Ford Super Duty (1999-2016) :: Coolant Leak And Smoking From The Middle Of Engine Area
The wife and I were driving back to Sacramento yesterday. It was pretty hot around 95 when we left Stonyford, CA after a day of trail riding with our dirt bikes. From the staging area to the freeway, the distance was about 40 miles of slow twisty roads. We average around 30-45 miles per hour with full AC running. Once we got to the freeway and drove about 20 miles, we pulled to a McDonalds at which point I noticed a weird smell and smoke coming from under the hood. We opened the hood and notices smoke coming from the middle of the engine. I also noticed coolant leaking from under the engine. I waited an hour and then pour about 3 gallons of concentrate coolant back into the system. It seems to stopped leaking. We drove another 45 miles to home. Coolant hasn't leaked. I can't take this truck out until I figure this out and fix it.
View 8 RepliesFord F-150 (2009-2014) :: 2011 FX4 - Rattling Kind Of Noise Coming From Middle Dash Area
I have a 2011 F150 FX4 with the traction control. When the tires spin (like taking off on a hill in the rain - that's when i noticed it) and I let off to let everything settle down, I hear a rattling kind of noise coming from the middle dash area, maybe on the engine compartment side of the firewall. It sounds like a rubber ball in a box being jostled around. What this might be?
View 3 RepliesFord 7.3L Power Stroke (1999-2003) :: A/C Leak Coming From Metal Tube Going Into Spongy Area
So after a hot drive yesterday we thought to do some googling about our clutch cycling on and off so fast. Yep, the airgap was out of spec. Fixed that.
Then we added some refrigerant to the truck. The truck is "new to us" and this is our first summer with it so not sure what might've gone on previously with the AC. Didn't take long to find a rather sizable leak. :P
See that metal tube going into the "spongy" area? Yeah, that's where it seems to be coming out. That tube is the only one that's cold, the rest are ambient temp. We fix a lot on our jeeps, but the AC system is naturally a bit out of our wheel house since it's not something you normally tangle with. Is this an easy fix? Or do we need to take it in to get serviced?
Ford F-150 (2009-2014) :: Coolant Leak At Y Hose For The Intake Manifold And Thermostat
If you have a coolant leak at the y hose for the intake manifold and the thermostat, make sure you replace the upper radiator hose as well as the y hose.
View 3 RepliesSanta FE SM (2001-06) :: Coolant Drip From Small Plastic Tube On Firewall Inside Engine Bay Area
I'm trying to figure out a small leak on my mothers' Santa Fe. Recently I smelled coolant after my mother had gone for a long drive. I checked the Radiator and overflow... need maybe 1 qt of coolant.
Now I'm trying to find the cause of the missing coolant ! While it's running, I see no leak. Shut it off and it starts to drip from a small plastic tube on the firewall inside the engine bay area (on the passenger side). It drips down onto a rubber boot covering some steering stuff. Is this from the heater core?
Camry :: 2009 XLE - Lower Engine Cover Hanging Loose In The Middle
After an oil change I noticed my lower engine cover hanging loose in the middle. Much searching has not found the part number. Underbody engine shield fasteners. Any quick reference for these? 2009 Camry 4 cyl XLE.
View 11 RepliesFord Super Duty (1999-2016) :: V10 - Coolant Leak Where Heater Core Tube Goes Into Intake At Rear Of Engine
I have a leak where my heater core tube goes into the intake at the rear pass side of engine. I have read that this part is pressed in. I dont want to remove the intake since i just paid $400 to have a new gasket kit put on. My question is can I bypass this tube with a hose from the water pump like in this video?
FORD 4.6 , 5.4 , 6.8, HEATER HOSE UNDER INTAKE REPLACEMENT THE EASY WAY !!! - YouTube....
If I can do a rubber hose like in the video I was to make sure that the tube just goes through the intake and that it does not supple coolant into the intake??
Mazda - 626 :: 2002 - Coolant Leak In Middle Part Of Engine?
I have a 2002 Mazda 626 with 134,00 miles. About a month ago there was a large coolant leak in the middle part of the engine. My mechanic replaced the coolant by-pass hose from the thermostat housing under exhaust manifold to engine block. A few days ago there was another leak around where the coolant reservoir is. Gauge read hot and had to top off coolant on way to repair shop. Topped off reservoir and next morning most of the coolant had drained out. My mechanic has done a pressure check, drove the car, let it sit and idle for up to an hour and there was no leak or overheating.
View 1 RepliesFord F-150 (2009-2014) :: Transmission Dipstick Tube Leaking
I was changing my oil the other week and when i went to pull the filter I noticed that my tranny pan was wet around the front side, as well as the flywheel insp. plate, and the tranny dipstick tube. It wasn't even enough to drip on my driveway, but wet none the less. after cleaning it up really well and driving it around for 15 minutes it seemed to be coming from the dipstick tube about halfway between where it seats in the tranny and top end of the dipstick.
Removing the tube was easy, just one 10 mm bolt on the back of the engine. After further insp, there was a small piece of insulation on the tube where it passes between the engine and exhaust manifold. when i removed that insulation i noticed there was rust on both the top and bottom of where the insulation sits. i looked it over really well and didnt' see any cracks or holes. I then pluged one end and blew into the other and didnt' notice a loss of pressure or any hissing noise.
I figured if it wasn't leaking and it was already out i might as well clean off the rust and hit it with some paint. I ran a wire brush over the lowest spot of rust and what do you know, 3 tiny little pin holes. I used some 2 part apoxy from work and some aluminum duct tape to repair the hole temporarily until i got the new part in the mail yesterday. total install took around 10 minutes.
Ford F-150 (2009-2014) :: Small Hole In Intercooler Tube
So my wife nailed a small spike buck and he when up under the truck. On his way back, his antlers hit the intercooler. One side tube was collapsed and the other collapsed but tore open. Has to repair one the tubes and, if so, with what. I was thinking I could pull the dent out with a pick and then put some sort of epoxy over it.
View 14 RepliesFord F-150 (2009-2014) :: 2013 FX4 Not Draining Water - A/C Drain Tube?
I just noticed my 13 FX4 isn't draining water, but I checked inside and the carpets feel dry. Maybe I'm just being paranoid but the wifes Jeep always has a huge puddle under it. I'm sure the drain is somewhere under all that silver sound deadener. Is this common?
View 3 RepliesDodge - Ram :: 1997 - Major Coolant Leak Coming Right From The Middle Of Front Of Engine
I've got a 1997 Dogde Ram 1500 Pickup. It's got a major coolant leak that seems to be coming right from the middle of the front of the engine. I can't see where it's coming from. I changed the thermostat and the water pump, but it seems to be even behind that. There is a rubber hose that comes off the water pump and disappears between the two banks. I can only see a tiny end of it, where it goes. It looks like getting to that would involve taking off the whole intake manifold. If that's the case, I might as well total the truck. I dunno...
View 12 RepliesFord 6.7L Power Stroke Diesel :: 2012 - Coolant Leak From Lower Radiator Hose
Just had to replace radiator at 38k on my 2012 SD. Now I have another leak at 41k. Looks like it's wherever the lower radiator hose leads. Kind of a weird junction. I don't think it's coming from above there, but not sure. It's the primary dgas bottle that was low. The radiator was covered under my ESP. We'll have to see what's up with this one. Been eying a denim blue SD at dealer, thinking this is going to talk me out of it though. Not especially happy right now.
View 3 RepliesFord - Explorer :: 2000 - Coolant Leak From The Spark Plug Area
I used to have a 1999 Mercury Mountaineer 5.0. Loved the truck but sold it because I didn't have a place to store it.
So I bought a 2000 E.B. Explorer! I love it thus far, I was doing a tune-up and now I hate it. I was changing the spark plugs and one of the spark plugs had a lot of rust around it. As I was chipping the rust away so I could get a socket around it coolant started to come out right below the spark plug
I have attached pictures too.
I don't know what this could be. I have done my research, anything from the lower intake manifold gasket to a cracked head. Need info about this type of leak? its no where near any gaskets, I have a friend that says I could have hit a coolant chamber but I wasn't banging hard at all.
Ford Super Duty (1999-2016) :: 2008 F250 - Coolant Leak Above Lower Radiator Hose
I'm trying to troubleshoot a leak on my 08' F250 with a 6.4 powerstroke. It's been dripping coolant when cold pretty aggressively. Once the truck heats up, the coolant leak seems to mostly go away.
Here's a picture of the drip, it's marked by a dart, so you can see the location from the top (second pic). The radiator house connection around the engine seems dry.
Pic from Top ....
What's hidden here that could be causing the leak?
Ford F-150 (2009-2014) :: Why Is 6.5' Bed Lower Than The 5.5'
Looking at the specs, the screw 5.5' truck's cab height is 76.7" (4x4). For the 6.5' bed, that cab height is 75.6".
This seems to be true for most of the configurations: the shorter, the taller.
Golf IV R32 :: Coolant Leak On The Lower Portion Of Down Pipe And Running Across The Bottom
Come out to the this am and notice a small puddle that was not there last night. Pull the car out and it's start burning something off. Roll the car in first thought is oil (maybe the turbo return line is leaking) no its coolant. On the lower portion of the down pipe and running across the bottom. I'm at a loss as where the leak could be coming from being back there.
View 6 RepliesFord F-150 (2009-2014) :: Bucking At Lower RPMs
This is not on our F150, but rather our Flex that has the 3.5 Ecoboost.
Recently we have been having a bucking problem at lower rpms. Usually when taking off and hitting a slight grade. Doesn't really have a problem at highway speeds. Usually only on takeoff when it shifts through the gears. If you accelerate more, you can stop it for the moment. Weather doesn't make a difference. Also can feel a slighting surging sometimes and can see it on the tack. Like a 2 sec alternating surge. Doesn't do this all the time though. I have replaced plugs with iridium, gapped at 34.
I also purchased two motorcraft coil packs and installed them in different configurations as to see if I could isolate it. No change. I HAVE NO CEL YET. At all. Wish it would! I have tried to make it buck hard enough to throw the code to no avail. I have heard of condensation in the intercooler, but from what I have read it is a higher RPM symptom..This feels just like the COP problem on my 5.4. Unless I have 3 or 4 bad COPS and no CEL. If I could just get a code.
Phaeton :: V8 - Coolant Leak Coming From Area Under Oil Filter Housing
I have a coolant leak coming from the area under the oil filter housing where the cooler is. My thought is the little plastic pipe between the cooler and the engine block. I have the alternator removed but am wondering what's next. Can I get to the cooler without dropping the engine?
View 24 Replies