Ford Super Duty (1999-2016) :: Fuel Pump Relay Location?
2004 super duty crew long bed 2wd, v10 auto SLT.
Manual says not in fuse block.
Looked behind radio, nothing, not even a space or the blue one there.
There are some on the firewall, driver side not marked. No pink wire.
Where else??
Ford Super Duty (1999-2016) :: F250 - No Power To Fuel Pump Relay
1999 f-250 super duty... okay, here is what i have going on. basically no power to the fuel pump. For the last 2 weeks the fuel pump relay and 1 of the relays behind the radio (next to the blue relay) would chatter and the truck would die. Wait about 5 minutes and turn the key on and if the chatter was gone then it would fire up and run... So NOW no chatter on either relay and not cranking up. - motor turns over just fine- just no power to fuel pump. So I changed out the relay- both behind the radio and the one under the hood. still chatters and no start. i have checked the Inertia switch and 12 volts there... Here is my question, when i turn the ignition on, i have no power to the base of the Fuel Pump Relay.... Where does the power come from to power the relay???
View 13 RepliesFord Super Duty (1999-2016) :: F550 V10 - Fuel Pump Relay Location
I am looking for the location of the fuel pump relay for my 1999 Ford F550 V10 4WD Gas truck.
I have replaced the fuel filter and fuel pump. When the key is turned the pump gets juice and 2 seconds later is not getting juice. No lines are coming into it, so it's not getting up to pressure and shutting off.
Ford Super Duty (1999-2016) :: 2004 F250 - Fuel Pump Relay Location
I am trying to diagnose my fuel system, but I cant seem to find the fuel pump relay. My truck is an 2004 f250 crew cab work truck with 5.4L. it seems that the relay can be mounted anywhere from behind the radio or in the engine compartment as well as built in to the fuse box under the steering wheel.
View 14 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Fuel Pump Relay Location?
Looking for where the fuel pump relay is 2001 f 250 SD reg cab 2 wd. Won't Start On pump gas , starting fluid yes
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F250 5.4 Engine - Fuel Pump Relay Location
Its it true, that the fuel pump relay is hid in the fuse and relay box, and non serviceable ?
View 6 RepliesFord Super Duty (1999-2016) :: F250 5.4L - Engine Won't Start / Fuel Pump Relay Failed
I see several threads regarding engines that wont start for no apparent reason. My reason was a failed fuel pump relay. This sucker is hidden in the dash below and to the left of the radio. I got to it by taking out the ash tray. There are three relays under the cover. The upper left is the fuel pump relay. The one to the right is the turn signal relay. I don't know what the bottom left is for.
View 3 RepliesFord Super Duty (1999-2016) :: 2007 F350 - Fuel Pump Is Not Running
I have a 2007 f-350 with the 5.4. The fuel pump is not running, have voltage at the inertia switch but none at the pump. Where the pump driver module is located at?
View 2 RepliesFord Super Duty (1999-2016) :: F350 - No Power To Fuel Pump Or Relays
I have a 1999 f350 with the 5.4l engine. I have no power to the fuel pump or fuel pump relay. I have battery voltage to the pcm relay. I don't know what else to test because I don't have a proper wiring diagram.
View 2 RepliesFord Super Duty (1999-2016) :: 2002 - Gas Engine Won't Start After Replacing Fuel Filter / Pump Relay / Air Filter?
After replacing fuel filter, pump relay, and air filter for good measure my 2002 f250 v10 gas engine still wont start. What to do?
View 13 RepliesFord Super Duty (1999-2016) :: 2001 F350 V10 Stalls But Fuel Pump Stays Running?
I have a 2001 f350 v10 that has been giving me fits. has 88000 miles. cranks and starts when cold or fuel pressure is below 40 psi. SES light will flash when it stalls and fuel pressure goes from 30 while running to 40 and the fuel pump runs continuously when this happens and truck will not start. replaced crank sensor and fuel pump was changed about two months ago. if I relieve fuel pressure it will start and run for short time then stall and fuel pump stays on. all fuses are good. I am at a loss.
View 1 RepliesFord Super Duty (1999-2016) :: 2003 F350 - Radio Is Cutting On And Off
In my 03 F-350 my radio is cutting on and off . Have figured out problem is in dash cluster. Which wire do I use to run radio to battery and bypass the cluster???
View 3 RepliesFord Super Duty (1999-2016) :: 2003 - Fuel Pump Not Coming On?
I have searched through the site but have not found anything like the problem I'm having. I have a 2003 F250 5.4. Three weeks ago I attempted to start my truck and it just cranks. The fuel pump was not coming on. I left the truck over night and the next morning the truck starts with no issues. It ran normally for the next three weeks then the same thing happened again. Towed to the mechanic but the truck started up and ran. It shows no codes after both no starts and both times ran fine the next day. When running fuel pressure is where it should be.
View 3 RepliesFord Super Duty (1999-2016) :: 2003 - Replaced Fuel Pump Now No Gas Gauge?
I just replaced my fuel pump to avoid another tow truck ride and now my fuel gauge is off. I filled up the truck today and the fuel gauge is only showing half a tank. I turned the truck on and off several times to try to reset it, but that didn't work.
Truck is a 2003 with the 5.4.
Ford Super Duty (1999-2016) :: 2003 F350 - Fuel Smell In The Cab?
I have a 2003 F 350 Diesel. When the heater is on, I can smell diesel fuel through the vent. This happens mainly when I am at a stop sign and the fan is on high. I did some research on this forum and found some others with a similar problem. The question I have is it seems like some said it was the cracked injector cups or a leak at the reservoir on top of the motor where the filter is. What I wasn't sure of was the symptoms. If it is a crack injector cup, would the smell be all the time and not just when I am stopped at a stop sign? Or would it be intermittent as well? It is definitely not exhaust smell. It smells like fuel. If it is the gaskets in the reservoir, I think I will do the blue spring replacement cause that seemed to improve a couple things based on the treads of the forum. I do see drips on the pavement every once in a while at the front of the truck towards the passenger side of the truck. Not all the way to the side near the tire, but off center on the passenger side. Is there anything that could be leaking fuel on that side of the motor?
View 4 RepliesFord Super Duty (1999-2016) :: F250 V10 - Rapid Clicking Of Relay Behind Radio
1999 ford F250 SD V10 ... When this goes on the truck misfires and tries to die. Usually I can key the ignition in nuetral and the clicking stops and the truck starts and runs better....
View 6 RepliesFord Super Duty (1999-2016) :: 2004 F350 Won't Start / Relay Or Reset Cut Off
My 2004 F350 would not start yesterday, for the second time. I had just been driving it 30 minutes before, but when I tried to start it nothing happened. The dash light came on but nothing else, not even a click. Had to leave it overnight, and this morning it started completely normally. what this might be? It seems kind of like a relay or reset that was cut off and took time to reset itself. The first time it happened, it started up after 20 minutes, but yesterday it still wouldn't after an hour at which point I had to go to work so I don't know what the interval would have been if I could have stuck around and continued trying it.
View 6 RepliesFord Super Duty (1999-2016) :: 2015 F350 - CEL On - Glow Plug Relay?
I have a new f350 with 1500 miles and the check engine light came on. Took it to dealer he said it was the DEF heater. He replaced that part and then it came back on and now its the GLOW PLUG RELAY MODULE. Now for the good part. Ford told dealer that I could drive the truck with the CEL on. Ford stated that they were remanufacturing the glow plug relay and that is was not available at this time and not sure when it will be ready. I filed a complaint with ford, but with little success. Not sure what else to do about this issue.
View 2 RepliesFord Super Duty (1999-2016) :: 2003 F550 - Suddenly Power Loss And Struggles While Driving / Gurgling Fuel Pump Noise
2003 f550 with 7.3, suddenly loses power and struggles while driving. White/blue smoke comes from tailpipe, can smell the diesel exhaust bad when happens, comes and goes intermittently but has been happening more and more often. I uploaded a video onto YouTube to show sound, rough running motor and smoke from exhaust although smoke not that bad in video. Search "shadetreelandscaping" on YouTube in case link below doesn't work.
ShadeTreeLandscaping - YouTube
Took to ford dealer a few diff times for problem and they can't get any codes, can't duplicate problem. After it being in for third time they say had to call ford tech hotline and they suggest replacing injector however can not and will not gaurntee that will solve problem, and obviously dealer isn't cheap for repair. I find it hard to believe that a bad injector(s) would be an intermittent problem as it is or that it would cause fuel pump to make gurgling sound.