Ford Super Duty (1999-2016) :: 2004 - Burning Smell And Shut Down - Stalls While Driving?
I have an 04 f250 with a 5.4 I smelled something like burning and the truck shut down. the fuse panel was warm. after a min or so it starts back up never know how far till it stalls again.
View 4 RepliesFord Super Duty (1999-2016) :: Glow Plug Light Comes On And Power Shut Down While Driving
I have a 2003, f-350, 6.0L with a K&N Filter. While driving the glow plug light comes on and the power is shut down. After a few seconds the power comes back and it won't do it for a while. No codes. I replaced all of the glow plugs and wires. What's causing this?
View 3 RepliesFord Super Duty (1999-2016) :: 2008 F250 - Lost Power While Driving Uphill At 60 MPH / Shut Off / No Start
While driving up hill at 60mph the truck lost power. Rpm jumped up as to change gears as it hit 55mph. Still losing power until it shut off. I tried to restart and just got a click from the solenoid. No engine codes whatsoever. Battery had 12.1 volts but when turning the key to start in getting 8 volts. Had it towed home. Today I swapped batteries with my other truck and same click noise from solenoid. All lights, radio, ect still work. Where should I start? Alternator, fuses...?? 2008 f250 5.4 ...
View 12 RepliesFord Super Duty (1999-2016) :: 2008 F250 5.4L - Gauges Will Randomly Start Jumping Around Then Truck Will Just Shut Off While Driving
So I'll be driving down the road and the gauges will randomly start jumping around then the truck will just shut off, this just started a couple days ago, it seems to be gaining in frequency, when i try and restart the engine all my warning lights flash on and nothing happens, try again and it starts back up, now the last time it happened all of the above happened but it was followed by a fast clicking noise from under the steering column, it has to be a electrical issue as i have full tanks and motor is in tip top shape. Also no codes pop up with my code reader.
View 1 RepliesFord Super Duty (1999-2016) :: Cruise 2x Would Just Shut Off
Did a 1600 mile trip and noticed that the cruise 2x would just shut off. Most of the time tho it ran fine. Every once in a while when I would stop for gas and turn off the motor the cruise would not come on at all when we headed back out. Sometimes when it did this it would not come back on till I shut off the truck and then restart. Other times it would work after 20 or so miles.
When it did shut off or not come on, I would try turning it on and off, mashing the buttons HARD, What to do? Or should I just take it to the dealer and be done with it?
Ford Super Duty (1999-2016) :: Blower Fan Won't Shut Off?
Ok, I have had this problem a couple of times before, generally when it is wet and cold outside and the result is a very dead battery. The heat/ac blower fan continues to run after the truck has been shut off and the key removed. I believe that it even comes on after the truck has been shut off. What could be causing this?
View 14 RepliesFord Super Duty (1999-2016) :: 2002 - Way To Shut Off Dinging?
I just bought myself an '02 F-350XL 4X4 with a 7.3l, love the truck, but I've got an issue. When you first start the truck and the chimes go through their little ditty, about 3 seconds later they go off again.. but this time they chime five times and cycle five times, so a total of 25 times over a certain period.. seems to do it about every half hour, could this be related to the clock somehow? The truck is bare bones basic, XL trim level Reg cab, Auto with tilt, cruise and A/C, oh and the premium stereo...
View 4 RepliesFord Super Duty (1999-2016) :: F250 - Horn Won't Shut Off?
Okay so I have an e99 f250 7.3 the problem all started went I hit a puddle the other day. My horn started going crazy and wouldn't shut off so I had to pull the fuse and relay. After that I found another problem, all my dash lights,headlights and running lights will not turn off unless I pull the battery terminals, it does not matter which way the headlight switch is it can be on or off and they stay on. I did find it though if I pull the negative terminals and put them back on the lights stay off if I turn the switch on and try to turn the lights back off with the switch they stay stuck on again untill I pull the terminals what could be the problem I've looked at every fuse and can't find the probelm.
View 8 RepliesFord Super Duty (1999-2016) :: Truck Shut Off When Hit A Pole
I already reset inertia switch but it still wont start is there a way to by pass the inertia switch...
View 5 RepliesFord Super Duty (1999-2016) :: ABS And Brake Lights Came On And Will Not Shut Off
So I went to start my truck today (1999 f250 5.4), it hasn't ran in a couple days due to -38C weather. When I started it today, it started rough(understandable in this weather) but my abs light and brake light came on and will not shut off. It ran fine the last time I used it, but now the lights came on. What may have happened.
View 3 RepliesFord Super Duty (1999-2016) :: Radio Does Not Shut Off When Doors Open
I have a 2004 F-250 SD, Crew Cab, 6.0L diesel. Out of the blue, when opening the door with the key off and out, the dome lights stopped working, the radio wouldn't shut off and I would get no warning that I had left my lights on (nor any other warning coincident with the door opening). Just as if the truck is not detecting the door being opened.
One would immediately suspect the door switches, except that this was a suddenly occurring problem that affected all four doors, by sheer odds, pretty much negating this problem as one to do with the door switches. Still, I did spray the switches with WD40, couldn't hurt, right?
I have replaced relays (#306) with known good relays, I have pulled and looked over every single fuse. I have read of door post wiring issues with F-150's that speak to this issue for that model, but am not convinced that translates to the F-250. I'm at a loss, and almost perfectly convinced this is a computer problem (the GEM, though it's called something different now). But before I go replacing expensive computers, I would like to know how to diagnose this.
As it is, I've learned to live with the fact the radio will stay on when I get out of the truck and will time out after 10-20 minutes. I've learned to live without the dome light coming on and have counted my blessings when the foresight of some engineer saved me from a dead battery by knowing that I would leave the manual dome light switch on from time to time. I've learned to look back at the truck to make sure I haven't left the headlights on. In other words, I've learned to live with this problem.
Ford Super Duty (1999-2016) :: 2006 - Shut Off Immediately Now Won't Start?
My 2006 6.0 shut off immediatEly after starting this morning and never started back up. I have a scan Guage 2 hooked up. I'm showing no ficm voltage and no sync even when cranking. I physically checked the ficm voltage with a dvm at the screw to the far right on the ficm, and I have 48 volts. Why do I have 48 volts at the ficm, but 0 volts showing on my scan guage? And no sync when cranking?
View 4 RepliesFord Super Duty (1999-2016) :: 2002 - Shut Off After Running About One Hour
2002 Ford F350 7.3...
After replacing the Glow Plug Module and the cam sensor. I have no codes on the scanner. However, after driving the truck for one hour or two it stalled and after cool down about a while t started and stalled after hot. Now I been reading lots of info and this is what I got so far.
Flow Sensor
Fuel injector control
Fuel pump
And one person said that he change the wire harnesses for glow plug on top of the head covers?
Ford Super Duty (1999-2016) :: Truck Rolls When Shut Off And In Gear
I am new to the site and my 1999 F-350 4x4 7.3 manual. I parked on a hill and noticed the truck would intermittenly roll an inch at a time while in first gear and shut off. The parking brake does need adjusting and/or replacing. I also found a re-call for the p-brake cable that i have an appt. for. What i am not sure of is that the clutch is slipping while parked and needing replaced or what it might be.
View 14 RepliesFord Super Duty (1999-2016) :: 2006 F250 5.4L V8 Hisses After Shut Down
I bought this truck used and it is my first F-250. I took it to the shop last week and they found a few things and a cracked radiator was one. They replaced the radiator with a new one. I heard the sound before the new radiator and I still hear it now. The coolant level is not dropping and the engine is not over heating (also no fluid on the ground). Is this a normal cool down sound?
View 6 RepliesFord Super Duty (1999-2016) :: Power On And AC Blows When Shut Off The Truck
My truck is a 2000 f350 with a 7.3 init but when I shut it off and open the doors the power is still on in the truck and ac blows then shuts off. Relays are going crazy and I can not find the problem.
View 7 RepliesFord Super Duty (1999-2016) :: Cranks But Won't Start / Backfired Then Shut Off
I have a 2002 F250 super duty 5.4 XLT 4x4. I got home turned it off went to move it and it cranks but won't start. I sprayed brake cleaner in the intake and it started for a few seconds, back fired then shut off. Where is the fuel pump relay? Or how can I power the pump to test it? All the fuses are good, I swapped the relays under the hood with each other and still nothing. The fuel pump shut off switch is not tripped. Is their a way to test it?
View 2 RepliesFord Super Duty (1999-2016) :: 2005 6.0 Shut Off Then Fired Right Back Up
After a long day at work, I had the pleasure of driving home in traffic. While sitting there enjoying the last of the warm weather, I tapped the brakes to slow down and then the truck shut off. I looked down and naturally the battery light came on. I pulled over, turned everything off, then tried to start the truck. The truck fired right up and all indications were normal. The scan gauge showed no codes and batt voltage was normal at 13.3 volts. Where to start looking? Drive home without any faults for the next 20 minutes.
View 2 RepliesFord Super Duty (1999-2016) :: Vacuum Pump Doesn't Shut Off In 4x4?
So my auto locking hubs have not been working for a couple years and I have just been locking them manually as needed. But now I have a boat and I like putting the truck in 4x4 at the landings just for added safety. It's difficult to manually put the truck in and out of 4x4 for just a few minutes when I know I have auto hubs. Plus I recently got aftermarket rims and they cover the manual locks, which can be accessed with a screw driver, but again, tough.
So today I bought the vacuum solenoid valve, whatever its called, and installed it, and they work! But the vacuum pump will not shut off while the 4x4 is engaged. The auto hubs work, my a/c controls work, everything works fine, the only symptom is the pump not shutting off. My a/c stays right where I put it, it doesn't go into defrost or anything, not even for a second, like it used to when my solenoid first started failing. Is the pump running normal? Or is there a leak on the other side of that solenoid? Should I even worry about it if everything else is working?