Ford Super Duty (1999-2016) :: Glow Plug Light Comes On And Power Shut Down While Driving
I have a 2003, f-350, 6.0L with a K&N Filter. While driving the glow plug light comes on and the power is shut down. After a few seconds the power comes back and it won't do it for a while. No codes. I replaced all of the glow plugs and wires. What's causing this?
View 3 RepliesFord Super Duty (1999-2016) :: 2015 F350 - CEL On - Glow Plug Relay?
I have a new f350 with 1500 miles and the check engine light came on. Took it to dealer he said it was the DEF heater. He replaced that part and then it came back on and now its the GLOW PLUG RELAY MODULE. Now for the good part. Ford told dealer that I could drive the truck with the CEL on. Ford stated that they were remanufacturing the glow plug relay and that is was not available at this time and not sure when it will be ready. I filed a complaint with ford, but with little success. Not sure what else to do about this issue.
View 2 RepliesFord Super Duty (1999-2016) :: 2004 F350 - Glow Plug Errors On Cylinder 2 / 4 And 8
I have an 04 F350 with Glow Plug errors on cylinder 2, 4 and 8. I have already replaced the harness on that side because the old one was gunked up pretty bad. Still have the same issue. Does this sound like a GPCM issue to ya'll?
AE pulled the following codes:
P0672 Cylinder 2 Glow Plug Circuit
P0674 Cylinder 4 Glow Plug Circuit
P0678 Cylinder 8 Glow Plug Circuit
Not having issues starting but it rarely gets into the 30's here in FL.
Ford Super Duty (1999-2016) :: Replacing Glow Plug - Dead Completely After Noise From Fuse Box?
i was replacing my glow plug relay and my ratchet hit one of the small wires and sparked. i went in the truck and I heard a really fast clicking noise at the fuse box. I opened it up a very top small relay was the one clicking. i replaced it and it still clicks. the truck is TOTALLY DEAD no power to anything. I checked ALL the fuses under dash and under the hood, they are all good. both batts are at 12. 9 volts. what would kill the whole truck like this. is there a main fuse somewhere? I really need to get this going tonight. it's gonna rain all day tomorrow and this is my only Tow Truck for my business.
View 14 RepliesFord Super Duty (1999-2016) :: 2005 F250 - Running Really Rough When Engine Not Fully Warmed Up - Glow Plug Codes
2005 F250 6.0L ... My truck is running really rough when the engine isn't all the way quite warmed up. once the truck is fully warmed up to normal running temp it runs good. I am getting four engine codes. P0672, P0673, P0674, P0676 These codes say 2,3,4, and 6 glow plugs have a open circuit. Can this be the cause of my problem?
View 7 RepliesFord Super Duty (1999-2016) :: 2006 F250 - Tow / Haul Light Started To Flash
Experiencing a melt down with one of my trucks. One of our trucks is an 06 F250 SD with 80k on a 5.4L and the other day the tow/haul light started to flash. I took it to a buddy's repair shop (who is an experienced Ford tech and tranny guy) any way, it shifted fine until about the last 1/2 mile before I got to his shop, then it started shifting in and out of different gears. He found solenoid "A" pressure solenoid failure and one other solenoid failure, he replaced all 7 solenoids and also found the pigtail from the transmission to the wire harness bad as well and replaced that. I pick it up and get about a mile down the road and the light starts to flash again so I took it back, he ran his scanner and now found something with the coast clutch and through all his testing it told him the coast clutch needs replaced. He removed the trans. and tore it all down and found nothing wrong with anything, in fact he said everything looked in great shape and thinks the pcm failed.
View 12 RepliesFord Super Duty (1999-2016) :: 2001 F350 - Overdrive Light On Gear Shift Would Flash Intermittently
I have an '01 F350 super duty dually, 7.3L, auto trans. Over the past weeks my overdrive light on the gearshift would flash intermittently, maybe once every couple weeks. I chalked it up to a prior theft attempt where the steering column was damaged, and had turn signal/hazards issues after that.
Over the past few days my reverse gear has taken longer to engage, and is hard getting into the higher gears at speed. As of yesterday, reverse is out and won't shift out of second. Fluid level is good and clear. Could this be a PCM issue, or some sensor or relay?
Ford Super Duty (1999-2016) :: 2003 F250 - AC Blows Colder While Driving Than Idling
I have a 2003 f250 xlt with the 5.4l engine in it and lately my AC hasn't been standing up to the heat of the Midwest. When driving around town or on the highway my AC blows really cold but at idle you can tell a drop off in temp. Is this normal due to extreme heat or is there something I can do?
View 12 RepliesFord Super Duty (1999-2016) :: Truck Shaking When Accelerating / Idling And Driving At 1500 RPMs
I got a 2000 f250, 5.4l, I got a check engine light bout 2 weeks ago and didn't experience any driving issues. The code was p0171, just recently I've been experience troubles idling, if I let my truck idle for about 3 minutes it will want to shut off, also on acceleration the hole truck bumps, feels like I'm in an earthquake. Where I should start with this problem?
View 11 RepliesPassat (B6) :: Glow Plug Lamp Light Came On While Driving And Car Seemed To Lose Power
I have a 2005 B6 TDi 2.0 sports 140bhp passat and have encountered a glow plug lamp problem. The light came on while i was driving and the car seemed to lose power. We then switched it off and restarted and it was fine but then the problem recurred a few days later. The light has come on both times when i have accelerated on the motorway. What it could be?
View 2 RepliesFord Super Duty (1999-2016) :: Idling At Startup Make Truck Deliver Power Smoother / Battery Light Stays Off
I would like to know what's happening, it seems as if idling for a minute to let my transmission temperature dial raise past the lowest line on the dial fixes or at least drastically reduces a couple issues.
The truck will deliver power much smoother off the line. I've been concerned about this for a while. The degree to which it happened wasn't constant but it seems like the truck is having trouble grabbing on (so to say) to the power coming off the line. I sort of liken it to a rope. When I give it the beans the rope goes forward but it takes a half a second or so for the truck to "grab" on to the rope. Never hard shifts, it's just delivering the power off the line or from a near stop.
Idling for a minute seems to fix this, power delivery is smooth off the line. Transmission dipstick was nice and pink but smelled slightly burnt. This is with the engine cold overnight. Didn't have time to do multiple wipes or check in the handbook for the proper methods of checking fluid, I just pulled it out quickly to take a look before heading out. Fluid covered the whole tip.
Second issue that seems to be fixed is that the battery light doesn't come on nearly as much and not for nearly as long. Typically the battery light will come on and off seemingly on its own whim during the drive. However, it seems to stay more consistently off if I idle right after startup.
Now bear in mind I baby my truck, I don't rev it high right after startup. Just low enough to cruise around the parking lot until I hit the road then I accelerate up to 40 - 60 depending on my route. I'd gladly give it the minute to warm up in the future but if I could get down to the bottom of this that'd be preferred, I doubt this is required behavior.
I do realize that these issues are not tied to startup behavior but I find it interesting that idling for a minute at startup to let the transmission gauge rise seems to mitigate these symptoms.
Ford Super Duty (1999-2016) :: F250 Will Not Start After Removal Of SCT Flash Tuner
Yesterday I returned my F-250 SUPERDUTY 5.4 To stock on the sct flash tuner that came on the truck. after returning it to stock i tried to start the truck to leave about an hour later and instantly wouldnt start it backfired. we returned it back to the tune that was on the truck, still no start. we replaced the starter, the battery still nothing. if it sits for a little while it will attempt to turn over. it has a strong odor of gas in which led me to possibly thinking its vapor locked? or the pcm being bad or maybe the crank shaft sensor? the truck has ran strong and had zero problems up until now when we took the tuner off. it runs about 6 codes now, a few being the kam the o2 and low voltage.
View 4 RepliesFord Super Duty (1999-2016) :: Calibration Complete Message On Dash Flash And Disappear
Took a trip last week towing the toyhauler. 400 miles one way. 2008 F350 4x4 dually, bone stock, 35,000 miles. On the trip home, as soon as I left campground I started getting a message on the dash- Calibration complete. Would flash and disappear. Then it would flash it again and right after would say "Drive slowly in circle to calibrate". Did this off and on entire way home even after shutting truck off a couple times. I haven't had time to look in the manual yet, what it's for.
View 2 RepliesFord Super Duty (1999-2016) :: Turn Signal Sometimes Taking A Few Seconds Before Actually Starts To Flash
Need better understanding of the wiring and turn signal selector than I do in my 07 6.0 HD. At first the issue started with the right front and right mirror blinking fast indicating a burnt out rear right turn signal. However after a few seconds the right rear will start working and the speed would be normal. I noticed it worse on very wet days making me think the rear tail light was letting in water and messing with the bulb. But it turns out it does it on nice days too.
These days it has evolved into the turn signal sometimes taking a few seconds before any of the right side actually starts to flash, also sometimes the indicator does not automatically deactivate after a right turn.
Giving the bottom of the steering column a calibrated tap usually always fixes the issue until the next turn.
Assuming its a bad turn signal selector switch Part number YL3T-13K359-ABJAEA but not knowing the wiring diagram I dont see how this bad switch would intermittently stop controlling the right rear turn signal. I would guess that it would tell the flasher left or right, not which lefts and which rights.
Ford Super Duty (1999-2016) :: Service Engine Light Came On While Driving Doing Around 65 Mph
1999 F250 Super Duty. My service engine light came on while driving doing around 65 mph. Truck seems to be running normal, no loss of power or acceleration. It's a 5.4L with 104000.
View 6 RepliesFord Super Duty (1999-2016) :: F250 - 4x4 Light Flashing Or Flickering While Driving
1999 F-250 7.3 Ext Cab 4X4... I just got this truck and it started having the 4x4 light flashing or flickering while driving and sitting?
View 3 RepliesFord Super Duty (1999-2016) :: 2014 - Headlights Stay On?
This is my first post on this forum. I have a 2014 F350 standard fleet truck. The headlights are not day time running lights. The headlight switch is the basic off/parking light/on. The headlights come on as soon as you start the
truck. This just started happening about a month ago. When you shut off the truck the headlights stay on for ten minutes. I scanned the truck with a snap on modis. I got into the lighting module and the "command on" is on. The modis would not give me the option to turn it off. Short of taking the truck out of service for a day to go to the dealer. Is there any other fix I can do?
Ford Super Duty (1999-2016) :: Keeps Dying / Not Stay Running
My issue is not with the truck starting its with it staying running. I had plugged in all the night prior and all day while at work. When my shift was over went out started fine let it run for about 20 minutes and left to make my way home. During the trip it ran fine for about 1/2 a mile and then it started idling really rough at a stop light went to go threw the light and it as though I had left it out all night with plugging it in. I went to turn on a side street because this situation was not going to end well and it died trying to turn. It would not start back up I was able to get a jump and made another 1/4 of a mile and it died right in front of my house. I replaced both the batteries this morning and it fired right up lasted about a minute and then died again. All the gauge read fine, oil level is good, and the injectors were replaced 2 years ago.
View 14 RepliesFord Super Duty (1999-2016) :: 2002 - Headlights Stay On - Won't Go Off?
i have a 2002 f250 i drove it lat night parked it came home from work at about 3 and noticed my head lights were on and just headlights. I open the door and see that the switch is in the off position too. WEIRD HUH ? they wont go off. I tried to unplug the switch and nothing.
View 6 Replies