Ford Super Duty (1999-2016) :: Noticeable Torque Converter Lockup In 5th Gear
When running up through the gears under normal acceleration I can feel almost a double shift in 5th gear. It doesn't occur using tow/haul so I assume it is the TC locking up. Everything else seems fine. Truck has 9k miles, mostly towing. 2016 6.2 ....
View 6 RepliesFord Super Duty (1999-2016) :: 2007 - Won't Shift If Does Then Slams Into Gear - Torque Converter?
I have an issue to where every once in a while my truck will not shift and when it does shift it slams into gear, and my overdrive light flashes and then I'll turn the truck off let it sit and crank it back up and it drives fine and the overdrive light is off. It shifts normal and smooth other than when this happens. Not sure if it is my torque converter or maybe a solenoid or what. My truck is an 07 f250 6.0 with 192,000.
View 5 RepliesFord Super Duty (1999-2016) :: 2000 F250 V10 Truck Started To Have A Miss Under Normal Acceleration
Question, my truck started to have a miss under normal acceleration, when I really get on it, it clears up? I also noticed a bad sulfer smell at idle. Im thinking the cat is possibly plugged? Truck had 172000ish on it, and the cat is original. I did do a big tune up this past fall, new plugs, coil packs, air and fuel filter. Should I put a new cat on it? And a new oxygen sensor?
View 9 RepliesFord Super Duty (1999-2016) :: F350 Running Rough When Locked In First Gear
My brother is having a issue with his 99 F350 diesel 7.3 automatic tranny pu. When in manual 1rst gear the engine stumbles and runs like crap. In drive or 2nd gear it runs fine. He's getting a code for a bad cam sensor. A new OEM and aftermarket sensor has been tried with no solution to the engine problem. What might be going on? Maybe a bad ECM.
View 2 RepliesFord Super Duty (1999-2016) :: F350 - Steering Wheel Locked While Driving
Yesterday while traveling about 30mph and starting into a slight left turn the steering wheel locked, when the brake pedal was applied it was rock hard and would not engage braking resulting in a single vehicle crash, no injuries. 8300 miles...
How would I make Ford aware of this incident and get them involved? Is it likely that such events may have been logged somehow in the computer? The truck is at our collision repair shop waiting for an insurance adjuster to inspect.
Ford Super Duty (1999-2016) :: Check Engine Light Comes On And Turns Off During Normal Driving Conditions
On my 2002 F250 7.3 I kept getting a check engine light when I pulled my 5th wheel uphill, I took it to a shop and they told me my HPOP needed replaced. I bought a new pump and installed it. Now my check engine light comes on and turns off during normal driving conditions. I do not have a code yet but hoping there is some idea on what might have happened.
View 1 RepliesFord Super Duty (1999-2016) :: 2006 F350 Shuts Down While Driving After Hard Acceleration
I have an 06' f350 6Ltr. Over 300 k. Good shape, i have owned it for about a year. My first diesel. Last week it wouldnt start, had a 1/4 tank. Read about problems with other trucks with a broken pick up on fuel pump. So i filled the tank and it started. Next morning used command start and it ran for 1 minute then shutdown. took about 5 minutes of manually turning it over and it fires up ran all day. Does this almost everyday since and now shuts down while driving after hard acceleration and surges under acceleration when on incline or underload. Changed fuel relay, fuel filters. Researched and asked around but getting mixed opinions. I am mechanically inclined but this is a little beyond my scope of trouble shooting and id rather not start throwing parts at it.
View 1 RepliesFord Super Duty (1999-2016) :: Engine Is Running Rough (jerky On Acceleration) Especially When Driving
I have a 1999 F250 SD V10 4x4. I recently had a transmission installed and the truck is running erratic. I have an engine miss (sometimes when idling, more so when in drive and foot on the brake). I say sometimes because there are times it will not miss and the engine runs smooth. The transmission shifts a little strange and sometimes hard.
I am getting a code reading that says my TPS is faulty, but I installed a new one a few months back.
The engine is running rough (jerky on acceleration) especially when driving. I was wondering if I should take it to a shop and have them flash the computer to reset it?
I also remove the AC compressor a while back (bad clutch). I installed an aftermarket pulley.
Ford Super Duty (1999-2016) :: Second Gear Skipping When Driving In D
A couple days ago, my Excursion started skipping 2nd gear when driving in D. The RPMs will go up to 3500 or so before slamming into 3rd gear. Shifting in all other gears works fine. However, when manually shifting through the gears (1, 2, D), it finds 2nd gear and shifts fine. I am mechanically inclined when it comes to engines, but not an auto trans.
View 6 RepliesFord Super Duty (1999-2016) :: Unable To Shift Into Overdrive / Higher Gear While Driving Down The Road
1999 5.4 ... I was just driving down road and truck suddenly wouldnt shift into overdrive/higher gear. pulled to side of road and the motor was revving very high at 2500 rpm. shut truck off and on a few times...kept doing it until finally after a while it went back to normal....
View 1 RepliesFord Super Duty (1999-2016) :: When To Replace Catalytic Converter?
ill be replacing my muffler here soon, its rusted out blows smoke out all the rust holes, and so on. gonna replace with a nice flo master. Question is, when is it time to replace the catalytic converter? 15 years old and 93000 miles, it still seems like its in good shape, but could it be getting clogged? just from the sounds of the exhaust the past few months, it almost sounds like the truck is somewhat congested. The power from the engine is kinda week, but that's the engine itself. I have no real problems getting up to speed. my hesitation issues from before turned out to be water in the gas tank. Figured since im down there does it make sense just to bite the bullet and throw a new catalytic converter on?
View 8 RepliesFord Super Duty (1999-2016) :: Locked Up Clutch?
I was driving to work this morning and my hydraulic clutch linkage messed up on the 1999 f-250 super duty 7.3 with zf 6 speed. It acted like any clutch master cylinder when they go out, the pedal went to the floor and the clutch would not release, but it also became very hard to shove in the clutch pedal, so I speed shifted it without the clutch and made it to work. So I figured no big deal I will swap out the clutch master and slave cylinder complete assembly in the parking lot, except I had to get a ride 30 miles to an auto parts store that had it in stock. I changed out the complete assembly and same problem with the new one, extremely hard clutch pedal, so I did not dare to push it anymore and risk damaging the new cylinders, and left the truck at work. I am thinking broken throw out bearing jammed into the clutch, or dislocated throw out arm causing the problem. The clutch disc, pressure plate and single mass flywheel were replaced by the previous owner 3 years and 15,000 miles ago.
View 3 RepliesFord Super Duty (1999-2016) :: Substantial Vibration When Torque Converter Locks
I have a bone stock (other than exhaust) F-250 SD, 6.0 auto, 185k miles. I have a substantial vibration when the torque converter locks - about 50-55 mph. Once the transmission warms up (i.e. 4-5 miles from a cold start) the vibration goes away and the transmission performs flawlessly. Backing out of the throttle and allowing the TC to unlock makes the vibration go away, as does shifting into neutral. There is no noise, just a vibration that will shake the whole truck. Transmission fluid looks good, and showing full. Have had the truck about 4 months, and have not flushed or replaced the filters on transmission.
I've seen a couple of similar threads on vibrations, but not one where the vibration will completely go away. I'm thinking replace the torque converter but wanted to get more information from the experienced experts that know these 5R110s better.
2007 F-250 King Ranch 6.0 PSD, 5R110W, 4" Turbo Back, Otherwise bone stock, 185k.
Ford Super Duty (1999-2016) :: 2011 F250 - CEL On - CAT Converter Failing At 39k Miles?
Recently my 2011 f250 sd 6.2s check engine light came on so I took it to my local dealer it was throwing a p0430 code, they said bank 2 cat converter wasn't do it's job so it needed to be replaced. I am concerned that there is an underlying cause of the premature cat fail. I pushed the issue with the service manager and he told me that's all they could do was replace the cat and refused to check anything else on the truck. Is this common? The truck runs and drives fine. I'm just concerned that they are just throwing parts at it to get it out the door.
View 5 RepliesFord Super Duty (1999-2016) :: 2011 - Engine Locked Up?
2011 F-250 King Ranch, bought new, 59,995 miles. Dealer Serviced, always. ESP to 100K.
Took it in for an oil change, running perfect. Jan 4.
Service writer comes and gets me after 2 hours. "Engine locked up after they went to start it after oil change."
They are getting a remanufactured long block from Ford.
I am still in shock.....
Ford Super Duty (1999-2016) :: 22K With Hubs In Locked Position
Its a 2016 F-250, 6.2L gas truck with the electronic shift on the fly transfer case.
I have put right at 22,000 miles on it like this, frequently at 70-80 mph.
What are the odds I have damaged it and is there anything I should do now that I discovered it - other than put them both in "AUTO".
Truck has been to the dealer twice and not once was this noticed. They blamed the squealing on the brakes which I knew it wasn't.
Ford Super Duty (1999-2016) :: 2011 - Radio Locked Up?
Radio locked up. Dealer says $800 to replace which seems way out of line to me. Are there any aftermarket solutions that retain the Bluetooth phone integration and don't look gawdy once installed?
My radio has the CD player, a digital display and steering wheel controls but no large screen or touchscreen for mapping or backup camera or anything like that.
Or if there is no good aftermarket solution perhaps I would be better off replacing it with a higher end Ford radio with inputs for a backup camera, etc?
Ford Super Duty (1999-2016) :: 2003 - Low Boost Inconsistently?
I have a 2003 f250 with a 6.0l that at random will only build 11 psi of boost and throws a low boost input code. The egr is disconnected but not removed. Ive checked the map sensor line and tube and replaced the sensor itself. The truck also has an air raid intake. Other than that it's stock. Seriously sometimes it runs perfect for a week than will be back to only 11 psi for a day. I'm not sure if it matters but it seems that it more commonly has the issue when I'm running the air conditioning.
View 6 RepliesFord Super Duty (1999-2016) :: 2006 - No Power / Boost?
I have a 2006 f350 4x4 dually 6.0. The other morning when leaving for work I hard a loud air noise, like a jet. It only happens when the motor is trying to create boost. I have NO boost. No smoke. If I push the fuel pedal past 1/4, nothing. Its like its stuck and no more power at all. I have changed the boot from the turbo to the intercooler pipe. (looked like it had cracks in it).
Checked the cold pipe, no cracks seen. Check the exhaust clamps, into the turbo, they are tight. The turbo is seeping oil around the seal. I took the inlet, fresh air, pipe off. Check the turbo spool for looseness, fins, spun the wheel, ran the engine and watch to wheel. Seen no issues. Where to go now?? No coolant leaks, no oil leaks.