Ford F-150 (2009-2014) :: HVAC Malfunctioning - Getting Popping Noise Under The Dashboard - A/C Not Working Properly
I have a 2011 f150 xl with the basic climate system. I'm having a couple issues with my hvac system. Initially when I took over payments on this truck I was getting a little popping noise under the dash that would go away after a couple pops. I took the bezel off to look at the radio and how it was mounted for a separate issue when I put everything back together I started the truck and now that popping is constant (it is the blend motor actuator, I've already determine that and have a new one coming) the other issue I got is that now the ac will only blow through defrost no matter what button I push. When I start up it will blow out the defrost like the flap is in default then it will blow out of the dash for a few seconds and then go back to blowing out of the defrost. I still have speed control tho I don't have 1 ,which I didn't have before that, and I haven't tried temp yet but I'm assuming it still works. Do the newer trucks still use vacuum to control the flaps or is it all electronic? I've noticed when I look at the actuators they all have a plug end instead of a vacuum port. And would the defrost vent issue be a dash control issue or would it be the actuator for that one a
s well?
Ford A/C :: 2009 Escape - HVAC Blower Motor Do Not Seem To Move Any Air On Speed 1 And 2
I bought my youngest daughter a used 2009 Ford Escape (out of warranty) a week ago. Manual HVAC controls, 3.0 V6, AWD, 73K miles. The HVAC blower motor do not seem to move any air on speed 1 and 2. However speeds 3 and 4 appear to operate normally. Speed 4 noticeably puts out more volume of air then 3. Each 3 and 4 operator what seems to be normal speeds for their setting.
I would normally suspect resistor but my experience is usually that you have all or nothing not it's partially working like this is. I don't mind throwing a new resistor in there and trying it but I rather come up with a better way of troubleshooting it then throw parts at it.
Ford F-150 (2009-2014) :: 2013 Ecoboost Won't Start Typically When Temps Get Low
2013 ecoboost bought new. Every winter 3-5 times, typically when temps get low( Kansas City), and truck left outside without starting for 12+ hours. I will get to my truck and it won't even unlock with key fob. Put cables to it and within seconds the alarm is beeping and I move directly to ignition and it fires right up. Had battery tested just this week and again nothing is wrong with it. Has not been to dealship, cuz I just kept telling myself I must of been leaving something inside the truck on and that's why it won't start. But I am beyond that now and with how fast everything starts once I get cables on it, I feel the battery is not getting drained. So it has done it speractically for 4 winters, maybe once during summer months and just everything is dead when i get to truck. No lights no entry no dash.
View 12 RepliesFord F-150 (2009-2014) :: No Response From A/C Fan Blower?
Started up today and no response from the A/C fan on any speed- dual climate control. Checked all fuses good. Electronic control panel shows normal with all the fan speeds, but no blower motor action.
Is it the motor or a resistor/controller? Thought with a bad resistor you would get the fan on at least in one speed.
Ford F-150 (2009-2014) :: No Response From AC Fan Blower
Started up today and no response from the A/C fan on any speed- dual climate control. Checked all fuses good. Electronic control panel shows normal with all the fan speeds, but no blower motor action. Is it the motor or a resistor/controller? Thought with a bad resistor you would get the fan on at least in one speed.
View 4 RepliesFord Excursion :: HVAC Blower Won't Turn Off
I'm new and have recently bought my first X. its a 2001 XLT with the 5.4. I really couldn't pass it up with the guy asking under 7K with 104,000 miles and not a rust bucket.
I discovered last night that my blower (at least front) continues to blow when key is out and off. I have played with the key to think its a switch but am not sure. Here's the other part, If I turn the selector to off before shutting the truck off it stays off BUT if i turn it on it will not go back off and stays on....
Ford F-150 (2009-2014) :: Blower Not Working - No AC / Heater
My blower on my 2010 Lariat truck isn't working and I can't seem to figure the issue. No heat or AC. It seems that some air is coming through, and the fan indicator shows it on high, but nothing.
View 8 RepliesFord F-150 (2009-2014) :: Noisy Fan Blower In AC Mode
My fan is NOISY!!! Its noisy in AC mode, defrost mode, heat mode, vent mode.... It really sounds like a leaf got sucked in. I don't wanna mess with the dealer since I don't think its a warranty thing. So, is it as simple as dropping the glove box and three screws for the blower as I have read?
2012 Eco.....
Elantra MD (2010-15) :: HVAC Blower Noise / Metal On Metal Rubbing
My Elantra's HVAC fan has always been a quiet thing, even on 3.....we won't mention level 4 and the fact it sounds like a 747 at takeoff.
I kid you not, the very evening I hit 60,000 miles and the general warranty expired, the blower motor started making noise like it was throwing a bearing and definitely sounded like some light metal-on-metal rubbing. After I became irritated at this, the noise went away and didn't come back until just a few weeks ago. I could make it stop by smacking on the bottom of the fan assembly a few times but I want a more permanent solution.
Tonight I dropped the blower out which was stupid easy except for the fact you're upside down in the dark with your head in a hole. But three screws and an electrical connector later, I dropped the assembly to find no serviceable components. I mentioned this to friend of mine who's into Volvos suggested spraying some lithium grease on the hub of the blower and letting it run long enough to quiet it down. I'll do this over the next few days and report back but part of me thinks a new blower may be in my future.
Ford A/C :: 1995 - HVAC Blower Wiring Schematic
My 1995 Ford motorhome blower does not work. The motor works fine. All threads say to follow the circuits to troubleshoot. That is nearly impossible with wiring harnesses. I need a Ford F- Series HVAC wiring schematic to find ALL of the electrical components, in order to test.
View 7 RepliesFord F-150 (2009-2014) :: Blower Motor Resistor Overheating
Have a 2009 platinum, 5.4, supercrew with dualzone heating and air. The blower motor resistor block is overheating and melting the connector block. fooled with it way too much, and then put a new resistor and pigtail in it. The new resistor would kick out in about 30 seconds, so used the old resistor on the new pigtail, got hot, melted the new pigtail. What is causing the resistor block to get so hot, and what do I do about it?
View 7 RepliesFord F-150 (2009-2014) :: A/C Blower Trips On High Speeds 6 And 7
2011 FX2, 81,000 miles, with dual control A/C. The blower motor works fine on speeds 1-5. Put it on speed 6 or 7 and the motor trips after about 5 seconds. Turn it back below 6 or 7 and it starts working fine. I have replaced the resistor and the blower with the same results.
I have read through a good deal of the posts and most seem to deal with the resistor and the lower speeds not working. It's like its tripping a breaker or overload.
Ford F-150 (2009-2014) :: Blower Motor Stuck On High
What is the testing procedures for the blower motor controller on my 2009 150 Lariat. In the old days it was called the resistor but now it is computer controlled for the dual climate control. My fan is stuck on high, the fan switch does work(the bars on the display change when I push the fan speed button). The climate control works also, just blasts you with air and the temp is changing a lot due to the fact of the fan on High. I am 99% sure it is the blower motor controller, but I would like to test the controller.
View 14 RepliesFord F-150 (2009-2014) :: 2010 - Blower Fan Will Not Run On Lowest Setting
My blower fan will not run on setting 1. on 2 3 and 4 it will work but not on the lowest setting. I replaced the relay and it still doesn't work. I have a 2010 f150 with the 2v 4.6 .....
View 6 RepliesFord - Explorer :: 2008 - HVAC Blower Inlet Blocked?
So I just picked up a 08 STL. I noticed that it doesn't get a lot of airflow out of the vents or floor. I initially thought that it was door actuators. I checked the vacuum at all of them and they all cycled as required.
I also checked the blend door, and the fresh air doors as well. They all cycled as desired. When I was checking my fresh air door with the borescope, I noticed a layer of... insulation maybe? on top of the inlet for the blower. So I removed the blower, and the picture below is looking up into the housing. Is that supposed to be there? It appears extremely dense, so I am led to believe that's what is causing my flow issues.
If it does not belong, how to remove it? Where is the fresh air inlet on this thing?
Full size : [URL] .....
Ford F-150 (2009-2014) :: 2010 XLT - Blower Control - When In Floor Air Keep Going To Windshield
In the last few weeks I have noticed that when I have the control set to floor only (manual system, not dual) I still have more air going to windshield than the floor. I can switch to Windshield/Floor, Center Vent and all seems ok. Just when in floor only it seems to keep going to Windshield. Asked the service rep at last oil change and he said it's normal for some air to always go to the windshield/defrost. I'm going back to dealer and check a new F150 XLT to verify I have a problem.
View 1 RepliesFord F-150 (2009-2014) :: 2012 - A/C Blower Stops If Turned Up Too Quickly
I did not want to high jack the threat about the blower motor stuck on high, but on rare occasions my blower will quit all together if it is turned up too quickly. I can still hear the compressor clicking on and off, but no air moving. after waiting a few minutes it will work fine if you adjust the blower control slowly.
My truck is a 2012 lariat supercrew with navi and dual climate controls. oh and i believe i have about 300 miles left on warranty, but it is not doing it on a regular basis, i doubt the local ford dealership will repair it.
Ford 6.7L Power Stroke Diesel :: HVAC Blower Stopped Working
Just got back from a 1200 mile camp trip pulling an 18K toy hauler. 500 miles into the trip the HVAC blower stopped working. Right after the torrential downpours we had last week. Did some limited checking and found the relay under the hood real hot. Swapped it out with the DEF relay and no luck. All the fuses were good.
This was in the Littleton, MA area. Dragged the truck and camper to a Ford dealer who had no interest - "make an appointment for sometime next week". Dragged the trailer to another Ford dealer who was equally not interested. From here we towed the 130 miles to our next stop.
You really miss your HVAC when you have to drive with all the windows open and two fur dropping Golden Retrievers in the back seat. The fur just circles around and ends up either in your eyes, nose or mouth.
Next day I was off in search of a repair. 20 or so miles north I find the next Ford dealer not intrested. Now I'm pissed and rant a little bit at the dealer.
I did almost 20 years in new car service, all highway dealers. Not once did we turn down a vacationing family on the road with vehicle troubles. We have even done engines and transmissions for travelers broken down.
60 miles to the next dealer in Laconia, NH, Irwin Motors, Ford, Lincoln and Toyota.
Same initial story “we are really busy and backed up”.
But, if I was willing to wait a little bit they would see what they could do.
45 minutes later I get the news that I need a blower motor and it is ordered.
No problem. I show up at 2, park the 5<sup>th</sup> wheel in the lot and at 3:30 we have a free wash coupon and we are on our way. And the service people couldn’t have been more pleasant to deal with. Even the techs came out to visit the dogs as we were walking around. 5 stars for Irwin Motors.
Ford F-150 (2009-2014) :: 2012 XLT - Control Panel / Audio / Blower And Key Fob Failure
So I have a 2012 xlt 5.0l single cab. Standard heat/ac with the non-navigation sync system. The blower and heat dosent work. The radio doesn't work on fm or Bluetooth. For the most part the screek doesn't say anything but if I hit the power button on the stereo the time pops up for a second. The key fob also doesn't work. When I click on the font the center console will light up but nothing will happen. The key doesn't work in the door but I'm not sure if it ever did. Intermittently it all comes back on and works just fine but cuts out again. A few times hitting the dash has made it all come back on. When it all isn't working and I press the eject button on the stereo the deck tries to spit something out and it says eject on the screen so I know the screen and the cd part of the stereo are getting power all the time. The Bluetooth doesn't work and the USB port doesn't work or charge my phone. The lights on the center console are all working but it doesn't dim when I dim the dash. I am baffled on what it could be and the harness is impossible to follow.
View 2 Replies