Ford Super Duty (1999-2016) :: 2006 F250 - Tow / Haul Light Only Blinks For First Couple Of Minutes Of Driving Then Stops
I've got a 2006 f250 with 160,000 miles, trans was rebuilt by previous owner about 10,000 miles ago. The tow/haul light started blinking yesterday, only blinks for first couple of minutes of driving and then stops. Service engine light popped on today as well. Won't have access to a code reader until tomorrow, but looking for some preliminary info...
View 3 RepliesFord Super Duty (1999-2016) :: 2006 F350 Not Starting - Code P2285 - Injector Control Pressure Sensor Circuit Low
I have a 2006 f-350 6.0 and i went to fill up my truck with diesel. After that the truck did not start. Currently has the code p2285 - injector control pressure sensor circuit low. I tried disconnecting sensor, still no start.
I have the torque pro app and another 6.0 that I use for comparison. Check power at ficm 48 volt, flp 11.5v, FVP 11.5v. Hpop while cranking shows 1400 psi. removed oil filter and see low pressure oil ok, fills up reservoir. ipr at crank about 65%. fuel filter full of fuel.
Replaced the dummy plug on passenger side because originally hpop was very low psi 12. after replacement it went up to 1400 on cranking. What should I be looking at next, should I be removing ipr? should i be looking at crank sensor or cam sensor? Just installed 2 new batteries also because my dad kept cranking the truck until it died.
Checked to make sure fuel cut off relay not triggered, Ok. The truck has been having long cranks before it died. Also right now the injector cycling is 10 seconds long while on my other 6.0 it is about 4.
Ford Super Duty (1999-2016) :: 2006 F350 Shuts Down While Driving After Hard Acceleration
I have an 06' f350 6Ltr. Over 300 k. Good shape, i have owned it for about a year. My first diesel. Last week it wouldnt start, had a 1/4 tank. Read about problems with other trucks with a broken pick up on fuel pump. So i filled the tank and it started. Next morning used command start and it ran for 1 minute then shutdown. took about 5 minutes of manually turning it over and it fires up ran all day. Does this almost everyday since and now shuts down while driving after hard acceleration and surges under acceleration when on incline or underload. Changed fuel relay, fuel filters. Researched and asked around but getting mixed opinions. I am mechanically inclined but this is a little beyond my scope of trouble shooting and id rather not start throwing parts at it.
View 1 RepliesFord Super Duty (1999-2016) :: Died Going Down Road - Oil Pressure Gauge On Dash Dropped
2002 7.3 powerstroke, no info about service or work done, looks to have a new hpop, know for sure that there was a new lpop installed, claims no gouging in front cover, died going down road oil pressure gauge on dash dropped and was taken to a shop and did not get complete diagnosis, where should i start? Shop drained oil to take sample and no metal shavings or flakes were present according to them...
View 3 RepliesFord Super Duty (1999-2016) :: 2002 F350 TPS - Low Crawling / Throttle Is Very Jerky Off Road
My truck is a 2002 F350 CC dually longbox 4x4 7.3 auto that I bought last fall. On the street it is very well behaved although I suspect it is not giving me as much power as it should be, as compared to my previous 95 powerstroke.
Off road, slow crawling, the throttle is very jerky. Under acceleration it is smooth, but if I try holding a low throttle position, the rpm rises and falls. I am certain this is a bad TPS, and may also be contributing to my perceived low power on the street.
I have googled my brains out and it seems there is a cheap replacement TPS for earlier trucks but the 2002 has the 5 wire combined TPS and IVS, which reportedly is not replaceable without replacing the whole pedal assembly. To complicate matters I have the adjustable pedal assembly
So are there any options other than buying a complete pedal assembly from ford? Can I save some bux and retrofit a non-adjustable pedal assembly? I saw a youtube video where a guy put a newer 6.0 pedal assembly in but he was short on specifics about what exactly he gained doing this.
Ford Super Duty (1999-2016) :: 2000 F350 Front End Vibration When Hit A Little Bump On The Road?
2000 F350. 4x4, V10. 153,xxx miles. Here's the story. Whenever I hit a little bump in the road, I get a vibration directly under my feet and in the gas pedal, NOT in the steering. It will go away pretty quick or when I hit another bump. It only happens when the front driveshaft is not spinning. Hubs locked in in 2WD, it doesn't vibrate. Hubs unlocked and in 4x4 High it doesn't vibrate.
View 8 RepliesFord Super Duty (1999-2016) :: 2012 F350 - Road Armor Bumper Installation?
I am installing a set on a '12 F350 for a customer. I already had to go buy an additional hardware in order to get the back bumper on correctly...and now I'm looking at the front bumper and I swear I don't have the parts I need to install it. It appears to be missing some brackets. There were NO instructions with them (apparently a chronic problem with Road Armor) and I can't possibly imagine it bolting to the flimsy brackets that hold the factory bumper (fairing would be a better word for it) in place.
View 6 RepliesFord Super Duty (1999-2016) :: 1997 F350 - Engine Stalls Going Down The Road With No Warning
I have a 1997 f-350 crew cab 4x4 w/ off road package and 7.5 fuel muncher power package. My engine stalls going down the road w/ no warning. Sometimes it will start back up immediately, and other times not until i cycle the ignition 6 times or so.it seems to be getting worse as time goes by. Since it started i replaced tps, cap, rotor, plugs and wires. I also replaced fuel tank and pump and filter about 1.5 years ago. Some other issues to clear up, but concerned w/ current problem.
View 2 RepliesFord Super Duty (1999-2016) :: F350 - Rear Suspension Clunk Over Bumps / Heaves In The Road
I have a 2005 king ranch and have a clunk coming from the back over bumps/heaves in the road. It doesn't happen all the time but often enough. I just replaced the shocks, that worked a little but didn't solve the problem. Now thinking rear sway bar end links? Anything I can check/inspect?
View 1 RepliesFord Super Duty (1999-2016) :: F350 4x4 Death Wobble Felling Even Around Slight Bends In The Road
I put new ball joints on a few months ago and now the truck is starting the death wobbles felling even around slight bends in the road.I jacked it up and the passenger side tire will move 1" side to side scarey.Not sure what I need to replace.
View 9 RepliesFord Super Duty (1999-2016) :: Getting Vibration Driving Down The Road
01 F350...4R100/V-10/4wd. Sometimes get a vibration driving down the road. First thought of tire out of balance but then the vibration goes away and may not come back for a few days or more. It starts sometimes around 30-40 mph and stays all the way up to around 65 mph. Even slowing down it vibrates or shakes. I can stop and take off again with nothing happening. Would think tires out of balance would do it all the time. And a few times....pulling my 5th wheel...making a right turn out of a parking lot.....it feels like a rumble from the rear.
View 2 RepliesFord Super Duty (1999-2016) :: F250 Cutting Off When Driving Down The Road?
While driving down the road the truck will just cut off. We wait a few mins and start it again can drive a few miles and it cuts off again. we have replaced the ignition coils and it is still doing this. No codes are coming up to get any idea what it can be?
View 14 RepliesFord Super Duty (1999-2016) :: Loud Spinning Sound When Driving Down The Road
I have a 2004 Ford f250 6.0. When driving it down the road i will hear a loud spinning sound, sorta like putting a playing card in your bicycle spokes. The sound can be heard until I make a complete stop where at that time the sound stops and a clunk can be felt. After that the truck sounds normal. This also only happens once between starting the truck and turning it off. I took it into the shop and they could not hear the sound, all they said is i need new ball joints.
View 6 RepliesFord Super Duty (1999-2016) :: Steering Went Out Completely When Driving On A Straight Road
A few weeks ago, my employees were driving home one of my work trucks, a 2001 F350 7.3 4x4 Crew w. 130K miles. They were on a straight road in a small town when the steering went completely out. The truck veered into a telephone pole. No one was injured. The truck has major damage to the front passenger's side.
I finally got the truck back to my shop today. It is quite evident what caused the problem. The gear/splined shaft that protrudes from the steering box and is connected to the pitman arm sheared completely off.
Ford Super Duty (1999-2016) :: Engine Died Suddenly When Driving Down The Road
2004 F-250. 6.0 I was driving down the road when the engine dies. It was like I had turned off the key. When I tried to restart it, it was no click, no starter sound, nothing. The glow plug light remained on, even while turning the key over. What could cause this?
View 10 RepliesFord Super Duty (1999-2016) :: F250 Started To Surge When Driving Down The Road
I have a 99' f250 I purchased a few months ago. Here's what happened. Today I was driving down the road and it started to surge. I pulled over and shut the truck off. When I went to start it, the motor turned over slow for a sec and then clicked. When I put a jump pack to it, it fired up. I took it home with the jumper still hooked to it and checked voltage. The alternator was throwing 33.4 volts!! I went to the auto parts store and bought a new battery and alternator. Now the battery shows 11.7 volts steady. The alternator still reads 33.4. Also, if I unplug the positive lead while it's running, the truck shuts off. And one more thing. If the key is off and I reconnect the positive lead, I can hear the fuel rail pressurize. What is going on? I hate electrical gremlins.
View 6 RepliesFord Super Duty (1999-2016) :: 2000 F350 - No Oil Pressure When Truck Started
So I went to start the truck this morning around 8:00 and it was 7 degrees outside, when the truck started the oil light came on and oil gauge was on low? So I turned it off right away. few hours later I tried it again and still nothing I thought maybe the oil was frozen. After I started the truck the oil was higher on the dipstick so I am assuming the oil pump is functional. What could be causing this? Could it be the the gauge is not working? The truck is a 2000 F-350 V-8 5.4 gas. I'm hoping it is something simple I am suppose to work this afternoon
View 14 RepliesFord Super Duty (1999-2016) :: 2005 F350 - No Start - Not Enough High Oil Pressure
I have a 2005 f350 6.0 has 585000. Installed new hpop and lpop and new ipr .pressured oil system with air don't hear any leaks. After truck done started then put truck together no start same problem as before. No oil pressure on dash. All checks goqd except not enough high pressure.
View 2 RepliesFord Super Duty (1999-2016) :: 2006 - Run 10 Miles Then Die With No DTC?
I have an 06 6.0. I have replace icp and ipr. I had a car tube with an hole so I replaced the tube connectors. No dtcs are present. The truck will crank and run fine but after thirty minutes of running it dies, it dies faster if I put it in gear and drive it, if I move it back to neutral it starts running ruff and I lose throttle response sometimes completely and sometimes on a minute or two. I also fixed a fuel leak around the 6mm plug on pump, replaced both fuel filters.
View 8 Replies