Ford Super Duty (1999-2016) :: 2005 - Ignition Switch Or Bus Bar Bad?
2005 Ford F250 5.4 ... Having problems with ignition switch or bus bar in that circuit being bad?
View 3 RepliesFord Super Duty (1999-2016) :: F350 Ignition Switch Chimes Key-in Buzzer When No Key
Question: How easy is it to replace the key switch - do I need any special tools? Is there a way to upgrade to one which requires an encrypted RFID key? Or is there an easier fix to my problem below?
Background: On my '05 SD, I am getting a weird problem where the ignition switch chimes Key-In sometimes when there is no key. I can get this to go away by fidgeting with the key switch, but since I am going to be installing a remote start / security system, I need to fix this...
Ford Super Duty (1999-2016) :: F350 - Heater Blower Runs When Ignition Switch Is Off
The heater blower in my 1999 F350 continues to run after the switch is turned off. I checked the relay and it is working properly. Looking for a wiring diagram showing the control circuit for the blower?
Do the heater switch controls power to the relay coil or if the switch grounds the coil to pick up the relay?
Ford Super Duty (1999-2016) :: 2001 - Won't Start But Radio On Even With Key Out - Ignition Switch / Actuator?
I have a 2001 f350 this morning I went to start the truck the key turn but I heard a click sound all the lights and everything came on but the truck won't start just silence I could turn the key back in the off position and put the key out but the truck is still on radios on it's like the truck is still in the run position or on position there is a lot of play between off and run but like I said the truck will not start, could be not sure if it's the ignition switch or actuator rod..
View 2 RepliesFord Super Duty (1999-2016) :: 2003 F250 - No Headlights When Ignition Switch Is On / Wheezing Sound For A Second
Headlights work well w/ ignition switch off. High/low/passing all ok. When I turn the ignition switch on, there's a strange wheezing sound for a second.
When the ignition switch is on, there are no headlights.
What's the wheezing sound? Why does the power to the switch quit with the key on? The more I work on modern trucks, the more I like my 1968 f-250.
Ford Super Duty (1999-2016) :: 2005 F250 - No Power To Some Accessories
I just bought a 2005 Ford F-250 Super Duty 4WD. My problem is, my power port, lighter and diagnostic connection don't work. Also, my radio powers up but no sound (which may just be loose speaker wires). My question is, if my fuses are not blown, where should I start looking next to troubleshoot this problem?
View 1 RepliesFord Super Duty (1999-2016) :: Key Fob Won't Operate Electric Locks
I put new batteries in the fobs, and my electric locks work using the buttons in the door.
Checked the key fobs at autozone.. they are ok.
Is there a training procedure for Ford OEM fobs?
F250 2002 4x4 5.4 Lariat Crew
Ford Super Duty (1999-2016) :: Electric Wiring Diagram To Stop Turn LED Bar?
Just got an inexpensive LED Stop/Turn/Taillight Bar my problem is it has (3) wires Red, Black and White while the available connection from the old bar has only (2) wires Black and White with Red Dots.
The wiring instructions for the new LED bar says (1) Attach black wire to tail lamp circuit(+), (2) Attach the Red wire to the stop/turn circuit(+) and (3) Attach white wire to a good ground(-) location.
How I should hook this up? My thought is Black to Black , Red to White with Red Dots and White to Frame metal.
Ford Super Duty (1999-2016) :: 2008 F550 - Interior Electric Systems Not Working
2008 F 550 6.4L Diesel 2wd... Truck has a few interior elect systems not working. ALL fuses are good. Message center not working at all, HVAC fan not working, key/lights chime not working, and radio lights very dim. All of these problems started at once. Everything else on truck works fine.
View 2 RepliesFord Super Duty (1999-2016) :: 2015 F350 - Electric Locking Axle Swap
Putting in a locking axle to replace there non locking axle? Have a 2015 f350. And found a electric locking for a great price. Can this swap be done?
View 14 RepliesFord Super Duty (1999-2016) :: Electric Cord Running To Rear View Mirror?
Why there is an electric cord running to my rear view mirror?
View 5 RepliesFord Super Duty (1999-2016) :: Small Electric Pump Noise Coming From Under The Hood On Shutdown
I have a '12 F250 w/ 6.7 diesel. Lately when I turn off the ignition after a few seconds I hear a noise that sounds like a small electric pump coming from under the hood on the passenger side.
This also happened a while back but at the time the service people said they could not get it to do that and it eventually stopped.
Ford Super Duty (1999-2016) :: 2000 F350 - Electric Vacuum Motor Stays Running
I have a 2000 F-350 diesel and the electric vacuum pump went out. I bought a new one from napa and it would not stop pumping. Checked for leaks and found none. If I unplug the hose from the vacuum can the next day, you can hear it suck air so it seems I am holding vacuum. Problem is I burnt out the new pump in two weeks from running all the time. Bought another one and same problem.
So now I plug the electrical in and let it build up vacuum for a couple of minutes and then disconnect it so it won't burn out and I am good for days on vent controls and 4x4. If there has been a bad batch of pumps out there? I also unplugged the hose from the pump to the holding tank and put my finger over where the pump sucks and it still did not shut off.
Ford Super Duty (1999-2016) :: Front Electric Windows Goes Down Slowly And Eventually Stops Halfway
The electric windows in the front seem to be very lazy. When you depress the button, it goes down slowly and eventually stops halfway. Does it need a lube?
View 1 RepliesFord Super Duty (1999-2016) :: 2014 - Headlights Stay On?
This is my first post on this forum. I have a 2014 F350 standard fleet truck. The headlights are not day time running lights. The headlight switch is the basic off/parking light/on. The headlights come on as soon as you start the
truck. This just started happening about a month ago. When you shut off the truck the headlights stay on for ten minutes. I scanned the truck with a snap on modis. I got into the lighting module and the "command on" is on. The modis would not give me the option to turn it off. Short of taking the truck out of service for a day to go to the dealer. Is there any other fix I can do?
Ford Super Duty (1999-2016) :: Keeps Dying / Not Stay Running
My issue is not with the truck starting its with it staying running. I had plugged in all the night prior and all day while at work. When my shift was over went out started fine let it run for about 20 minutes and left to make my way home. During the trip it ran fine for about 1/2 a mile and then it started idling really rough at a stop light went to go threw the light and it as though I had left it out all night with plugging it in. I went to turn on a side street because this situation was not going to end well and it died trying to turn. It would not start back up I was able to get a jump and made another 1/4 of a mile and it died right in front of my house. I replaced both the batteries this morning and it fired right up lasted about a minute and then died again. All the gauge read fine, oil level is good, and the injectors were replaced 2 years ago.
View 14 RepliesFord Super Duty (1999-2016) :: 2002 - Headlights Stay On - Won't Go Off?
i have a 2002 f250 i drove it lat night parked it came home from work at about 3 and noticed my head lights were on and just headlights. I open the door and see that the switch is in the off position too. WEIRD HUH ? they wont go off. I tried to unplug the switch and nothing.
View 6 RepliesFord Super Duty (1999-2016) :: A/C Clutch Hardly Stay Engaged
I was thinking my AC clutch has too much gap and was gonna do the "fix it" listed in another thread. However, my clutch wouldn't engage like it states needs to be done. The only time my AC blows cold is when it's cold/cooler outside OR I rev up the RPM's but it hardly stays engaged. I had a friend do a few diagnostics on it, with a paper clip (assuming he did it right) he feels my clutch is bad. But I've read the clutch is either good or bad, works or doesn't work, no in between.
Next, it doesn't seem to blow as hard as it used to. I replaced the blower motor last summer, but even before that, it seemed to not blow very hard. If I have it on low, it's very hard to feel it. With a crew cab and 2 little boys seated in the back, they often end up sweaty and miserable, no matter how far we go. I've read the orifice tube might need to be replaced, or something needs to be cleaned cuz it's dirty or clogged like the orifice tube. But I can't remember what.
Ford Super Duty (1999-2016) :: Headlights Stay On And Smoke From Fuse Box
Walk out to my 02 f250sd this afternoon after it sat for 9 hours while I was working... the lights are on... look inside and the light switch is in the off position... Open the door and it smells like burning wires. Car cranks without a problem but lights will not go off. Unplugged light switch and still lights are on. Open fuse box and all fuses look good none of the relays are hot. Reach around to back of fuse box and almost burn my fingers. Remove 4 screws that hold box in place and look around back. Unplug the wires going into fuse box and see that one is melted and it appears it is melted inside the fuse compartment itself. What might be going on inside this black box?
View 11 Replies