Ford Super Duty (1999-2016) :: Roof Channel Sealant Cracking?
I was checking out a rust spot in the roof and upon closer inspection also saw that the sealant in the channels is cracked on the edges. Can't tell if there is rust in there too or just dirt.
View 14 RepliesFord Super Duty (1999-2016) :: 2012 F350 - No Defrost / Stay In Vent Only
I have a 2012 F-350 SRW with a 6.7 diesel. The other day I went to push the defrost switch and noticed it does not work. All the lights work in the switches, and the temp control works, but no matter what I push, defrost or floor, it stay in the vent only. Anything I can check??
View 1 RepliesFord Super Duty (1999-2016) :: 2012 F250 - AM / FM / CD / AUX No Radio Display?
I've got a 2012 F250 XLT with AM/FM/CD/AUX radio, and the display is not working. The radio functions fine, as do all other electronics on the truck, but the display is dark. I've tried pulling Fuse #29 in the passenger kick panel, and it looked fine. Is my radio toast?
View 3 RepliesFord Super Duty (1999-2016) :: Cab Fan Only Turns On When On High Setting
I've got a 2006 SD Lariat, 6.0. The fan only comes on when turned to high. The display moves when the fan speed button is pressed, but nothing from the fan until high. I don't really know anything about the operation of these things, whether they run on a vacuum, or electric, or??? I'm not sure where to start with it.
View 14 RepliesFord Super Duty (1999-2016) :: 2001 - Blower Works Better On A/C Compared To Max Setting?
My 2001 f350 a/c blower works better on a/c compared to max a/c . When I turn the selector to max a/c it makes more of a blowing noise but less air blows out of the vents though. When I select plain a/c it makes less noise but blows more air out of the vents. What is wrong and how to go about fixing it is 93 here today and won't get much cooler over the summer months .
View 5 RepliesFord Super Duty (1999-2016) :: Changing Oil Seals On Front End - Backlash Setting
I'm in the process of changing oil seals on my dually front end. Do I need to worry about backlash settings? I see the gears are attached with solid brackets, which I assume, as just torque to spec and not worry about backlash. What is the torque spec for the four bolts holding the gears/yoke in place?
View 2 RepliesFord Super Duty (1999-2016) :: 2010 F250 - Setting Keypad Code?
I recently purchased a 2010 F250 Super Duty and would like to set a keypad code. I have looked every where I can think of except behind the radio.
View 5 RepliesPrius Plug-in 2012-15 :: Radio Only Access To Channel Numbers Up To 222?
So what's the deal with the channel limitation on the SirusXM radio in the PIP. It seems it can only access channel numbers up to 222 and I see no way to enter or access channel numbers in the 300's and 500's. Am I missing something or are the radios crippled?
View 10 RepliesFord Super Duty (1999-2016) :: 2014 - Headlights Stay On?
This is my first post on this forum. I have a 2014 F350 standard fleet truck. The headlights are not day time running lights. The headlight switch is the basic off/parking light/on. The headlights come on as soon as you start the
truck. This just started happening about a month ago. When you shut off the truck the headlights stay on for ten minutes. I scanned the truck with a snap on modis. I got into the lighting module and the "command on" is on. The modis would not give me the option to turn it off. Short of taking the truck out of service for a day to go to the dealer. Is there any other fix I can do?
Ford Super Duty (1999-2016) :: Keeps Dying / Not Stay Running
My issue is not with the truck starting its with it staying running. I had plugged in all the night prior and all day while at work. When my shift was over went out started fine let it run for about 20 minutes and left to make my way home. During the trip it ran fine for about 1/2 a mile and then it started idling really rough at a stop light went to go threw the light and it as though I had left it out all night with plugging it in. I went to turn on a side street because this situation was not going to end well and it died trying to turn. It would not start back up I was able to get a jump and made another 1/4 of a mile and it died right in front of my house. I replaced both the batteries this morning and it fired right up lasted about a minute and then died again. All the gauge read fine, oil level is good, and the injectors were replaced 2 years ago.
View 14 RepliesFord Super Duty (1999-2016) :: 2002 - Headlights Stay On - Won't Go Off?
i have a 2002 f250 i drove it lat night parked it came home from work at about 3 and noticed my head lights were on and just headlights. I open the door and see that the switch is in the off position too. WEIRD HUH ? they wont go off. I tried to unplug the switch and nothing.
View 6 RepliesFord Super Duty (1999-2016) :: A/C Clutch Hardly Stay Engaged
I was thinking my AC clutch has too much gap and was gonna do the "fix it" listed in another thread. However, my clutch wouldn't engage like it states needs to be done. The only time my AC blows cold is when it's cold/cooler outside OR I rev up the RPM's but it hardly stays engaged. I had a friend do a few diagnostics on it, with a paper clip (assuming he did it right) he feels my clutch is bad. But I've read the clutch is either good or bad, works or doesn't work, no in between.
Next, it doesn't seem to blow as hard as it used to. I replaced the blower motor last summer, but even before that, it seemed to not blow very hard. If I have it on low, it's very hard to feel it. With a crew cab and 2 little boys seated in the back, they often end up sweaty and miserable, no matter how far we go. I've read the orifice tube might need to be replaced, or something needs to be cleaned cuz it's dirty or clogged like the orifice tube. But I can't remember what.
Ford Super Duty (1999-2016) :: Headlights Stay On And Smoke From Fuse Box
Walk out to my 02 f250sd this afternoon after it sat for 9 hours while I was working... the lights are on... look inside and the light switch is in the off position... Open the door and it smells like burning wires. Car cranks without a problem but lights will not go off. Unplugged light switch and still lights are on. Open fuse box and all fuses look good none of the relays are hot. Reach around to back of fuse box and almost burn my fingers. Remove 4 screws that hold box in place and look around back. Unplug the wires going into fuse box and see that one is melted and it appears it is melted inside the fuse compartment itself. What might be going on inside this black box?
View 11 RepliesFord Super Duty (1999-2016) :: Right Side Passenger Blinker Does Not Stay On
Yesterday jump in truck head out and when I go to use right (passenger) blinker and it doesn't stay on. Left side works fine. It will stay on if held but on it's own it blinks like 4 times then shuts off.
Side note not sure if connected but a couple days before was using wipers and when I shut them off it was still like it was on intermittent. It happened a couple times but seems fine now, but then with the blinker I am wondering if it is something in there.
Ford Super Duty (1999-2016) :: 2005 F250 6.0 - Headlights Won't Stay On
I bought an hid kit for my 2005 f250 the dog lights work fine but the headlights won't stay on. They come on for about 30 seconds then shut off. How to fix this. I've swapped the ballast with the fog light ballast and it does the same thing.
View 3 RepliesFord Super Duty (1999-2016) :: Parking Brake Pedal Won't Stay Down
When I parked my truck at work this morning, I pushed the parking brake pedal down like always, but it popped back up. I didn't pop all the way back up, it stayed down about 1/4 of the way. Several tries yielded the same results.
Since I'm at work, I didn't have any time to crawl under there are investigate. I'll do so tonight when I get home, or maybe tomorrow. Kinda sounds like the locking "teeth" mechanism may be misaligned?? Since it doesn't come all the way back up, I'm hoping the mechanism isn't totally broken.
Ford Super Duty (1999-2016) :: CC Displays On Right - No Outer Temp And Temp Setting?
My CC display shows all icons on the right regardless of settings (see pic). The temperature setting and outside temp will not come on.
The second issue is that my front blower starts to lose velocity and sounds strange on long road trips.
Ford Super Duty (1999-2016) :: F450 Would Not Stay Running Almost As If Out Of Fuel When Cold
Got a 99 F450 7.3 with 190k miles, started acting sluggish. When cold, it wouldn't stay running, almost as if out of fuel. Would stall out when you pressed and released the accelerator but would idle fine. Now, it won't even stay running. Still acts like it's out of fuel. Changed the air filter, fuel filter, and added injector cleaner and conditioner. What else could it be? after warming up when shifting gears and letting off throttle it stalls and when restarted lets off blueish white smoke.
View 2 RepliesFord Super Duty (1999-2016) :: Ignition Switch Off But Electric Accessories Stay On
Okay, I've done a few topic searches and see some variations on this, but not this specific scenario. 2001 F-250 (5.4L, 4x4, auto). My daughter's truck and I wasn't home so this is the best info I have as relayed by her.
She turned the key off, the engine shut off, but all the "electrics" stayed on -- radio and a/c fan to be specific. She said that morning the truck had a dead battery so she got a jump start, leading one to suspect that the electrics stayed on the previous night as well. (?)
I had her disconnect the battery and let it sit until I got home. Of course, when I got home and reconnected the battery, everything works normally as it should. And has worked normally for a few days.
So.. any words of wisdom out there while we wait for "the next" occurrence?