Ford Super Duty (1999-2016) :: 2004 F250 - Fuel Pump Relay Location
I am trying to diagnose my fuel system, but I cant seem to find the fuel pump relay. My truck is an 2004 f250 crew cab work truck with 5.4L. it seems that the relay can be mounted anywhere from behind the radio or in the engine compartment as well as built in to the fuse box under the steering wheel.
View 14 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Fuel Pump Relay Location?
Looking for where the fuel pump relay is 2001 f 250 SD reg cab 2 wd. Won't Start On pump gas , starting fluid yes
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F250 5.4 Engine - Fuel Pump Relay Location
Its it true, that the fuel pump relay is hid in the fuse and relay box, and non serviceable ?
View 6 RepliesFord Super Duty (1999-2016) :: F250 5.4L - Engine Won't Start / Fuel Pump Relay Failed
I see several threads regarding engines that wont start for no apparent reason. My reason was a failed fuel pump relay. This sucker is hidden in the dash below and to the left of the radio. I got to it by taking out the ash tray. There are three relays under the cover. The upper left is the fuel pump relay. The one to the right is the turn signal relay. I don't know what the bottom left is for.
View 3 RepliesFord Super Duty (1999-2016) :: Fuel Pump Relay Location?
2004 super duty crew long bed 2wd, v10 auto SLT.
Manual says not in fuse block.
Looked behind radio, nothing, not even a space or the blue one there.
There are some on the firewall, driver side not marked. No pink wire.
Where else??
Ford Super Duty (1999-2016) :: F550 V10 - Fuel Pump Relay Location
I am looking for the location of the fuel pump relay for my 1999 Ford F550 V10 4WD Gas truck.
I have replaced the fuel filter and fuel pump. When the key is turned the pump gets juice and 2 seconds later is not getting juice. No lines are coming into it, so it's not getting up to pressure and shutting off.
Ford Super Duty (1999-2016) :: 2003 F350 - Fuel Pump Relay Behind The Radio?
2003 f350 5.4... Is the fuel pump relay behind the radio? Under hood? Or built in the fuse panel and unserviceable?
View 14 RepliesFord Super Duty (1999-2016) :: 2002 - Gas Engine Won't Start After Replacing Fuel Filter / Pump Relay / Air Filter?
After replacing fuel filter, pump relay, and air filter for good measure my 2002 f250 v10 gas engine still wont start. What to do?
View 13 RepliesFord Super Duty (1999-2016) :: 2001 F250 Occasionally Starts - Fuel Pump?
I have the gas 5.4l in my 01 F250 Super Duty. I had to change out the leaking Heater hose before I could attack this other issue. The truck starts when it feels like it. I changed the fuel filter and it started fine. Then the next day it wouldn't. Later it would. However each time it does start it dies when throttled up. I am down to thinking it is the fuel pump. My question is, because changing the pump sucks about as bad as changing the heater hose. Can I install an inline fuel pump and deal with the sump pump in the tank later? Are there any Cons to doing this?
View 5 RepliesFord Super Duty (1999-2016) :: 2006 F250 5.4L - Fuel Pump Fuse Keeps Blowing
The fuel pump fuse keeps blowing intermittently. I would assume it's a wire grounding out somewhere but I can't seem to find one yet. I do have a faulty purge solenoid on the canister but I don't think that would cause this. The reset switch doesn't seem to be tripped either.
View 3 RepliesFord Super Duty (1999-2016) :: 2010 F250 - High Pressure Fuel Pump Failure
I have a 2010 f250 6.4 About two months ago the truck just quite on me. I am a farmer in south jersey and have a decent background in diesel motors. First thing that came to mind was fuel. I assumed I was having a fuel issue (clogged filters, failed pump, etc.) truck only had 45,000 miles on it so I took it to my local dealership for what I assumed would be a warranty job. I dealer service all my trucks while under warranty. Long story short I was told it was a fuel contamination issue which scared the walls of the hpfp throwing metal pieces into the injectors, fouling them.
I would need all new injectors, fuel rails etc. as well as new filter housings, fuel tank cleaning, etc. I had receipts for every drop of fuel put in the vehicle and fought all the way to through the dealership to Ford who sent out a rep and who denied the warranty work. Fortunately my insurance company covered the ordeal and all repairs were completed. I got the truck back and 2 weeks later the truck died on me again. I called the dealership back who supposedly warranted the repairs but there first words were there is no way it is their problem, they would look at it but I have to consent that if they find it is contamination again I am responsible for the repairs which we all know just to diagnose they have to remove the cab etc.
I of course lost my mind and told them this is there issue and there is no way in hell I am that unlucky that I received 2 bad tanks of fuel from 2 different high volume highway side fuel stations in the same 2 months. it is obvious they missed something or there is another issue that was not addressed. They claim there is no way they missed something. I am at a standstill.
Ford Super Duty (1999-2016) :: F350 - No Power To Fuel Pump Or Relays
I have a 1999 f350 with the 5.4l engine. I have no power to the fuel pump or fuel pump relay. I have battery voltage to the pcm relay. I don't know what else to test because I don't have a proper wiring diagram.
View 2 RepliesFord Super Duty (1999-2016) :: 2000 F250 5.4L - Power Steering Pump Flush
Any link on how to do a flush on the 5.4L power steering pump? I screwed up on installing my new power steering pump and used power steering fluid (new to ford) and it is moaning so I need to flush and get mercon ATF put back in the lines. The write up I found was for the diesel hydroboost and I do not have that setup.
View 3 RepliesFord Super Duty (1999-2016) :: F250 V10 - Rapid Clicking Of Relay Behind Radio
1999 ford F250 SD V10 ... When this goes on the truck misfires and tries to die. Usually I can key the ignition in nuetral and the clicking stops and the truck starts and runs better....
View 6 RepliesFord Super Duty (1999-2016) :: 2000 F250 - Park Lamp Relay Location?
The #8 fuse under the hood was blowing on my '00 F-250 every time I turned on the healights meaning I would lose power to my park lights. The brown wire coming from the back of the headlight switch showed a dead short to ground that I traced to somewhere between the switch and the firewall.
Anyway, I got tired of trying to pinpoint the ground fault, so I cut the brown wires at the back of the switch and under the hood at the top bolt-on electrical plug and replaced the bad section with a new wire. It works fine now with the only exception being I do not get the park light flash when I hit the remote lock button the second time. I do still get the horn chirp.
My Haynes manual indicates there should be a relay box with a Park Lamp relay, Driver Unlock relay, All Lock Relay, and All Unlock relay. The park light relay looks like it sends the blip of power to the park light circuit. Where this relay box is? I'd like to splice into the brown wir coming out of it to restore the light flash when I lock the truck since sometimes it's too noisy to hear the horn.
Ford Super Duty (1999-2016) :: 2001 F250 V10 Only Starts When Jump Start Relay
Truck was dead- 2001 F250 V10... Has a starter relay (solinoid) behind battery... put a new relay in there- no go- cleaner terminals... then I put key in start and shorted the 2 terminals in the relay and she cranked right up. That would mean the starter is still good correct?? something in the ignition system?
View 1 RepliesFord Super Duty (1999-2016) :: 2008 F250 - No Power At All Loaded And Unloaded And Really Bad Fuel Mileage
I've got a 08 f250 ext cab long box with the 5.4 gas. I know I know 3/4 ton gas. Trucks got NO power at all loaded and unloaded and really bad fuel mileage. Driving like a grandpa in town I'm getting 7mpg on the hwy unloaded I get 9 or 10mpg loaded on the hwy the trucks working way harder than it should and getting 6mpg.... I'm wanting to swap the 5 4 for a 6.0. Reason I saw 6.0 is my buddy's done egr delete. Bulletproof oil cooler head studs and a edge with attitude chip and has great power and reasonable fuel mileage. How hard is it going to be swapping the motors.
View 10 RepliesFord Super Duty (1999-2016) :: 2003 F550 - Suddenly Power Loss And Struggles While Driving / Gurgling Fuel Pump Noise
2003 f550 with 7.3, suddenly loses power and struggles while driving. White/blue smoke comes from tailpipe, can smell the diesel exhaust bad when happens, comes and goes intermittently but has been happening more and more often. I uploaded a video onto YouTube to show sound, rough running motor and smoke from exhaust although smoke not that bad in video. Search "shadetreelandscaping" on YouTube in case link below doesn't work.
ShadeTreeLandscaping - YouTube
Took to ford dealer a few diff times for problem and they can't get any codes, can't duplicate problem. After it being in for third time they say had to call ford tech hotline and they suggest replacing injector however can not and will not gaurntee that will solve problem, and obviously dealer isn't cheap for repair. I find it hard to believe that a bad injector(s) would be an intermittent problem as it is or that it would cause fuel pump to make gurgling sound.
Ford Super Duty (1999-2016) :: 2004 F250 6.0L - Buzzing Noise From Relay Under The Steering Wheel
2004 F250 SuperDuty 6.0L Diesel. The turn signal (left or right), it would make a buzzing noise, so I located the relay under the steering wheel (by putting my hand on it and seeing which one was buzzing) and replaced it, I bought a replacement at Schucks, then the buzzing noise went away, and the clicking noise is back.
But.... I don't see the turn signal lights in the dashboard and the turn lights are not working, I checked, what could be the problem ? I read the owners manual, in the fuse box under the steering wheel, fuze #18 is used for turn lights, but it is not blown.