Ford Super Duty (1999-2016) :: 2009 F250 - Rear Diff Fluid Change / Pinion Seal Leaking
I just picked up an 09 F250 a couple of weeks ago and I was planning on replacing all the fluids since I'm not sure when everything had been done in the past, but it did pull a camper 5th wheel. It has about 93000 Km/57000mi on it
One thing I noticed when reading the manual is that a rear diff fluid change is not necessary on these rear axles unless they have been submerged in water or repaired etc..
Just after I got it I noticed the pinion seal was leaking. It was fixed under warranty but the dealer did not replace the diff fluid as they said Ford will not pay for it.
My question is do you think I need to replace the diff fluid or should it still be good, given the relatively low mileage.
Ford 7.3L Power Stroke (1999-2003) :: F250 - Changing Rear Diff Fluid?
I am changing the rear Diff fluid in my 1999 F250 Super Duty with limited slip differential. I have read in the manual that 8 ounces of friction modifier is required, ford dealer said it only required 4 ounces. I bought 8.
Also I asked for a inspections plate gasket and ford said use silicone... When I removed inspection plate it had a gasket. So, silicone or gasket or both? Differential capacity is 6.9 pints 75w/140w synthetic.
Ford F-150 (2009-2014) :: 2011 - Rear Seat Back Removal?
Trying to install some nice seat covers in my '11 supercab and can't seem to figure out how to remove the rear seat back. What is the combination?
View 2 RepliesFord Transmission :: Front Diff Capacity - Fluid Level Up To Fill Hole?
I have a 2002 F250 SD 4x4 w/5.4. I drained the front differential gear lube and refilled with 2 qts of gear lube as specified in my owners manual. Actually the manual says 1.8l / 3.8 pts. The fluid level is not up to the fill hole and if I stick my little finger in the hole I can barely get any on the tip of my finger. The owners manual says these capacities are for F250/350 w/ Dana 50 axle. It then says F350/450/550 capacity as 2.7l / 5.8 pts with a Dana 60 axle. My question is should the fluid level be up to the fill hole, as with the transfer case and rear end levels? Could I have a Dana 60 with the higher gear oil capacity in my F250? Whats the proper gear oil level?
View 4 RepliesFord Ranger / B-Series :: 2000 - Leaking Fluid Around The Front Diff Cover
My 2000 Ranger has been leaking fluid around the front Diff cover so I decided to pull the cover and reseal it. It was obvious that this was going to be a tight job but I didn't anticipate running into a bolt that can't be removed because interference from the front cross member.
View 3 RepliesFord F-150 (2009-2014) :: Instructions About Fluid Changes?
I have a 2009 F150 5.4 that is 4x4 and I would like to get some info on performing fluid changes. The truck is coming up on 30,000 miles and I do tow a lot. The transmission and front differential seem to be the hardest fluids to change.
View 3 RepliesFord F-150 (2004-2008) :: Rear Axle Seal Relationship To Rear Diff
I recently had my rear axle seals replaced due to leaking. Does the rear diff fluid get replaced on that repair since the rear diff cover comes off? Trying to figure out when my next interval for changing rear diff fluid should be.
View 1 RepliesFord F-150 (2009-2014) :: Black Fluid Leak From Transmission?
about a week ago I popped both of the passenger side tires By hitting a rather tall curb while trying to avoid being t-boned. And I have had the passenger side jacked up for about a week now while waiting for the shop to order and get in my new rims. It has been raining here for the past week so I only just noticed today that there was a puddle underneath of my truck.
It looks and feels like engine oil but it is leaking from the back of my transmission. I can't figure what it might be because transmission fluid is red and my transmission has never overheated So it should not be burned. It has 128k miles on it so it also only has 8k miles on the last fluid change. So it's fairly new fluid. What this could be?
I know some seal is obviously broken and the way everything is wet around just the back bottom of the transmission it looks like it is coming from the transmission. I originally thought it was just the transfer case got hit and it could be a bushing at either the transfer case or transmission but there is no scraping on anything under the truck so none of it was hit or damaged from that. What could be causing this?
Ford F-150 (2009-2014) :: 2010 - Brake Fluid Loss?
My 2010 screw 5.4 has only 20K on it and last week the low brake fluid light came on. Yes I know I need to do the pads and with the little miles the truck gets I was waiting on slightly milder weather to address this. I added fluid and went on my way. Last night the light comes on again, my guess there is a leak somewhere. BTW truck stops fine. First question; Any recalls on the brake system? I bought the extended warranty so since this probably isn't pad or rotor issue should the dealer fix the problem? I'm in a real bind here as my lady in is rough shape health wise and I need this truck ready to roll at all times.
View 6 RepliesFord F-150 (2009-2014) :: Prevent Washer Fluid From Freezing
When I find a good deal I stock up, case in point we had a menards open up recently and with all their sales to get ya in there the washer fluid was 2 for a buck. well shoot I have 5 gallons at the house and i just ran out in the f150. problem its all summer stuff like only good til 32 degrees f. Its supposed to get to neg 9 here tomorrow night. solution my local grocery has had a sale on isopropyl alcohol for quite a while (I have alot of 16oz bottles stocked up) so I'm gonna pour 8 oz of alcohol in a gallon and see how that does me.I usually do throw in some alcohol in the winter time just in case. We don't see temps that low very often in st louis, on top of snow we are supposed to get here. so there ya have it if ya find yourself with a tank full of summer washer fluid or just have a bunch around throw in some alcohol and wash away the winter nasty from your windshield.
View 14 RepliesFord F-150 (2009-2014) :: 2010 - Changing Transmission Fluid?
My new to me 2010 f150 4x4 superCrew Lariat is great. Got the 6spd tranny. Do a lot of maint. Myself and wanting to change tranny fluid since I hit 90k. Didn't see a dipstick. Called the stealership and they told me I can't do the change n/c I need certain equipment.
Are there any write ups? Are there any more surprises with this truck, like routine maint issues that I need to be aware of? I plan on doing diff fluid changes. Is this possible?
Ford F-150 (2009-2014) :: Checking Transmission Fluid Levels?
My truck just had it's check up at the dealership. On the slip it stated ATF fluid on rear housing. The tech said "No big deal maybe take a better look and maybe replace rear gasket later down the road". So first where is the check hole as I know there is no dip stick plus I think you use your finger to figure level. How far up should it be? I go over my truck about once a month looking for stuff and would like to include in my inspections.
View 4 RepliesFord F-150 (2009-2014) :: 2010 - Differential Fluid Grey In Color?
Had the diff checked today.fluid was grey in color,looked like it might have a little water in it. 2010 limited slip. wasn't over full. 10000 miles.
View 12 RepliesFord F-150 (2009-2014) :: 2011 - Fluid Leak - Yellow Antifreeze?
I have a 2011 SCREW Eco-Boost with a build date in April 2011. I have a gravel driveway. When I first got the truck I noticed small dark spots in the gravel but attributed it to the A/C. I parked over some fresh snow the other night and found some fluid stain on the ground in the morning. It was kind of by the motor and then a little further back. It was the color of yellow/chartruse antifreeze but the truck has pink antifreeze in the overflow tank. What is going on?
View 7 RepliesFord F-150 (2009-2014) :: 2011 - Front Differential Fluid Change
Changing the front diff fluid on truck. I was looking at mine today and it looks like the top bolts will be difficult to reach.
I also tried to suck the fluid out of the fill hole but couldn't really fit a tube into the differential.
Ford F-150 (2009-2014) :: Change Transmission Fluid At 110K Miles?
My truck just hit 110k on the clock, and i've never had the transmission fluid changed. Is this something that I am past due on changing or early? I don't know when it is supposed to be changed. If so is it something that you can do yourself?
View 14 RepliesFord F-150 (2009-2014) :: 2010 2WD - Power Steering Fluid Leak
My 2010 F-150 Lariat 5.4L 2WD Ext Cab with 76,000 miles is leaking power steering fluid. I traced it down to the cooling coil in between the radiator and the transmission cooler. It does not look easy or cheap to get out of there. Stop leak scares me a bit...
View 14 RepliesC/K :: Front Diff Pushing Fluid Out - Vent Tube
My front differential on my 97 Silverado Z71 sometimes vents some fluid out of the vent tube. I end up smelling it in the interior while driving. The vent tube top is above the top of the radiator and has the little cap on it. The first time it did it, was during a heavy rain. I had it in 4wd on the freeway doing around 60-70 mph. I figured it was because I was in 4wd. It did it yesterday after a 35 mile drive on the freeway again, but I was in 2wd the whole time. Outside air temp was over 100 degrees and I am using Royal Purple fluid. I checked the level a couple of weeks ago and it was below the fill plug about 1/2 inch.
View 5 RepliesFord F-150 (2009-2014) :: Trans Leaking Only When Sitting / Big Puddle Of Fluid Under The Truck
I have a 2009 F150 that when I came home from Cabo Monday, had a big puddle of fluid under the truck. I took it to Ford and they said it was some type of bolt on the tranny that is nationally backordered for who knows how long. They topped off my fluid and told me I would be good to go till the part comes in.
View 14 Replies