Ford Super Duty (1999-2016) :: 2004 F450 - Loud Click Almost A Bang When Cruise Control Shut Off
I've got a 2004 F450 that I'm loving, but suddenly having an issue getting it into gear. To get it out of park and into another gear I've got to turn the key a little father towards start (somewhere in between normal after start position and actually engaging the starter) and then the column shifter will actually let me get out of park and into another gear. Once I've done this there is no problem moving between gears. Last, this has to be related since it started at the same time - when I'm in cruise control it takes a greater amount of force on the brake to get the cruise control to shut off. When it finally does, it makes a loud click, almost a bang. If I only lightly push on the brake it won't kick off the cruise control and the engine will increase power to keep the speed and fight me on the brake.
View 1 RepliesFord Super Duty (1999-2016) :: Cruise Control Has Quite Again?
02 E450 Super Duty V10, C class a motorhome, 29000 miles. Cruise stopped working a month or so back. I searched this forum and managed to fix it with the info provided. It turned out to be the pressure switch on the master cylinder, the recall had been done. I replaced the pressure switch and the harness with an aftermarket one from the local auto parts store. It worked well for about 200 miles, it knocked off again on our road trip last week. It was working on the road and we stopped for breakfast and it didn't come on again, no light in the dash or anything.
When I ran the internal diagnostics on the first repair all the lights would flash when the buttons were pressed and the servo would cycle through at the end of the test as it should, based on the diagnostic instructions. This time when I run the diagnostic test the light will flash when I first turn the switch on (holding the off button down) and when I push the on the button but will not flash when I press the other 3 buttons.
I have not been able to find a wiring diagram for this particular truck, I've found 6 or so but none of them match my fuse boxes under the hood and dash.
I have no trouble lights on in the dash CEL or ABS. I'm at a loss what direction to take from here.
Ford Super Duty (1999-2016) :: Disable Cruise Control With IDs?
I have a newer 2012 f250 that i souls like to disable cruise control on, can this be done with auto ingenuity, our will the dealer have to do it with ids?
View 3 RepliesFord Super Duty (1999-2016) :: Cruise Control Won't Work?
New problem with my 99 f-250 superduty supercab 4x4. Cruise control does not work. Checked all fuses and all are good. No cruise light or speed cont light . Where do I start? What do I need to look for? Where do I look?
View 4 RepliesFord Super Duty (1999-2016) :: Cruise Control Become Intermittent
I've got a '08 F250 XLT that the cruise control has become intermittent. It works most of the time but at times it will "go out to lunch" and not do anything. I've taken the controls from the wheel and didn't see any gummed up coke spills or anything there. It may not be anything but twice when it failed while on a trip I pulled over and shut the truck down. Started it up and the cruise would go back to working. Once I did this and it went back to working only to shut off in about 2 seconds but I was able to engage it again and it kept working. When it stops working there is no green indicator on the dash either.
View 9 RepliesFord Super Duty (1999-2016) :: Adding Cruise Control?
My 1999 SD was originally a Work Truck without cruise. I'd like to add cruise of some sort (factory or after market), but also trying to keep the cost and difficulty factors low.
Have any of you SD drivers ever done this and if so, what you went through?
Ford Super Duty (1999-2016) :: Cruise Control Dropped Out
Suddenly my cruise control dropped out. With some investigation I'm pretty sure it's that sensor or switch stuck to on position. Brake light is on. Checked the brake system and everything works well. Fluid is full all 4 pads replaced 2 days ago. Plenty brake power.
The question is: how can I bypass that switch to get my cruise control back? I see 4 wires coming out of the switch: red, blue, green, red/orange, green/purple. How do I do it?
Ford Super Duty (1999-2016) :: Shut Off While Driving?
Strange thing happened today while driving down the highway while towing my camper. I was going down the road with the cruise control set at 65 mph and I looked at the dash and I had no tach, speedometer or gauges. The dash was blank. The radio was still playing and I was just coasting to a stop. When I finally pulled to the side of the road, I put the truck in park and turned the key to the off position. Turned the key and it started right up and ran fine for the next 2 hours on my trip. I had been towing for about 3 hours before the truck shut off. Don't want this to happen again as I'm towing back home from FL to CT.
View 14 RepliesFord Super Duty (1999-2016) :: Blower Fan Won't Shut Off?
Ok, I have had this problem a couple of times before, generally when it is wet and cold outside and the result is a very dead battery. The heat/ac blower fan continues to run after the truck has been shut off and the key removed. I believe that it even comes on after the truck has been shut off. What could be causing this?
View 14 RepliesFord Super Duty (1999-2016) :: 2000 - No Cruise / Horn Alarming?
Been searching but can't find a clue. I replaced my steering gear box. Went fine, but after starting back up. My alarm goes off, my cruise or horn doesn't work and my air bag is giving a code 32.
Is there a ground wire or something I could of missed when installing the gear box?
Ford Super Duty (1999-2016) :: Cruise Control On / Off Button Is Sticking
Just noticed today that my cruise control on/off button is sticking. Push to off it stays pushed off, push it up to on and it stays up so i must physically center it myself. Is there a way to remove the button and take it apart to clean and regrease the contacts so it doesnt stick? Kinda dumb actually since i might have used it eight or ten times since buying the truck new....
View 2 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Cruise Won't Power Up
Cruise won't power up. Tried entering diagnostics but did not get any flashes. By-passed switch on master cylinder, did not make any difference. Horn honks. Brake lights work correctly.
View 9 RepliesFord Super Duty (1999-2016) :: 2014 - Within 2500 Miles Cruise Goes Out?
2014 f250 with 2500...My cruise went out on my new platinum. Cruise symbol comes on, goes green when I hit set but will not hold speed. I know this would be an easy warranty fix but here's my problem. My regular local dealer, which I bought my 3 fleet truck and all personal autos from didn't get this sale. In fact he was 5k higher then the dealer 120 miles away and I brought him written proof. He was very angry and down right rude when I nicely told him I couldn't pass up 5k. He told me that was just bad business by the other dealer and hung up on me.
View 10 RepliesFord Super Duty (1999-2016) :: Hesitation Or Miss When Using The Cruise Control
2010 f250 cc 5.4 145000 miles. I bought it last fall have not drove it a lot. When using the cruise control and a load is added grade or hill in the roadway. It jerks hesitates or miss then cleans up and runs fine. When using the accelerator it does not do this. No codes.... Thinking about changing the plugs.
View 5 RepliesFord Super Duty (1999-2016) :: 2003 - Cruise Control Not Working
Just bought the 03 listed in my signature line, and I just found out that the cruise control isn't working, so started trying to troubleshoot anything obvious.
When I switch it on, I get no cluster light that the manual shows to be to the right of the brake light. When I turn the key to run, it never lights up, so am guessing the bulb is bad.
Can't see how a bad bulb would keep the system from activating, so am thinking I have bigger issues. I pulled the fuse panel, but the manual does not have a listing for speed control. Which fuse it is combined into?
Also need the skinny on how to change the bulb. Can I reach my hand behind there? does the cluster have to come out?
Last question. What is the most likely culprit for non functioning cruise? A module? Perhaps the switch in the steering wheel?
Ford Super Duty (1999-2016) :: 2014 - Cruise Was Set To 62 MPH And Truck Kept Downshifting
Came over the "mountain" tonight elevation is 1,054 (Snickers Gap) anyway cruise was set to 62mph and the truck kept downshifting. Got to 2nd gear about 5500 rpms and was trying to hold 62mph. I turned off cruise and it stayed in second and picked up speed still in second, I finally tried some braking and some acceleration with the gas pedal and it shifted up through to 6th. Truck has 6.2L and 3,300 miles on it. I wasn't really afraid of wrecking or anything but I was convinced it was going to redline in 2nd, it didn't but it was really loud. I was about 10-15 seconds from throwing it in neutral.
Additional info: I have driven this road for 14 years, with cruise control on in everything from a geo metro, (2) different 2010 f-150's 4.6 and a 5.4, ford escape hybrid, and many other vehicles. This is probably the 10th time I have taken the new F-250 in to the city and back it has never reacted this way before, but I have notice it downshifts more than I expect in other situations as well.
So is the downshifting what others are seeing?
6.2L Supercab, longbed 3.73 gears.
Ford Super Duty (1999-2016) :: 2000 - Cruise Control Won't Working?
Our cruise isn't working, I've read through the posts here and tried a few things
2000 F-250 V-10
-First symptom was the cruise light would light with the ON button and go off with the OFF button but I could not set the speed with the SET button. Now the cruise light hardly comes on at all any more.
- I've run the cruise self-test diagnostics and all the switch presses passed with no additional light blinks. After the static test the speed control servo makes a sound but does not move the throttle at all.
-The horn works
-Fuses are good
-Truck was taken to the dealer several years back for the cruise update. The pigtail with the green label is installed at the master cylinder. I've disconnected both connections and sprayed with contact cleaner.
That's about it. What it could be or what to test next?
Ford Super Duty (1999-2016) :: Noise Noticeable When Cruise Down The Highway
02 f250 SD 5.4 zf6 manual xcase ext cab long bed...
When I'm cruising down the highway it's most noticeable. 5th gear anywhere from 65mph+ I'll let off the gas and it'll make a "errrRRRt" until I press the gas again. I've recently installed new :
- Front u joints, ball joints, hub assemblies, rotors, calipers, pads
- Rear drive shaft u joints
- Front diff fluid
- Trans fluid
- Tcase fluid
- 4" zone lift kit
All of these things did nothing to effect the noise. it seems to be coming from between the clutch and rear shaft (either clutch, trans, tcase). I don't think it is a motor noise or suspension noise.
Ford Super Duty (1999-2016) :: Cruise Control Isn't Maintaining Speed
I was driving home from school last week and noticed my cruise control would stay set for 5 minutes or so, then slowly (over several minutes) lose speed. I've noticed it happen before, but very infrequently and usually if I stopped to use the restroom, when I started the truck back up it was fine. This time it continued to happen.
As I was getting nearer to home, I noticed that while I had the cruise set, I would hear a high squeaking noise in the dash almost dead center under the radio. Then , when I would tap the brakes, there would be a rattle. This would only happen with the cruise set.
Noise in dash - YouTube
Not sure how well the squeak can be heard, but the rattle is definitely audible. What the cause might be? Electrical, mechanical, are the cruise and the noise even related? Other than that, the truck seems to be running alright.