Ford F-150 (2009-2014) :: Exhaust Leak Only When Cold?
So after remotely starting my truck on a cold morning, I walk up to the vehicle and notice a small puddle of water near the middle of the truck (not near the engine where the A/C usually drips), and I can also hear a slight ticking noise that I never heard before. I stoop down and can see water dripping from the exhaust (I think off the back of the resonator?). I snap a few pics and decide I'll take a closer look later, but curiously when I return from my drive, the leak and noise are gone.
With 76K miles on the truck, is it possible I've developed a pinhole sized perforation or leak in the factory exhaust system (or maybe there's a loose fitting) that is only present when the engine is cold, but "seals" itself up once the engine is warm and the metal has expanded? I only see the water puddle and hear the noise when remotely starting the truck on cold mornings, never on warm days or after driving around town.
Ford F-150 (2009-2014) :: 2012 - Metallic Ticking Sound When Cold?
I have a 2012 F150 5.0 I just bought a couple weeks ago. I have a metallic ticking sound when cold, you can hear it when it idles down, but once driven and hot it is more faint but still there. Its not the injectors, Ive checked that.
Ive seen it posted in various forums but no cause mentioned. Ive had it in to the dealership and they are waiting for Ford to get back to them on what to do but I fear they will say its normal. My friends 2013 doesn't do it at all.
Listen to whole video, wait until the camera was placed on tire and its idled down to hear it. Its louder in real life but not extreme loud.
[URL] ....
Ford F-150 (2009-2014) :: 2010 5.4L - Ticking Sound From Engine?
I've had this truck since new and now with 98k miles I just started to hear the dreaded engine ticking. I realize that it is probably the cam phaser's. I have plans to take it to the dealer to get the plugs changed (actually not bad at $225) and now I going to add the ticking noise to the list. How bad will I get killed for two new cam phaser's? Also, since this just started, am I doing any more damage by continuing to drive it? I probably won't be able to take it it for another month.
View 5 RepliesCamry :: 2010 - Engine Lifter Ticking Noise On Cold Start Until Warm
I just punches a 2010 Camry 4 cylinder with 44,646 miles. Very clean. I've owned 2 camrys in the past a 97 and 2002 that both reached well over 200,00 miles without a hint of trouble. Well, when I start the 2010 when its cold like from overnight it sounds like the lifter are ticking?, it lasts until the engine is warm and then I don't hear it. It still has the 2 month 3000 mile warranty from the dealer. I just don't seem to remember our other Toyota sounding that way.
View 14 RepliesElantra XD (2001-06) :: Exhaust Leak Sound From Engine Compartment Only At Cold Startup
I hear a bit of exhaust leak noise from engine compartment only at a cold startup, it goes away in seconds. I am 700miles from home. If it's a nonessential fix i will drive home before fixing, or, if an easy gasket replacement, I have two more days here, and tools,garage, and competent support to diy the job.
View 4 RepliesFord F-150 (2009-2014) :: 2012 - Cold Start Humming Sound
I have a 2012 F-150 Platinum 6.2L. Every morning after a cold start, I get this humming sound until the engine heats up. It does seem to get a little quieter when I'm moving but not much. This only happens after the first start of the day and has only started doing this since it's been cold (20-30 F).
YouTube ......
Ford F-150 (2009-2014) :: 2 Second Clatter Sound On Cold Start - Cam Phaser?
It seems that my 09 F150 has developed a troubling noise... I'm looking for any cam phaser. I'm at 116,712mi. 5.4L motor of course.
On cold start, I hear about 2 seconds of "clatter" - sounds like something is "loose" on top of the motor. At hot idle, I hear the classic "diesel" idle, indicative of the cam phaser issue. In gear, the rattle intensifies and is very noticeable around 1000RPM.
Other than the noises, the truck runs great - like new.
Here's a video: [URL] ....
Under hood, under hood close up, driver's wheel well, interior, then interior in gear. You'll need to crank the volume to hear the last two.
Best I can tell, this is not an exhaust manifold issue. So, what say you? Cam phasers?
Ford F-150 (2009-2014) :: Loud Ticking On Right Side When Cold
I have a 2010 F150 with the 4.62v. I bought it new in March '11 and have used either MC 5w20 or Pennzoil 5w20 and MC filters, changing every 5k since new. When cold (30deg F or below) the right side has a loud ticking, until it has run for approx 1 minute. Since it is a 2v, cam phasers should not be a part of the problem. What the issue could be. It has just over 36k now, so the powertrain warranty should still be valid.
View 10 RepliesFord 7.3L Power Stroke (1999-2003) :: Engine Ticking - Exhaust Leak?
As it says, I have a tick. It's not apparent at idle and increases with engine speed.
Just spent $570 having bellowed up-pipes installed and while a little quieter, the tick is still there. What else tends to go out on these things? Manifold(s) cracked, manifold gasket(s)? It's seen high EGT's quite a bit but not for longer than 20-25 seconds.
Impala - Chevrolet :: 2001 - Engine Ticking Sound For About 2 - 3 Minutes Every Time On Cold Start
I own a 2001 chevy impala 3.8 and I recently had a good friend of mine whose going to school as a mechanic install a manifold gasket upper and lower but now I am hearing this loud tick tick tick sound for about 2-3 min every time i start my car in the morning and then the noise goes away and its normal it never made this noise before is it harmful and break my engine or is it okay to just leave it....
View 12 RepliesFord F-150 (2009-2014) :: Exhaust Leak Under The Hood
I have had an exhaust leak under the hood of my 09' F150, XLT, 4.6 3V for some time now and decided to get it checked out. I took to the local stealer and as i suspected its the manifolds. There are 4 studs on the left and one stud on the right sheared off. Ford quoted $1400 for replacing both mainfolds and extracting the broken studs. This would give me the exact same manifolds that were on the truck from the factory and started leaking at 78,000 miles.
So I decided to take the truck to a local speed shop that I have used in the past for other things. The mechanic there said to just buy a high quality set of stainless headers, stage 8 locking fasteners, and copper gaskets. He will install. I went with JBA shortys from AutoAnything.com and the mentioned hardware from Jegs.
So basically for around $100 more I get headers that probably will last the life of the truck. I am quite displeased with the exhaust issues that Ford has had and known about for over 20 years. The service manager at Ford said they replace manifolds with broken studs on a regular basis. He also said it was a wise choice to go with the headers instead of the manifolds even though they will not install them. That says a lot about the confidence of the Ford service department in their parts and vehicle designs.
Its a little sad that a 6 year old truck with only 78,000 miles....
Ford F-150 (2009-2014) :: Exhaust Leak At Manifold Collector?
I currently own a 2009 F-150 XLT, ext. cab, 4X4, 4.6l, 6R80 trans. Surprise, Surprise I have just developed an exhaust leak at the manifold collector. After some careful investigation, I separated the pipe from the manifold and the sealing surface is totally rotted away. I cleaned it up as best as I could and slathered some muffler cement inside the joint to seal the leak. It is about 80% better but will get worse again I'm sure.
I visited my local Ford dealer and talked to a friend I have working there and he said Ford has known about quality issues with manifolds for years and he was surprised that the manifolds lasted 70k miles.
I am hoping to use the truck as is through the winter and in the spring I am going to install these headers:JBA Headers - Reviews on JBA Cat4ward Exhaust Headers - Stainless, Ceramic & Chrome Finishes
This intake:K&N 63 Series AirCharger High Flow Cold Air Intake Kits Best Price & Reviews
This tuner:Bully Dog Triple Dog GT Tuner (49-State Legal) - Bully Dog GT Tuner Reviews on Gas Programs for Dodge, Chevy, Ford & Nissan Trucks
I already installed a Flowmaster American thunder catback exhaust system about a year ago...
Ford F-150 (2009-2014) :: 2013 - Idle Was A Bit Jumpy Warm Or Cold
Got a 13 f150 with the 5.0. I bought it used with about 14 thous kms, now it has 17. Ever since I owned it I noticed the idle was a bit jumpy warm or cold. I didn't really pay any attention to it as it wasnt throwing a CEL or anything but now that I have a roush exhaust and intake I have started to notice it a lot more....not that its worse but at idle my truck sounds like a boat. Weird comparison I know. It seems like it'll jump within +/- 200 rpm @ idle which IIRC is 1K rpm.
View 7 RepliesFord F-150 (2009-2014) :: 2011 - Heater Blows Cold Air / Not Even Coming Close To Warm
So the other morning I drive the 140 miles out of town to work for the week. when I pull up to the job site the cooling fans were revving really really high! never heard this before. then it went back to normal after I opened the gate and parked my truck and shut it off. I'm driving maybe 5 miles tops to the job and back to the motel every day. however that is far enough that my heater should be warming up and it's not even coming close to warm. it blows cold air. and to compound that I'm not sure the cooling fans are even working. they don't appear to be. Is there a connection here?
2011 xlt 4x4 super crew.....
Ford F-150 (2009-2014) :: 2013 - AC Fluctuates From Cold To Warm With Heavy Damp Smell
AC used for the first time since purchasing the truck last Oct. I notice and passengers in truck with me as well notice that the AC is not strong at all and it fluctuates from cold to warm with a heavy damp smell almost like its letting fresh air in mixing with the cold AC. It seems to be doing this more so when driving but will also do it at at idle after driving. Of course dealership states perfect temp blowing @34 and Freon at perfect levels. Max AC will not blow you out of the truck and reg ac at lowest setting feels like its on a vent setting. When AC first comes out it smells very damp mildew smell. 2013 F-150 Limited 3.5.....
View 3 RepliesLexus LS 2007+ :: LS460 Engine Noise - Exhaust Leak Or Fan Blade Ticking
Strange ticking noise that you can hear in the cabin sounds almost like a exhaust leak or a fan blade ticking something under the hood.. I have had the dealer check it they say nothing is wrong i just can't believe a 75k car can have this noise...
View 14 RepliesFord - Explorer :: 2008 - Sound At Start Up At 63K Miles - Exhaust Manifold Leak?
I purchased my 2008 Explorer Ltd about 4 months ago with a 4.6L and 63k miles. I use it for towing a small travel trailer, so I don't put many miles on it. It's got about 66k on it now. According to OASIS, it has had all MFR maintenance performed up to the 60k mark.
In the past two months, it has developed a "sound" on startup. it goes away after about 75 seconds. To me it sounds like a typical exh manifold leak. That "3 cylinder, putt putt putt tractor" sound. There is no apparent affect on performance. It is definitely coming from the area of cyl #1. I have a recording here.
[URL]....
It is the "higher" of the sounds. The lower pulsing/whooshing is just regular engine noise. You can hear the regular engine noise as the camera pans to the back of the car.
What puzzles me is that the exh manifold sound goes away after 75 seconds or so. Holding the tailpipe shut for a bit builds up lots of pressure quickly. Do you think it IS, in fact, an exh manifold leak, and it seals up with thermal expansion as the engine worms up (75 seconds)? Is this a typical issue with the 4.6L
Ford F-150 (2009-2014) :: 2010 4.6L 3v Engine Ticking / Fluttering Type Noise
I just bought a 2010 F150 XLT XTR SuperCab 4X4 with a 4.6L 3V engine. I had a 2003 5.4L and a 2004 V10 before and this new engine seems to be nosier then the older ones I've had. It's a ticking/fluttering type noise I here when I'm standing outside the truck while it is idling. Is it normal for these newer 3V engines to make this noise? My wife has a 2009 Hyundai Santefe and it makes a similar noise just not as loud. Does the 5.4L make a similar noise also?
View 12 RepliesFord F-150 (2004-2008) :: New Exhaust / Sound Under Load And At Cold Start
So I finally went and put the exhaust I had been wanting on my truck. Pretty simple set-up. I had the factory muffler cut off and a flowmaster 40 series on it previously. I liked the sound under load and at cold start but normal driving I could not tell a difference from a factory muffler. So I had the flowmaster removed. I still have 4 cats so it's not crazy but it is loud. The only time I have cackle is on initial start-up not even at WOT which was a pleasant surprise. I just like the look of a single exhaust but still want some sound. I have been gone awhile as I needed a little break from starting and also being drawn in to arguments.
View 7 Replies