Ford Super Duty (1999-2016) :: 2006 F350 - Hooking Up High Idle With Upfitter Switches
I would like to do the high idle mod with my 2006 F-350 using the upfitter switches. I've seen a couple of threads about this but they are not real clear to me and don't mention the 2006.
View 14 RepliesFord Super Duty (1999-2016) :: 2000 F350 - Gas At High Altitude
I've got a 2000 F350 crew cab with a camper I bought in Chile and I'm going to be driving it from the tip of south america back to the US. It's a 9 month epic family road trip. It'll involve crossing the Andes several times and going over 15,000 ft. There are roads up to 19,500 ft in various places.
My question is am I going to have problems with the altitude? What can i do about it? I've got another truck which is a unimog, it's slow as hell but has a special kind of booster gas you can inject in to the engine to get it started in very cold weather and at high altitude. I chose the F350 for the truck instead of the unimog because a unimog is slow as hell (think 40mph max speed), but it handles extreme conditions well.
Ford Super Duty (1999-2016) :: F350 V10 Fan Switch Only Works On High
1999 F350 Crewcab 4x4 dually V10. Fan switch only works on High. All fuses and relays look Good. Is it a bad speed control switch? What can it be?
View 8 RepliesFord Super Duty (1999-2016) :: F350 Missing At High RPMs
I have a miss at high rpms.. I pulled this engine, manual trans, and 4x4 axle and put them in my F350 Majestic motorhome. 156,000 miles on the engine. Slightly dusted engine with good compression 375-400 (cranking and corrected for altitude). Has a little bit of a long start.
No smoke on start up unless 10 degrees or colder
No smoke when pulling either.
Glowplugs ...Good
GPR... Good
Checked resistance from IDM to injectors ...Good
History of some ether for starting before I got my hands on it. I have AE with the ford enhancement. But I am new to working on a powerstroke and new to AE.
ICP ...new
CPS...new
Oil ....new
EBP...new
Installed a pressure gauge to the drivers side upper port on my fuel bowl:
60 psi at idle
55 psi at WOT 2500-3000 rpms under a load
HPOP stabilized pressure is 2750 @ 40% duty cycle
Truck still misses (semi-intermittently) at higher rpm with a load.
Rechecked codes KOEO: None present
I visually inspected valve movement while running (idle). Did the buzz test when cold.... All injectors sounded the same when tested individually.
Did a cct when not completely warm:
P0266
p0272
Repeated the test at normal operating temperature:
P0266
Torque values on rocker arms bolts and injector holds are good. Fuel quality isn't an issue since this problem has remained for 5 tanks of fuel. What I should do next?
Ford Super Duty (1999-2016) :: 2013 F350 - Oil Leaking From Engine
I have a 2013 f-350 with 58,000 miles. I'm a general contractor and drove my truck to a very nice home with decorative concrete. After I left the customers house they called my office to say I left oil stains on their driveway. I looked under the hood and noticed motor oil leaking on the front left side of the engine. I told the customer we will take care of the stain. I've never had a diesel motor leak this soon on me.
My mechanic told me to go to a Ford dealer so I did. The dealer told me that this is not covered under the warranty as it is a oil pump/brake vacuum. THE MOTOR IS LEAKING OIL. I told the dealer that the motor is leaking oil and I have a warranty that I signed up for. He told me that Ford considers this issue the same thing as an alternator.
Ford Super Duty (1999-2016) :: 2013 F350 - No Power At Radio
I have a 2013 F350 king ranch with the 6.7. Radio will not turn on, no power at the radio, however navigation system is working. Could there be something miner causing this problem?
View 5 RepliesFord Super Duty (1999-2016) :: F350 Headlight Bulb Keeps Blowing Both High And Low
2013 F350 passenger headlight bulb keeps blowing both high and low? Replaced 2 times now?
View 1 RepliesFord Super Duty (1999-2016) :: 2005 F350 - No Start - Not Enough High Oil Pressure
I have a 2005 f350 6.0 has 585000. Installed new hpop and lpop and new ipr .pressured oil system with air don't hear any leaks. After truck done started then put truck together no start same problem as before. No oil pressure on dash. All checks goqd except not enough high pressure.
View 2 RepliesFord Super Duty (1999-2016) :: 2013 F350 - Codes P0420 And P0430
I have a 2013 F350 Crew Cab Long bed xl with 128000 miles on it. I just barely bought it from a small dealer and had a check engine light come on for the cats.(P0420 and 0430)
I have spoke with the dealer and he assured me that he would replace the cats. He stated he had O2 sensors replaced and thought he had fixed the problem. Not sure if he replaced all sensors or just the fronts.
He has been avoiding calls lately and will not return my messages. Anyways, My question is what should I be looking for to prevent future cats from going bad. I just ordered a bluetooth OBD 2 scanner and bought the Torque Pro App.
I am not new to working on trucks but they have all been 1995 and older and i am new to anything scanner wise and do not know what I should be monitoring. If I can't get this guy to replace the cats I want to monitor everything to make sure the cats are bad.
BTW, Fuel Mileage is at best 12.3 with an extremely light foot, Driving normal it drops off to about 11.8-12. Is this a normal MPG in these trucks? I have seen post about people getting close to 16 unloaded not smashing throttle?
On another note, I just remembered that my traction control light will come on with no wheel spin at times after starting the truck and driving away.
Ford Super Duty (1999-2016) :: 2013 F350 - Humming Sound When Key Is In Ignition
I've noticed that when I insert the key in my 2013 F250 I hear a humming noise, if I pull the key out it goes away. What is this noise? It seems to do it as long as the key is in, but is quiet enough that you can only hear it when there isn't a lot of back round noise.
View 14 RepliesFord Super Duty (1999-2016) :: 2013 F350 - Check Park Assist Is Always On
I got a 2013 f350 lariat long bed. Had a flat bed put on and now my check park assist is always on.. Dealer didn't install sensors. Is there any module or anything I can do to turn this thing off?
View 1 RepliesFord Super Duty (1999-2016) :: 2003 F350 Starts But Won't Idle
2003 f350 sd 2wd 5.4 auto cab chasis 40 gal rear tank (home depot truck//for real)
Wouldn't start/towed home/ran until it was parked ...
Bad fuel pump//replaced//new fuel filter ...
Starts but won't idle//will run if feathering throttle...
Code's po443/po1451/po1747/po755/po743 never had these codes before
Ford Super Duty (1999-2016) :: 2003 F350 2WD Won't Idle - No Codes?
2003 f350 2wd 5.4 auto cab and chassis with 40 gal rear tank replaced fuel pump/fuel filter/spark plugs/IAC no codes
View 7 RepliesFord Super Duty (1999-2016) :: 2009 F350 - Heater Blower Only Is Now Working On High
Very strange things happening with 2009 F350 Gas, first the heater blower only is now working on high, progressively has gotten worse, low settings started not working a while ago, now only high works. Just recently the strangest thing, start the truck OK, turn on radio OK, turn lights on then the radio goes off. Will bring it to dealer in a day or two if I can't figure this one out.
View 3 RepliesFord Super Duty (1999-2016) :: 2005 F350 - AC Will Not Cycle / Blower Only Blow On High
2005 F350 Lariat ..... I cant get my AC to work in my truck.
AC will not cycle on, Originally thought the system was low because I jumped the pressure switch and it cycled fine (But did not cool inside the vehicle). Checked the pressure and it was in the 40lb range on the low side. My blower will only blow on high but I assumed it was a defective fan speed control.. Possibly an issue with the climate control?
Ford Super Duty (1999-2016) :: 2001 F350 V10 - High Pitched Whine Appear / Disappear
I'm having an issue with my 2001 F350 V10. A seriously annoying high pitched whining noise appeared a while ago, then disappeared, and has now come back.
It happens as soon as I start my truck, whether it's cold or warmed up already. it increases in pitch and loudness as I increase RPM, it also does exactly the same in neutral. As soon as I put it in gear (R, D, 2, 1) it completely disappears and will come back as soon as I shift back to P or N. Strangely, if I drive around town for a few minutes, when I get back home and shift to park the sound doesn't really come back, sometimes it will be faint but usually it's totally gone. But if I shut the truck off and turn it right back on again then it's there again.
It's coming from somewhere in the engine compartment or close but due to the nature of the sound it's very difficult to locate. I got underneath using a screwdriver as a stethoscope and listened to the transmission, transfer case, starter, oil pan and even the gastank and it doesn't sound like it's coming directly from any of them. While underneath I noticed power steering fluid leaking from the pump behind the pulley and dripping off the hose. Somehow though I don't think it's related as the sound disappears in gear and doesn't change at all when turning the wheels. I cleaned the fluid off and drove around a bit and it doesn't seem to be leaking too badly and my reservoir is totally full.
The truck otherwise is driving as good as it always has and whatever this sound is doesn't seem to be having any effect on performance (yet...) ...
Ford Super Duty (1999-2016) :: 2008 F350 - Loss Of Turbo Suddenly At High PSI
Bought a 08 F350 with the 6.4 Liter, with 80k mikes on it. Was traveling up an incline. Both Turbo's were engaged, when suddenly I lost boost, and PSI dropped all the way down. They barely create any pressure now. Checked intake, also checked boots too inter cooler. All seem fine. After driving it for about five minutes at low PSI, a check engine light came on. It was a sudden loss of power.
View 13 RepliesFord Super Duty (1999-2016) :: 2005 F350 - Leak In High Pressure System
I recently came a cross a no start issue with my truck. It is 2005 ford f350 6.0 ... Found out I have a leak in the high pressure system. When I was taking out the bolts out from the manifold I stripped out two bolts. I know ford part # w301383 is the ford bolt. But I was thinking why use that same bolt and had have that issue again later.
View 1 RepliesFord Super Duty (1999-2016) :: 2002 F350 - Cylinders 4 And 6 High To Low Side Open
Alright, so here's what I've got: 2002 Ford F-350 7.3L - Unmodified, Stock, no chip, no tuner, 130K miles, been run with off-road diesel most of its life as a farm truck.
Here's what it's doing: Serious misfire in cylinders 4 and 6. At idle, mild miss. Throttle from 0 to 50 percent, runs well. Throttle from 50 percent to 100 percent, heavy miss, chugging, white smoke out the exhaust.
Here's what we've done so far:
New UVC Harnesses with updated pigtails.
Cleaned Fuel Filter Mixing screens.
Cleaned out fuel tank.
Cleaned bowl.
Changed Fuel Filter.
Changed IDMs
Changed Crank Sensor.
Inspected injectors while running to see if oil is pumping (it is).
No improvement. Where to go from here. Pulled codes, and it says Cylinder #4 and #6 High to Low Side open. We don't know what to do at this point.