps nice and warm, no heat. What could be the issue? I took a picture of what I believe are the lines running to the heater core, just barely warm to the touch, not hot by any means. It looks like there is a vacuum actuator on the line running in but there is no hose attached to it, what this it, should it have a line running to it?
Ford Super Duty (1999-2016) :: Losing Heat When Let Off Throttle / Come To Stop?
I have a 06 f350 6.0. I'm losing hear at times. My temp gauge is right in the middle like always. As soon as I let off he throttle or come to a stop the heat turns cold and blows out cold air!
View 2 RepliesFord Super Duty (1999-2016) :: Camera Monitor Keeps Falling In The Heat
I installed a Hopkins back up camera early last year. The original double sided tape that holds the monitor to the windshield didn't hold up long. Tried some of the gorilla double sided tape. A couple weeks max. Then I tried the 3m double sided tape. It would work a month or so. Did good all winter, but now I'm going to have to redo it for a 4th time already this year. It sticks to the glass, it's pulling loose from the plastic mount made onto the monitor.
View 3 RepliesFord Super Duty (1999-2016) :: Heater / Defrost Circuit Does Not Heat Up
My 2006 F-250 SD with 6.0 diesel has some sort of cut-out for the heater circuit, and possibly for the A/C as well. This truck was probably a fleet vehicle for the Houston Port Authority. Didn't really notice this peculiarity until it got really cold outside. If I start the truck up and let it idle for 10-15 minutes the water and transmission temperature get up to the normal operating ranges but the heater/defrost circuit does not heat up. Cannot defrost the windshield.
If I drive to the end of my driveway, about 600 feet, the heater/defroster starts putting out good heat. When driving, if I have to stop at a stoplight, or any other pause, with the truck still in gear, the heater output starts to cool down. I suspect that this feature was incorporated in the circuitry at the factory to prevent the driver from sitting still to keep warm. The truck MUST BE MOVING to allow heat or defrost to operate. The blower motor operates and it doesn't matter if the truck is in gear or not.
Ford Super Duty (1999-2016) :: Motor And Exhaust Bog Down For A Few Seconds When Turn On Heat
I have a 2001 f250 5.4 that when you turn the heat on the trucks motor and exhaust bog down for a few seconds then comes right back up...
View 4 Replies