Ford F-150 (2004-2008) :: F250 V8 - Starter Would Not Engage When Turned The Key
2008 Ford F-250 with a 5.4 Liter V-8 3-valve engine and automatic transmission.
Running down the road at 44-MPH. Pulling 5,000lbs. Engine died just after turning on the air conditioner. (Not sure this is relevant.)
Would not start. Turned the key - the starter would engage, but the engine would only turn maybe a quarter turn. Try it again engine turns. Try it again and now it only clicks. So, I
-Replaced the battery. Same symptom. Will only turn the engine 1/4 turn.
-Replaced the starter. Same symptom.
-Checked oil. Clean. No Water. No gas smell. (200 miles since last oil change)
-Checked coolant. Clean. No Oil.
-Charged the new battery and tried again. Same symptom.
-Checked and cleaned all grounds and battery cables. Same symptom.
-Checked that the transmission is shifting though the gears. Seems fine.
-Removed serpentine belt. Check all pulleys, and accessories that are driven by the belt. Everything spins quietly and freely.
-I put the truck in neutral and tried to spin the crank pulley with a 2 breaker bar. It wouldn't budge.
Am I missing something? I fear the engine is seized or hydro-locked. If hydro-locked, wouldn't I see signs in the fluids? Can the pistons be hydrolocked with fuel? Not sure what to try next.
Oldsmobile - Alero :: 2000 - Stalling And Security Light Beginning To Flash On Dashboard
I've been having a problem with my 2000 Alero recently where, periodically, attempting to start the car will end in the car stalling and the security light beginning to flash on the dashboard. Usually after about 10 minutes the light goes off and the car starts normally (well, insofar as feeling like it's going to shake itself apart the moment it hits idle is normal, but that's another topic for another post). This happens about 40% of the time when starting the car, and seems to be happening more and more frequently (which may be my imagination).
I took the car into the dealer (after my local mechanic told me he was familiar with the problem and wouldn't be able to fix it), and they told me I needed to replace the body control module and passlock sensor... Car info : 2000 Oldsmobile Alero~140,000 miles2.4L I-4.....
Cavalier :: 2004 Pontiac Sunfire Airbag Light Flash Six Times When Car Turned On
My airbag light flashes six times when I turn my car on. Then it remains on while I'm driving. I have no clue what this means.
View 4 RepliesFord F-150 (2004-2008) :: Light On The Dash Comes On - 4WD Is Not Engaging
I have a 2004 F-150 Non Heritage. The 4WD was working fine last year and is not working now. The light on the dash comes on and I do seen to be getting vacuum at the hub but it is not engaging. Several months prior to using the 4WD I did do some front end work and must have knocked the vac line off. It was off for several months, I reinstalled it and it is still not working.
View 2 RepliesFord F-150 (2004-2008) :: 4x4 Won't Engaging But Light On The Dash Comes On
I have 08 F150 that the 4x4 is not working on.The light on the dash comes on and I can hear the transfer case engaging.I checked to make sure that I have vacuum to the switch under the hood and that the vacuum line going down to the front diff is holding vacuum.I'm just not sure how it engages the diff.
View 7 RepliesFord F-150 (2004-2008) :: 4wd Not Engaging Properly Only Light Works
I have an 06 f150 xlt 4wd 5.4. I bought the truck about two months ago and have come to realize that my 4wd is not working. The light works and you can hear the clunk but recently we got alot of rain and i was going down a georgia clay dirt road and almost got stuck in the middle of the road. i tried 4hi and 4lo but only the rear wheels would spin. I had my wife put it in 4wd while i looked under the truck and the half shafts do turn in 4wd. which doesn't make any sense to me. I also unplugged to vacuum line from the intake and capped it off to try and let the hubs engage that way but still nothing. why would the half shafts be turning but no power to the front wheels in 4wd? does that mean the iwe's are stuck engaged? Which would explain why they turn all the time. But if they are engaged, whether they are stuck or vacuum leak or whatever the reason, shouldn't the front wheels be getting power.
View 8 RepliesFord F-150 (2004-2008) :: MIL Light Started To Flash / OBDII Codes / Misfire
My wife was driving her truck yesterday and said the MIL light started to flash and the truck felt like "it was about to blow up" . So when I got home I busted out the trusty old scanner and this is what I got:
P0305- Cyl 5 misfire'
P0354- Ignition coil D primary/ Secondary circuit malfunction
P0304- Cylinder 4 misfire
The truck is a 2005 5.4 with ~130,000 on it and it runs very well for the most part. I have done the spark plugs before the summer and replaced them with the motorcrasft sp-515s. I am guessing the problem will be with the #4&5 coil packs. is there a way to troubleshoot these?
Golf/GTI VI :: EPC Light Came On When Slowly Engaging The Clutch While Accelerating
The other night I threw an EPC light. I've tried reading older posts but haven't found anything.
I was at the top of a hill, slowly engaging the clutch while accelerating. I wasn't trying to floor it or anything. My car immediately went into limp mode and the EPC light came on. I pulled over, restarted the car, and it went away. It happened again the next day in the same place.
I am only having the problem on a steep hill while engaging the clutch. Other than this situation, the car seems to be running fine. The car is completely bone stock. I don't have a VAGCOM and can't really afford to purchase one at the moment.
Ford F-150 (2004-2008) :: Security Alarm Go Off For No Reason
I have a 2007 F-150 FX2 and as of 8-10 months ago I started having the security alarm go off for no reason. I thought maybe I sat on the fob or something stupid but it is getting to be more often. The truck sat at the dealership for 2 days last week and nothing. They decided after lightly bumping the grille and it went off the sensitivity was too low so adjusted that up to a reasonable bump required. Well it went off last night at 1:30 AM, so I don't know what to do now. The service writer did say he had seen this and it was always a door sensor but having 4 doors which one??
View 1 RepliesFord F-150 (2004-2008) :: 1998 4x4 -Tail Light Stays On When Truck Turned Off?
My sons 98 F150 4x4. First off he had a head light go out and replaced the bulb. Then a day or so later his tail lights would not go out after he turned the truck off. I had him to replace the pressure switch(I think that's what it is called ) anyways, that didn't work. So now he takes out the fuse every time he turns off the truck, just so the lights will go out. But, when he puts the brake fuse back in, the brakes work fine, but his windows will not roll down. I am totally confused with what is going on.
View 1 RepliesFord F-150 (2004-2008) :: 2007 - 4wd Won't Engaging?
i have a 2007 ford truck and the 4wd will not engage the lights come on the dash showing 4 low and 4 high and it clunks when you turn the dial to either 4 low or 4 high but does not engage.
View 1 RepliesFord Super Duty (1999-2016) :: 2008 F250 - Gauges Stopped Working / No Crank / Security Light Flashing
My father-in-law has a 2008 f-250 with the 5.4. as he was driving a while back all the gauges of the dash quit. The engine still kept running without any noticeable difference but when he shut the engine off and tried to restart, it wouldn't even crank but the security light was flashing. He tried starting it again a few hours later and it started just like normal and ran fine.
He has had this problem occur several times in the last few months, but the other day it repeated the problem again and would not restart for about 5 days. He has tried charging the batteries, changing relays, checking all fuses and finding none blown, scanned it with his code reader, and checked the steering column for bare or rubbed wires.
Ford F-150 (2004-2008) :: Four Wheel Drive Not Engaging
I have read through the folders and many websites on 4x4 problems. My problem has to deal with my four wheel drive not wanting to engage. It has nothing to do with the front end or solenoids. When I put it into 4x4, hi or low it will not send any power to my transfer case motor. It wont even illuminate any lights on the selector switch. I have checked all fuses and replaced any relays that have to do with the 4x4. Where I should go with this?
View 7 RepliesFord F-150 (2004-2008) :: 4x4 Engaging And Disengaging On 4 Wheel Hi
My '05 F150 (92,000 mi) 4 wheel seems like it is engaging and disengaging when activated. Makes a clunking sound on light acceleration then quits when I back off the gas. Not sure if it is engaged then or not. I noticed this on a gravel road when I had turned 4x4 on to distribute oil around the system since I had not used it in a while. What it might be and if it is any easy fix or a trip to the shop.
View 3 RepliesFord F-150 (2004-2008) :: Flash-to-pass Lights Brighter Than Hi-beam
I notice that when I pull the turnsignal switch, the "flash-to-pass" lights are considerably brighter than when I lock the switch forward for regular hi-beam. Questions:
1) does it hurt anything if you drive for a few minutes manually holding the switch towards you?
2) is there an easy wiring mod. to make the locked-on hi beams extra bright like the passing lights?
Why buy bulb upgrades if the stock ones are capable of xtra brightness? (I drive through a remote area daily in the dark that is rich with deer, and I am usually the only vehicle.)
Ford F-150 (2004-2008) :: 2006 - Front Differential Won't Engaging?
2006 F150, SuperCrew with 5.4
I just replaced the firewall actuator valve for the hubs, and went to try out the 4 wheel drive. The hubs engage and lock to the axle shaft, the transfer case engages and locks to the front driveline, but the front differential isn't doing anything. Is there an actuator for the front or did something break inside?
Ford F-150 (2004-2008) :: A/C Not Blowing Cold Air / Clutch Not Engaging
Here is my problem: A/C not blowing cold air, blower motor working fine, checked all relevant fuses for A/C and R202 relay under the hood. Everything is fine here. Next, low pressure switch, jumped, clutch does not engage. Next removed relay R202 (clutch relay) measured voltages (at female sockets) where pins 1 and 3 would go, voltage OK. Jumped where pins 3 and 5 would go (bypass to see if clutch engages) and it does. Appears that the pressure switches check out OK (low pressure and A/C cycling switch - although this one not sure). CarMD unit was used as well, and no codes generated so perhaps PCM is working OK? I'm stumped, as a loss of GND by PCM or perhaps a corroded or open wire issue??
Also, possible the A/C switch on the HVAC control could be bad, but the light comes on, (doesn't mean switch is good necessarily). The rest of that unit works fine, control ***** that is, fan speed adjusts properly, air flow looks good. It appears this is an electrical problem where the clutch is not getting juice but I don't know the source of the problem. However, I also noticed that when the clutch/compressor was running (temporarily as described above) cold air still didn't come out. This, I assume, would mean I would need to add refrigerant or re-charge the A/C AFTER I get the clutch to engage electrically. 2004 F-150 5.4L ....
Ford F-150 (2004-2008) :: 2005 - Four Wheel Drive Not Engaging
I have a 2005 F-150 with ESOF. When I turn the switch to 4x4 or 4low the lights on the dash will turn on but the front tires will not turn. I checked all the fuses and they were good. I'm not very familiar with this 4x4 system, what the issue is or on how to fix it?
View 3 RepliesGolf IV R32 :: Clutch Gargling When Slowly Engaging?
Lately I've noticed that when slowly engaging first or reverse, the clutch has noticeable but not loud chatter, kind of like its gargling a little. I JUST changed the trans fluid from OEM to Amsoil 75W-90 API GL4 and its about the same time the noise came, but I'm not going to assume right now that this is the source of the noise. Clutch acts just the same, apart from this gargle.
Might be worth mentioning that this all seems to have started about the same time the temps around here started to dip below 30 on a regular basis