Ford F-150 (2009-2014) :: Ticking Noise At 800 To 1000 RPMs / Rough Idle Leads To Engine Fail
2010 F150 ... So I have the tick noise at rpm's 800-1000 at drive through, stops, etc. So I did research on it a few months ago and saw that it might be VCT's but should be able to drive. so I drove it waiting to save money and have it go to a shop. well this past weekend while coming home from work my oil light came on the pressure dropped to zero, I was on the highway so I drove about another mile to get off highway and once I got off my truck died. I had it towed to my house and I thought I blew my motor. So I started doing research here and found that the VCT's AND cam Phaser could be bad. so I replaced my VCT on driver side put it all back together it started and loud knock was gone. then after 5 mins it was back very loud knock!
So I shut it down and took apart the passenger side once I got the valve cover off I found the problem.... The bolt that holds the cam phaser in place snapped off and was riding along the camshaft. So I took that out and extracted remaining part of bolt. inspected my camshaft and it was really messed up. so I bought new Phaser and Camshaft. the camshaft just came in today and I am trying to put it back in. but the hole for the pin in the phaser doesn't line up and I cant spin the shaft to make it line up. should I spin the cam phaser? I marked the chain and the phaser is where it should be on chain, but with that bolt snapping off could that have thrown the timing off so my mark is no good? when I lay the camshaft in place it sits perfect and if I just move the phase over 2-3 links it will all fit together. Should I do that?
Ford F-150 (2009-2014) :: Bucking At Lower RPMs
This is not on our F150, but rather our Flex that has the 3.5 Ecoboost.
Recently we have been having a bucking problem at lower rpms. Usually when taking off and hitting a slight grade. Doesn't really have a problem at highway speeds. Usually only on takeoff when it shifts through the gears. If you accelerate more, you can stop it for the moment. Weather doesn't make a difference. Also can feel a slighting surging sometimes and can see it on the tack. Like a 2 sec alternating surge. Doesn't do this all the time though. I have replaced plugs with iridium, gapped at 34.
I also purchased two motorcraft coil packs and installed them in different configurations as to see if I could isolate it. No change. I HAVE NO CEL YET. At all. Wish it would! I have tried to make it buck hard enough to throw the code to no avail. I have heard of condensation in the intercooler, but from what I have read it is a higher RPM symptom..This feels just like the COP problem on my 5.4. Unless I have 3 or 4 bad COPS and no CEL. If I could just get a code.
Ford F-150 (2009-2014) :: RPMs Drops While Shifting?
Used to own a F250 so I am new to the F150. I am currently in a 2014 F150 fx4 with about 10k miles on it. I noticed when the truck is shifting into 3rd (normal acceleration)the rpms once in third remain around 1800 then drop to 1400ish after about 2 seconds or so while still in third (almost like its shifting again). What it is?
View 6 RepliesFord F-150 (2009-2014) :: 2009 - 4th Gear Intermittent Slip At 88K Miles
Started a while back and comes and goes. Only commonality I have found is the truck needs to be warmed up for it to happen and usually after a few hours of driving. The downshift from 5th or 6th into fourth, at times, produces anywhere from a light to violent clunk, feels like a typical tranny slip. It will do it while in cruise and it will do it if I don't have the cruise on. Can't figure out if it is going to be a tune issue or hardware.
It does it only downshifting into 4th from 5th or 6th, no other downshifting is a problem and usually the 6th to 4th produces the worst results. At highway speeds that is usually a shift from around 2Krpm to just over 3K rpm (6th to 4th) if it is from 5th it is about 2500 to 3K. Start from a stop and go WOT and there are no issues.
Having it in Tow/Haul or not makes no difference as far as I can tell. IT can do it on one hill and the next time be just fine or do it 2-3 hills in a row. After this last trip it will do it at 9K feet or at 60 feet elevation, didn't make a difference there either.
Another issue that may be hurting the computer is the truck originally came with the 235 tires, it now has 285's and the rear is only 3.31. I plan on going with 265's and maybe still a gear change to 3.73's in the future. I usually only notice this on long trips, first was a 1500mile hauling an ATV, second was last week during a 2500 mile empty. Although I have had it do it a few times locally. I figure those bigger tires can't be good especially with that high of a rear for the management system.
Ford F-150 (2009-2014) :: Noticeable Vibration At Low RPMs Both In Park And While Driving
I just purchased my brand new 2014 F150 4x4 STX 5.0L single cab short box about a month ago. I noticed when I drove it off the lot that it had a slight vibration at low RPMs. I boiled it down to brand new stuff working out all the kinks and running around for the first time, bought a brand new jeep in 2005 and it made interesting noises and had funny vibrations for a while, but this is starting to get annoying. I have a very noticeable vibration at low RPMs both in park and while driving, more noticeable at speeds between 35-45 with RPMs anywhere from idle to 1500 or so.
I have not had it at the dealer yet, I want to be armed with a little bit of knowledge when I go in an talk to them if possible. I know how stealerships work and since it seems similar problems are somewhat common in these newer F150s, I don't want to get the "oh it's common in these trucks and perfectly normal". In my opinion a brand new truck should run smoother than melted butter on hot flapjacks, especially one that only has 1400 miles on it.
Ford F-150 (2009-2014) :: 2011 F250 - RPMs Drops And Then Shut Off?
I have a 2011 F250 6.2L Was working great until the other day when I went to hit the gas and the RPMs dropped and the truck shut off. I tried to restart which it would do for maybe a second and then shut down again. I checked the fuel line going to the top of the engine with the key switch on and there was not very good fuel pressure. so I thought my fuel pump was bad. After switching the fuel pump, the truck still starts and immediately shuts off. I checked the fuel line again and this time it is giving an initial burst of fuel for a second and then nothing. What else it could be?
View 1 RepliesFord F-150 (2009-2014) :: Humming / Vibrating Noise When Shifting And When RPMs Are Above 2k
I recently noticed my brand new truck with 5k miles has been making a humming /vibrating noise when shifting and when RpMs are above 2k. What this could be? It's a 2014 F150 stx 3.7 ....
View 4 RepliesFord F-150 (2009-2014) :: 2011 - Hesitation From Idle - Missing Or Running Lean / Rich During Spin Up Of RPMs
I have recently purchased a 2011 F150 Ext cab with 3.5L ecoboost with 69k miles. I have no experience with these engines prior to now. I've always wanted a full size truck and after driving my 98 S10 for 17 years, I decided it was time for a new truck. I hope I made the right choice in going for the 3.5 instead of 5.0.
On to my question. I've noticed that the truck hesitates from a dead stop or anytime the RPM's are under 1k. It feels like its missing or running lean/rich during the spin up of RPM's. When I drive it hard, it does seem to subside for a little, and I've heard people say that they run better when run hard. I can attest to that, but is this hesitation normal for an almost 70k mile engine? I am getting 15ish MPG on almost all city driving since I have bought it, but I do expect that to change (job hunting and current commute is less than 2 miles each way).
The only time I get to open it up is when I go run errands out of the immediate local area or visiting friends and family. On one of those trips, before I noticed the hesitation, I attempted to accelerate from 60 to pass on the expressway and it bucked and resisted like a horse. It finally took off up to 80 and completed that journey with no issue but the check engine light came on for a bit. The check engine light went off when I shut it down and hasn't come back on since.
New ride: 2011 3.5L Ecoboost....
Ford F-150 (2009-2014) :: 2012 - Missing / Shuddering On The Highway Between 1200 - 1700 RPMs During Slow Acceleration
I have a 2012 4x4 EB CC. In 6th gear, on the highway between 1200-1700 RPM's, during a slow acceleration, it feels like it is missing or shuddering. It is most pronounced going up a hill, and/or towing something. As soon as you get above about 1700, it goes away. Rig needs to be fully warmed up (not just the engine, but tranny/drivetrain). Needless to say, this is generally from about 52-65 mph, which is most highway (not freeway) driving I do. At times it's so bad my wife says it's time to get a Chebby.
Had it in about a year ago, couldn't duplicate it. Took it in this last week. Did the TSB on the plugs, and was told that would fix it. It didn't. Took it back in; they couldn't duplicate the issue. Rotated the tires hoping that might do something. Took the head service guy for a ride, and made it happen; it was very obvious then. It seems like the tachometer should bounce or shudder a bit when it's doing it, but nothing. It's going back in on Monday to see what they can do.
Ford F-150 (2009-2014) :: Transmission Slipping A Little From Second To Third Gear
I have a new 2011 F150 4x4 6.2 liter with about 1200 miles, 6R80 6 speed Transmission. I haven't liked the shift quality since buying a little over a month ago. I think the upshift from first to second is kind of rough and it feels like it's slipping a little from second to third gear. I've read a lot of negative posts/reviews on the 6R80 transmission, and some people have said it got better over time, or it got better with more aggressive driving. I do notice it shifts better if I drive it a little harder. The build date according to the sticker is 4/11 and I don't think there are any TSB's for PCM updates for this year/engine/model. I'm wondering if I should bring the truck in now for the dealer to take a look or drive it for awhile longer to see if it gets better?
View 7 RepliesFord F-150 (2009-2014) :: Rough Shifting 2nd To 3rd Gear
For the last few months my truck shifts rough between 2e and 3e gear. However it only does this first thing in the morning, when I leave the house I speed up until the end of the street, then when I let go of the gas it'll rev up a bit and shift from 2e to 3e while making a big clunking noise which I can definitely feel ...
It does it sometimes very rough and sometimes just a little bit. I used to not worry about it but i'm starting to wonder if something is wrong with my trans. Could it have something to do with the slip yoke?
Truck: f150 2009 xlt 4x4 supercab 6,5' box.....
Ford F-150 (2009-2014) :: Shudder When Come To A Stop While In 1st Gear
Extended cab ecoboost 2x4. Shudders as I come to a stop while in 1st gear. Feels like it's something to do with the transmission. Haven't taken it in yet. Not towing/hauling.
View 3 RepliesFord F-150 (2009-2014) :: Hard Downshifting Between 2nd And 1st Gear
My 2009 downshifts hard between 2nd and 1rst gear. Real distinct when stopping at a stop sign. I have 81,000 on it. I looked at older forum's and they said flashing the computer would assist. Just curious if it works for a vehicle with that many miles on it, or if it may be a more serious problem.
View 5 RepliesFord F-150 (2009-2014) :: Shudder In 2nd Gear Low Speed
New start for an old problem. 2010, F-150, 5.4, 5.5' bed. Truck is new to me, used 105K miles. Love the truck, got it to tow TT I was having trouble towing with a shorter wheel base vehicle. Has HD towing package, tows great, good power, stable. First trip out with the TT the ole Shudder in 2nd gear low speed reared it's ugly head. I did do the slip joint re-lube with Ford wonder grease.
View 7 RepliesFord F-150 (2009-2014) :: 2010 - Hard Shift From 2nd Gear To 1st
I recently bought a 2010 f150 5.4 extended cab 4x4, i noticed when in traffic and the truck goes into 2nd gear just rolling slow when i come back to a stop it bangs going back into 1st?
View 6 RepliesFord F-150 (2009-2014) :: Way To Get Gear Indicator Lights To Stay On?
How to get the gear indicator lights to stay on? I can do it manually but it has to be every time I restart the motor. I think it completes the instrument cluster with it one.
View 9 RepliesFord F-150 (2009-2014) :: Automatic Transmission Gear Indicator
I have a 2011 F-150 with the center console shift lever. I mainly drive the truck during the day so it's possible I never notice this but do the gear indicators illuminate when the lights are on? I happened to look down when I put the truck in gear and noticed that the selector has a red light showing its position but it was really hard to see what gear you have selected.
Normally I just pull it down until I hit D, knowing it clicks 3 times, and I'm off. If you do happen to go into M then you see it on the dash. So I don't know if I've never noticed it or if I have a burned out bulb and its no longer lit up. It's not a big deal but I always like to replace burnt out dash lights just so it looks good but I don't know the answer to this one.
Ford F-150 (2009-2014) :: Ring Gear Diameter Size?
What size Ring Gear Diameter I have, 9.75" or 10.5"? Probably going to a 4:10 to get some power back after lifting my truck.
Current Axle Ratio: 3:55 LS
Bolt Count: 12
Ford F-150 (2009-2014) :: Gear Display On Right Of Screen Disappeared
The gear display on the right of my screen has disappeared. The display when in "M" works normally. and the transmission seems to work normally. I haven't done a thing to it except drive it. I'll be going in for an oil change in a few weeks but I'd like some input from the group about this.
View 3 Replies