Ford Super Duty (1999-2016) :: Headlights Coming On Automatically After Rain
F350 1999 7.3L. It seems this only happens after a rain but the headlights have been coming on mysteriously by them selves without any contact with the vehicle. I woke up this morning with my headlights on. This has happened a few times in the past and I turn the light switch on and off a few times and then they shut off. This morning I did that but after a few minutes they came back on again. Where do I need to look? Relay? Switch? Dimmer Switch? A mystery.
View 1 RepliesFord Super Duty (1999-2016) :: Headlights / Dash Lights Are Blinking Or Flashing Repeatedly While Driving
2002 f350 ext cab. Having an issue where my lights are blinking or flashing repeatedly while driving. Or whenever really. Truck running or not. Auto light switch in any position. I can hear what I believe to be the under dash circuit breaker clicking on and off. If I turn my light switch to the on position, breaker still clicks but lights remain steady. Where to start looking? Bad wire? Bad switch?
View 1 RepliesFord Super Duty (1999-2016) :: Heavy Duty Rubber Floor Mats With Transfer Case
New floor mats. My truck is going to be 10yr old and has the original King Ranch floor mats. I want some heavy duty rubber ones that will fit around my manual transfer case lever. I ordered the Weathertech digital fit liners and I am not happy with them so they are headed back tomorrow. They have a heavy duty all weather mat but not sure how it will work with my shift lever on the floor. Husky liners/mats look nice and heavy duty but won't accommodate the floor lever.
View 6 RepliesFord Super Duty (1999-2016) :: Difference Between F250 Custom And Heavy Duty Steering Stabilizer?
Is there a steering stabilizer for a 92 Ford F-250 custom 2wd? and what's the difference between a f250 custom and a f250 heavy duty?
View 2 RepliesFord Super Duty (1999-2016) :: Vibration At 70 MPH / Heavy Rumbling
I have an issue with a truck I recently purchased. I have a vibration that starts around 50, feels like a wobbling vibration. Than once I hit 75 it feels like the truck is going to fall apart. Heavy rumbling.
It's a Ford F-350 dually extended cab. With 115,000 miles on it.
I took it to the shop to balance out the wheels and all the wheels needed atleast 2 oz of weighs on each side. Some have as much as 4.75 oz on one side. Is it possible that I need 6 brand new rims?
Ford Super Duty (1999-2016) :: Alternator Light Come On Occasionally But Never Constant
My trouble is that the alternator light on my 2004 F-250 Diesel began to come on occasionally, but never constant. Taking in the fact that it was still the original alternator, and over 70,000 miles, I figured it was time for a new one. I installed the new one and after two days the light came on again. I tested the alternator and it read 13.84 volts while running. With the engine shut off, I had 12.59, and 12.6 volts at the batteries. What may be my problem? Diesel down.
View 8 RepliesFord Super Duty (1999-2016) :: F250 V10 Shuddering At Constant Speed
I was running my 99 F250 SD with the V10 around the DFW area pulling a car hauler with a Jeep on it. The last 50 or so miles on the way home she started shuddering at a constant speed unless I turned off the overdrive or I was accelerating or slowing down.
She's never given me any issues but this is bothering me. 4x4...
Ford Super Duty (1999-2016) :: New Rotors / Pads But Constant Squealing?
I've replaced the pads and rotors on my 97 f250 HD, only to have constant squealing. I've replaced ranger rotors before with no problem but this has been an adventure. It's squeals constantly up to 35, (I've only went up to 35) and squeals louder under braking. Just looking for some pointers. Probably just need a good cleaning. The truck is parked until its fixed more than likely.
View 6 RepliesFord Super Duty (1999-2016) :: V10 F250 Not Cranking After Rain Storm
So, back in July I had some issues with my V10 F250 not cranking after a bad rain storm. (New battery was installed May 2011) and ended up recharging the battery & replacing the alternator. Have not had any problems since until yesterday as I was going to use the pickup. I drove it on Thursday with no problem and Friday Tropical Storm Lee came in with TONS of rain. Now NOTHING AGAIN. I also noticed a drop of water coming from overhead console (trip computer module that has not worked since I've had it).
So I pulled the overhead console out and water was beaded around the center overhead clearance light opening. I dried that one with a paper towel and looked under the headliner and others were slowly leaking. After looking the center one already had a drop beaded again. Would this cause a short that would drain the battery? Also having the battery drained so bad twice in 2-3 months is this going to degrade the capacity of my 5 month old battery?
Ford Super Duty (1999-2016) :: Water In Heat / AC Vents After Rain?
Don't get much rain here in SoCal except during the winter. After the last rain I noticed that there was water in the heating/ac vent system - or at least that's where I think it was.
When I made a right hand turn some water slopped out onto my foot and gave me quite a shock for a second till I figured out what had happened.
I suspect that there must be some kind of drain tube for the vent system that's become clogged, but before I start crawling around under the truck and dash I figured I would ask here first. Any useful tip on clearing the clog?
Ford Super Duty (1999-2016) :: Grinding Noise Constant In 2 Wheel Drive
I have a 2001 F350 with a7.3 power stroke, 6 speed manual with manual t case and hubs. I have a bad grinding noise when in 2 wheel drive. Similar sound as if you are trying to shift t case into 4 wheel drive too slowly. The grinding is constant in 2 wheel drive, but if I shift it into 4 wheel drive, the noise completely goes away. I have been driving around in 4 wheel drive (T case only, manual hubs not locked) for the past 2 days. If I shift back into 2 wheel drive, a constant terrible grinding noise returns. What could be wrong, and why it goes away in 4 wheel drive?????
View 3 RepliesFord Super Duty (1999-2016) :: Constant 12v Power At Bed - Run Wire Or Jump Relay?
I was getting ready to run a fused wire from the battery to the rear of the truck to power my bed lights. Then I read where some owners have jumped the trailer charge relay socket to provide constant 12v at the 7-pin trailer plug.
I never keep my trailer cord connected to the truck when camping so the chances of the trailer draining the battery are nil.I don't want powering the bed lights from other sources as I have decided I want 12v to bed light switch always available.
Ford Super Duty (1999-2016) :: Stuck Steering Wheel / Heavy And Does Not Center On Its Own
06 F250 6.0 CCSB 4x4 163K Truck was in a pass side wreck about three weeks ago. Aside from bumper, head light, etc I had to replace the track bar and then I had the alignment done. Mech said the steering was loose and was either the steering box or column.
PROBLEM: Truck drove and parked fine last night, I went to leave the driveway this morning and I had to turn the wheel full right while backing up. The wheel locked up and wouldn't turn back to the left to straighten out. Hood wouldn't pop either to check anything
I crawled under the truck, the belt was in place and I didn't see any power steering fluid leaking. Thinking it was a PS problem and the hood not opening, I basically floored it and yanked on the wheel and it broke loose. Also, for what ever reason the hood opened after that
Now the steering is heavy and the wheel doesn't center on it's own. It will stay turned when I let go of the wheel. Scared that it would happen I didn't try turning it full lock on the way to work. but it happened again exiting the parking lot, again full right lock and the wheel stuck.
I managed to yank the wheel to the left again and I heard a distinct pop from what I'm sure was the pass side wheel area.
The PS fluid is dark and I'll figure out how to change it. I've read issues from the U-joints, ball joints, Steering box, steering stabilizer, and failing PS pump could all lead to this. Being the truck had a pass side fender bender, and I'm pretty sure the pop sound came from the pass side how do I check all of these items.
Ford Super Duty (1999-2016) :: Excessive Blue Smoke After Heavy Acceleration
I have installed a delete kit and a H&S chip on my 2009 F350 6.4 powerstroke , I installed the mild tune and run in street level. When I accelerate fast from 20 to 70 it puts out a little black smoke but as soon as I let off to maintain speed it starts blue smoke really thick and runs rough , it will eventually stop after 5 or so miles but if I accelerate it will puff blue each time for a bit longer. What could be the issue?
View 11 RepliesFord Super Duty (1999-2016) :: 2005 F350 - Heavy Vibration While Accelerating
My '05 F350 PSD has developed a pretty bad vibration most noticeable above 40mph but only under acceleration. As soon as i hit speed and let off the gas its gone but if i accelerate again to pick up the speed i lost its back. Haven't looked into it too much yet as i was busy all weekend and drove the Expy but I did get down there and don't have an obviously bad u-joint or carrier bearing. I'm also gonna see if i popped off a driveline weight or something.
View 8 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Rain Water Under The Hood?
Twice I open the hood of my SD and I see water pooled up around the intake manifold on my 2001 F250 5.4. This happen when we have heavy rain. My truck is sitting on my drive way that has some angle to it. When it rains, all the water from the roof flows down the windshield and somehow the water is getting into the engine bay.
I cleaned out all the leaves and made sure the rubber molding were in place near the firewall, but it happen again last night. Is there something wrong with my truck to keep the water out. I suppose I could turn the truck around so that the rain will flow from the roof to the bed. But, I like parking my truck the way I park it.
Ford Super Duty (1999-2016) :: Heavy Grease Smell / Bleeder Valve Is Broken Off
2003 F-250 SD 7.3L Supercab
Problem 1: Right rear
Occasional smell of heavy grease, white smoke billowing out from under wheel well (once), black fluid leaking from lower area of caliper. Told it could be axle seal or caliper. I'm leaning toward axle since the caliper is only 1 yr old (NAPA OEM).
Oddly, I also notice a loud, piercing screech when going around traffic circles or exit ramp clovers to the right. I thought this was my trailer until it did the same thing without it.
Axle or Caliper?
Problem 2: Left front
Local mech advised the bleeder valve is broken off in to the unit and cannot be simply replaced. Insists it needs whole caliper. If pedal is all the way up there is a temporary breaking capability then it slowly creeps to the floorboard, hits a brick, and keeps rolling. Replaced master cylinder a few months ago when it same. Drove it for the last 2 weeks and problem is back.
Removing broke-off bleeder valve instead of replacing cals?
Ford Super Duty (1999-2016) :: Trans Fluid Leak After Pulling Heavy Load
I have a 2000 SD F250, gasser, auto. Last week I pulled a heavy load and developed a tranny fluid leak. The fluid appears to be coming from what looks like a freeze plug on the bottom of the casing forward of the (torque converter?) pan . Is that plug easily replaced by a DYIer. Small leak. 150K on the motor. First time it has leaked. Heaviest load I've pulled.
View 2 RepliesFord Super Duty (1999-2016) :: 2002 - Water Poured Out Of Top Gauge In Pillar Pod In Rain
We had almost 2 inches of rain in less than 20 minutes at 1:15, and at 2:00. I went to leave work and took a bath. Water poured out of the top gauge in the pillar pod. Where should I do a close look. Door seal, or windshield gasket?
I pealed back both at 2:45 and did not see anything on the top of the door seal. The top of the windshield gasket is a little open 4 inches in from the corner, but when i pealed it up a little it looked dry.