Ford Super Duty (1999-2016) :: New Long Block / Truck Still Smokes When Cranked
I have recently placed a new shortblock from Nashville engines. My retired ford diesel mechanic said it was the best shortblock he has ever seen. Since working on my truck he has ordered 6 small block from them. I used reman'd Ford heads after going through three sets of heads from Clearwater heads and one set from ProMaxx Cylinder Heads out of rainbow AL.
Since putting in new long block the truck smokes a puff of white smoke each morning. Enough smoke that it bothers me. A new longblock with new injectors should not be smoking. I have changed the fuel filters thinking the 5 sets of heads previously put on the truck may have gummed the motor up and have ran octane boost for the last 500 miles. I ran a 2000 mile road trip and the truck still smokes when cranked. sometimes a lot and sometimes a little. What could be causing this?
Ford Super Duty (1999-2016) :: Battery Light Comes On / Truck Started On 6th Try
2005 F-350 6L diesel .... Put new batteries in it a week ago.
Been running good then the radio quit a couple of times. It came back on after truck was restarted. This morning I go to town and the battery light comes on. I stopped and started about 5 times and on the 6th it wouldn't start.
I got a boost and started home it , started to try and quit when I was almost home. Was so dead the power windows wouldn't even work. Have it on the battery charger now and it starts right up but the battery light is still on and the ABS light is on.
Ford Super Duty (1999-2016) :: Battery Light Came On - Truck Died On Highway
Driving down the highway, battery gauge read fine power, but battery light came on. In a remote Alaska situation so I couldn't diagnose, plus truck is new to me. Kept driving towards civilization. All gauge dropped. Then lights dimmed, then truck died. This was over about 15 miles. At night with lights on. Truck has a plow with plow lights, aftermarket cranking stereo which I was using, heater on (Alaska). It sits 70 miles up the highway from where I'm at getting ready to go back and work on it. So...
Of course first thought it is the alternator, not providing enough power for all this. Looked inside, it is a newer looking reman. Belt is fine. My question is, if not this, what else could it be? I'm hoping to haul the alternator and whatever else out there and get it going without having to drive back and forth for more stuff I need. I can always return stuff I don't use. Probably I'll throw a new battery in it as well. But after that, anything else I should be thinking/ready for?
Ford Super Duty (1999-2016) :: Truck Starts Turning Over Without The Key When Hook Up Cable To Battery
When I hook my battery cable up to my battery when negative cable my truck automatically starts turning over without the key in it what could be the problem
View 1 RepliesFord Super Duty (1999-2016) :: 2005 F350 - Truck Seemed Slow To Turn Over / Battery Dead
I bought a 2005 F350 in January of 2012. At the time of purchase, I noticed that the truck seemed slow to turn over. I talked the dealer into installing 2 new 750 CCA Ford batteries at the time of sale.
I have put less than 7,000 miles on the truck since the day I bought it. In August of 2012, I went to start the truck and the batteries were completely dead. I charged them, started the truck, and the next day the truck was dead again.
I took the batteries out, and took them to the dealer. They replaced both of them under warranty. They said that after they charged them, each tested at less than 85 CCA.
In July of 2013, the same thing happened. I used the truck one day, and then the next day the batteries were completely dead. I had them tested at the dealer, and the passenger side battery failed the test. The driver's side passed. They replaced the passenger side under warranty, again. This time, they also cleaned all battery / ground connections and tested the charging system. Everything passed.
Last week, I went to start the truck. Same thing again. Took the truck to the dealer, and both batteries, after charging, failed the test. They replaced both batteries under warranty.This time, on each battery, the dealer had written with yellow paint pen on the batteries AND on the radiator shroud "BATTERY NOT UNDER WARRANTY."
I asked the dealer about this, and they said that since they have replaced 5 batteries in the truck, and since it has 152,000 miles on it, the warranty is no longer valid. I argued that since they have checked the truck thoroughly, and found no issues with the charging system, they can't void the warranty like that.
So, what is the reason why the batteries would fail like that, and that frequently?
Ford Super Duty (1999-2016) :: Idling At Startup Make Truck Deliver Power Smoother / Battery Light Stays Off
I would like to know what's happening, it seems as if idling for a minute to let my transmission temperature dial raise past the lowest line on the dial fixes or at least drastically reduces a couple issues.
The truck will deliver power much smoother off the line. I've been concerned about this for a while. The degree to which it happened wasn't constant but it seems like the truck is having trouble grabbing on (so to say) to the power coming off the line. I sort of liken it to a rope. When I give it the beans the rope goes forward but it takes a half a second or so for the truck to "grab" on to the rope. Never hard shifts, it's just delivering the power off the line or from a near stop.
Idling for a minute seems to fix this, power delivery is smooth off the line. Transmission dipstick was nice and pink but smelled slightly burnt. This is with the engine cold overnight. Didn't have time to do multiple wipes or check in the handbook for the proper methods of checking fluid, I just pulled it out quickly to take a look before heading out. Fluid covered the whole tip.
Second issue that seems to be fixed is that the battery light doesn't come on nearly as much and not for nearly as long. Typically the battery light will come on and off seemingly on its own whim during the drive. However, it seems to stay more consistently off if I idle right after startup.
Now bear in mind I baby my truck, I don't rev it high right after startup. Just low enough to cruise around the parking lot until I hit the road then I accelerate up to 40 - 60 depending on my route. I'd gladly give it the minute to warm up in the future but if I could get down to the bottom of this that'd be preferred, I doubt this is required behavior.
I do realize that these issues are not tied to startup behavior but I find it interesting that idling for a minute at startup to let the transmission gauge rise seems to mitigate these symptoms.
Ford Super Duty (1999-2016) :: Broken Exhaust Manifold Bolts - Long Term Fix?
I've got the dreaded broken exhaust manifold studs on my 2004 F250 V10. I don't drive it much (just 50,000 miles in 10 years) and confess I've ignored the hissing for quite a while. Is there really a permanent fix for these broken studs? Or should I expect to be replacing broken studs every 2 or 3 years?
If there is a permanent fix what is it? Special studs? Special manifold? I want to keep this truck a long time and don't want to be replacing these studs every few years.
Ford Super Duty (1999-2016) :: 2001 - Long Hard Starts No Matter What The Temp Is Outside
My truck is 2001 F250 with the 7.3 I have AFE intake, TS 6 position chip, Stage 1 Auto Tranny, 4in Exhaust all the way down. New glow pugs as of last week as well as uvchs and gp relay. Also has a new hpop line. New compression sleeves for fuel lines, riff-raff fuel banjo bolts and fuel pressure regulator.
I am having a hard start issue no matter what the temp is outside, unless it plugged in. Once it starts its good unless it sits for more than 5 hours.
Batteries have tested good, glow plugs ohm at 1.3, gpr 12.83 at batt side- once on it 11.9. All fuses are good. HPOP res is showing at about 3/4" down from top.
***Wires going to the MAT sensor are showing through at the connector, not sure if this could be a problem...if so why???
****Noticed some oil in the ICP, cleaned and unhooked will check start tomorrow to see if this works with long start as truck is plugged in.
Will also be putting a new fuel filter in and double checking oil level in the am. I do not have a scanner tool and am doing the best I can before I take it in to ford to diagnose.
Ford Super Duty (1999-2016) :: Stumble And White Smoke At First Start Up After Sitting For Long
The last couple weeks my excursion had started to have a stumble and smoke white ate the first startup or after I let it sit for a long time. I did get progressively worse. I noticed the hpop line to the driver side head was leaking from the fitting so I rebuilt the boss fitting and now it's not leaking but when I started it up this morning it did the same thing.
If I give it throttle it clears up pretty quickly but if I let it just idle it will put white for probably 5 minutes. I have no codes showing when I looked with the scanner I don't see any other oil leaks and I don't smell a fuel leak.
Ford Super Duty (1999-2016) :: Long Crank When Parked Facing Downhill Intermittently?
I am having some intermittent long cranks when parked facing down hill (even very slight downhill). It seems like it only happens cold and is worse when parked for longer. Truck has all updated parts under the hood and is under warranty for another month. I would like to know where to start diagnosing (what would cause this symptom) since I'm sure it won't do it when I take it to the shop right before warranty is up for one last go over.
View 2 RepliesFord Super Duty (1999-2016) :: 2012 F250 - Long Pedal Travel When Applying The Brakes
I took delivery last week of a new 2012 F250 with a 6.7 Power Stroke Diesel. This is my third F250 with a Power Stroke Diesel. My first one was a 1997 w/7.3 PSD and my last one was 2001 w/7.3 PSD which I traded in for the 2012.
Now for my problem. The brakes seem spongy to me. When I am applying the brakes I get what seems like a longer than normal pedal travel (to me anyway) and soft. The braking isn't as good as my last two F250's. If I pump the brakes, the brake pedal firms up and the braking really improves. I have not contacted my dealer yet.
Ford Super Duty (1999-2016) :: Long Term Negative Effects Of Heavy Condensation In Engine?
I only live 6 miles from work and I've been getting a lot of condensation gunk building up inside the filler cap and around the neck. Is there going to be any long term damage from this? Here is a picture of what I'm getting.
I know it's not coolant because I'm not loosing any and the oil on the dipstick is clean.
Since it got cold I've been taking another route to work that gets me up to 9 miles one way. Also, twice a week I take the long way home that has the engine running for a half hour but I'm still getting build up. In the winter I'm on call a lot and rarely go far from home so taking a two hour trip to really heat things up is probably not going to happen.
ETA. I change my oil every 3000 miles if that makes a difference.
Ford Super Duty (1999-2016) :: 2001 V10 - Sudden Power Loss After Sitting In Long Traffic Jam
My excursion suddenly lost power after sitting in a long traffic jam. I have a scan gauge II set up and didn't see any signs of over heating however when I went to accelerate back up to highway speed my motor revved up to 3000 rpm and just lost power I ended creeping on the side of the road at about 15 mph and barely maintaining that. The motor was not willing to revv up. I reached a spot to pull over and shut it down for about 15 minutes and started back up and drove off with no noticable issues. I have 211,000 miles on this motor and I am going to change my coil packs, I think they have been there since the truck was sold new....I changed four of them to address a miss and have six left, I will also be changing my fuel filter. We are about to pull our camper across country....about 1400 miles..
View 5 RepliesFord Super Duty (1999-2016) :: 2006 F350 - Long Cold Starts / IPR Is Maxing Out At 85% On The Gauge
I have an 06 F350 6.0 and I am having long cold starts. On the gauge the ipr is maxing out at 85%. This only happens when cold and have never had a no start issue. When hot the engine cranks right up and the ipr stays in normal range. FICM has been replaced. Does this sound like needing a new ipr only?
View 4 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Pedal Slowly Go To The Floor When Hold Down Brake For Long
I don't know what's going on maybe some body can shed a little light on this. If you hold the brake pedal down for a long period of time you can feel the pedal slowly go to the floor. So no problem I'll change the master cylinder bleed everything brand new fluid. Don't drive it much we let the sister in law drive it we'll I jump back into it the other day to go to Home Depot and once again I notice it still does it. Could the hydra brake booster be bleeding by or what's else could be causing this it's driving me insane. I really can't imagine the hydra booster causing a problem but it's new to me. I was thinking about bleeding the brakes again thinking there maybe there's air but I have run 2 bottles of brake fluid through how much more??
View 8 RepliesFord Super Duty (1999-2016) :: Truck Turns Over With No Key
Last night I was watching tv when my truck tried to start I thought I hit the remote start on my keys but it didn't start which I found weird. I went down stairs too see if it did anything else and it did it again it would turn over and turn over but never fire all while the keys are in my hand. At the same time the done light was stuck on and the radio went on and off. I'm pretty sure that my GEM got wet through the windshield, also Is the GEM dead or can it dry out and be ok
View 12 RepliesFord Super Duty (1999-2016) :: Truck Will Bog Down And Sometimes Die When Put It In Gear
I have a 2001 f250 7.3L. I bought it with 192,000 miles and have driven it to 206,000 in the last 6 months. When I put it in gear, the truck will "bog" down and sometimes die. I will have to refill the transmission fluid every 2 weeks but I can't find where it's leaking.
View 4 RepliesFord Super Duty (1999-2016) :: 2005 Truck Won't Shift In Or Out Of 4Hi
My 05 superduty is in the shop because it won't shift in or out of 4Hi. Ford garage says I need a new transfer case shift motor, and 4wheel drive module. They said the shift motor was full of oil. I am not really up to speed on how the shift motor works, other than it bolts externally to the transfer case, that's why it confuses me about the shift motor being saturated with oil. My truck has never leaked even a drop of any type oil, ever.
View 6 RepliesFord Super Duty (1999-2016) :: F350 Truck Won't Go In Park
All the sudden got home and now my truck wont go in park. All other gears are fine. My PRNDL on dash has always been off for the last 3 years park has always shown as reverse its never affected anything! I already checked the torq. bolts and that was not it. My shifter is very sloppy so is my steering wheel. I found a 00 whole steering column with wheel and shifter but its not a early 99 will it work or fix my no park. The guy didnt know if it would fit early 99 or my no park problem.
View 2 Replies