Ford F-150 (2004-2008) :: Truck Recently Started Sounding Like Trying To Shift Into 4X4 Mode While Driving - Gears Grinding
At a loss right now. My 2004 F150 4X4 and just recently started sounding like the truck is trying to shift into 4X4 mode while driving it. It stops if it's switched into 4X4. I have taken it to a local mechanic shop I use and they said it was the Actuators and they replaced those. I got it back and the same day the noise came back. Took it back and they have had it for another week and still unable to figure it out. I even took it to another shop that was highly recommended and they say to take it to a Ford dealership. I have read that some say it could be the vacuum operated hubs? Need to figure out what it was and had it fixed?
View 1 RepliesFord F-150 (2004-2008) :: Acceleration Seems Sluggish When Getting On The Interstate
2007 F150 King Ranche 4wd 5.4 192000 miles.
I started noticing a little stutter when trying to hold 45 mph if I hit a mild incline, and also at 70 or so if i hit an incline.
Around the same time, I noticed that acceleration seemed sluggish when getting on the interstate. Gas mileage dropped from 16-17 mpg combined to 12-13 mpg combined.
Historically, since I bought the truck 3 years ago, if I go WOT to get up to highway speed (Not my normal mode of driving, more of a test) I would get a misfire on cylinder 8.
About 2 weeks ago, driving around town, I got a check engine light. The code said it was rich on bank 2. Cleared the code, it has not come back.
Here is what I have done:
Flushed the tranny (Vehicle history shows this has been done consistently since original purchase)
Changed all 8 plugs (none broke!) and all 8 COPs. - Fixed the misfire on cylinder 8.
Still sluggish and still have the stutter at 45 and 70 on an incline. I know it's not a racecar, but 0-60 in 19.6 seconds seems quite unreasonable.
New Fuel Filter
New Air filter
Cleaned MAF sensor
Had the back pressure on exhaust checked. No blockage there.
My torque app tells me the TPS is functioning normally.
No codes are being thrown, no CEL at this time.
What am I missing? I have a reader that will chart up to 8 sensors as I drive.
Ford F-150 (2004-2008) :: Transmission Slips When Entering Interstate At Around 50 - 55 Mph
I have a 2004 XLT supercrew 4x4 with about 150,000 miles with the 5.4 motor. I noticed that when entering an interstate at around 50-55 mph it feels like the tranny slips. There is a jerk, jerk, jerk than it stops, it doesn't do it at any other speeds and only getting on interstates. Runs fine in town. No lights on the dash or codes, fluid level is normal and clean. I did have a caliper sticking but it was replaced and it's still doing the jerk, jerk, jerk. Could it be U joints?
View 6 RepliesFord F-150 (2004-2008) :: Slightly Rough Ride Around 70 - 80 Mph Sometimes On Interstate
I noticed a slightly rough ride around 70-80 mph sometimes on interstate a month back but thought it was my scalloped tires that need replacing and ignored it. Last weekend i had to go to MI from GA pulling a small enclosed tandem axle trailer (6x12). I started after work and made it to VA before stopping for the night with no problems not even at 70-80. Fueled up first thing in the morning (BP Fuel) and headed farther into the mountains when the truck started shaking when it should be downshifting (into overdrive I am guessing?)
No check engine light come on so i pulled off the road checked rear end and motor oil everything was fine, topped off tranny which was slightly low but was on dipstick .I let the truck cool for 20 min then got back going again. I continued driving with overdrive off, and not on the truck. Every time it had to downshift under hill climb it would start shaking but i would let out of the gas and it would stop. Once i got out of the mountains it was fine and couldnt tell it was running bad at low rpms, and also drove fine when i got off the interstate for fuel driving in towns.
I drove that whole day through ohio mich and back trough ohio when entering kentucky. It started to downshift and run at high rpms with no problem, and started acting up when i got back into the mountains.When the truck would go to downshift it started to shake uncontrollably again. then is when the check engine light come on and flashed. I babied in until tenn when i stopped at oriellys to hook up to scanner. scanner read misfire on 5 and ignition coil d primary secondary circuit malfunction. I checked the #5 plug (fine) and replaced the #4 coil, and didn't check the #4 plug.
t kept going and it never fixed the problem. stopped and jumped my coils around and check a few more plugs which all were fine but never that #4 (why idk), after being fed up, sat night, no mechanics around and wanting to get home i drove it the rest of the way. it never idled rough until i got almost home in Ga. When i got home the next day i pulled all plugs and all looked brand new still except the #4 which had the whole prong and tip completely burnt off. I replaced it and nothing changed, but my exhaust sounded restricted. Brought to a shop and it is now reading a misfire on 4 (with brand new plug) 5 7 and 8 and also saying it is running lean. They changed fuel filter and plugs but nothing still.
2004, f150, 4.6, 4x4, stx, short wheel base, 3:55
Ford F-150 (2004-2008) :: No A/C And ABS While Driving - Turn Signals Work But Do Not Display On Dash
I have an 05 Freestar with no instrumentation and no error codes. None of the gauges work and most of the warning lights are lit when the truck is running. No A/C and no ABS while driving and turn signals work, but do not display on the dash. It appears that two separate code readers are not acknowledging the computer. The battery and alternator check out good and there is no drain on the battery when ign switch is off.
View 5 RepliesGMC - Envoy :: 2004 - All Gears Work Intermittently?
Tranny loses all gears forward and reverse intermittently. I turn ignition off and on a couple times and everything is fine. It might be electrical because when I take key out of ignition and get out of car my power windows and radio are still working.
View 2 RepliesFord F-150 (2004-2008) :: 5.4L - Gears In Axle
I have a 2006 F-150 5.4L 4x4 Lariat. I was wondering where or how I could find out what gears are in my axles.
View 3 RepliesFord Excursion :: 2001 - Sloppy Steering When Driving On The Interstate
I am the original owner of a 2001 Ford Excursion with about 262K miles on it. I have thought about selling it more than once but I have finally come to realize that this is a very sturdy and reliable truck - so why sell it?
With that said, there are a few items that I need to address. The most important right now for me is to get the steering adjusted some how to eliminate the looseness. It is especially noticeable when driving on the interstate, I guess because I am traveling faster.
I am not a skilled mechanic but I do want to learn more about performing some of the simpler maintenance items since I have lost faith in the auto repair shops.
Ford F-150 (2004-2008) :: Factory Gears Whining At 45 MPH
It has been a long time since I have owned a Ford truck and recently got a good deal on a 2004 Reg. Cab 4x4 (4.6L). It only has 58K miles and still looks, drives and smells like new. I have just noticed that the Rear end gears whine very loudly at 45 mph. It is quite everywhere else accept a little hum at 60mph. No other issues with the truck and perhaps, this is just normal on these newer fords.
View 7 RepliesFord F-150 (2004-2008) :: Miles Per Gallon With 373 Gears?
I just bought a 08 Screw with the 5.4 3 valve, 4x4 with the 373 gears, and 25,000 miles on it. I love the truck, but what is the best that you have gotten for mileage on your trucks with the 373 gears? Does it do better at 75 mph or 55? I haven't checked mine yet so I am wondering what to expect...
View 8 RepliesFord F-150 - 1997-2003 :: 2002 Truck Shut Off On Interstate When Driving At 65 MPH
Truck in question is 2002 F150 4.6 with 150K miles. Crew was on interstate tonight driving 65 MPH and truck shut off. They called me out to trouble shoot. Engine had oil (was a quart low) and will not start. Starter engages but will not turn motor over. Had truck towed back to my shop. I removed belt just to see if it may be a locked up pulley i know, long shot)... it was not.
Employed called a shade tree mechanic he knows and trusts. He said was likely a broken timing chain and that is a common problem in 4.6. Said locked engine is probably because broken chain is wrapped around shaft. When I turn key fan does move about 1/4 inch.
1) Does this sound like a possibility or even a plausible explanation? Just trying to verify the information.
2) If this is the case, would a repair be advisable, or is engine likely shot and i should just replace it?
Ford - Explorer :: 2000 V6 Lost Power And Died When Driving Down The Interstate Doing 70 MPH
My daughter was driving down the interstate doing 70 mph when her explorer lost power and died. It will not re-start. Checked the DTCs and there were no codes. This same thing happened about a year ago and she had it towed to the dealership. After 3 weeks, they called and said to come pick it up. They said they had no idea what had been wrong but it was running. They replaced crank sensor, cam sensor, cleaned and checked several others an it still would not start. Then one day they sent one of the flunkies to move it back into the shop and he started it up and drove it in! They checked several more things but claimed they really didn't know what was wrong or why it started running. Now it has done it again. I suspect it may be a faulty ECM.
View 3 RepliesFord Super Duty (1999-2016) :: A/C Blow Cold Air When Driving Interstate?
I have an 06 F-250 Lariat with the crew cab. Even though the windows are tinted, the A/C struggles to keep the cab at 70 degrees on any given sunny day oer 80 degrees outside.
As long as you're driving on the interstate, it blows cold, but when slowing down (like a traffic jam or a stop sign) the air gets warmer and has a funny smell (like it's wet).
When I got the truck it had just gotten a new A/C compressor (160k miles). It stopped working last summer (180k miles) so I had the truck at the Ford dealer here and they replaced the A/C compressor, condenser, pressure regulator and dryer...basically all A/C components under the hood.
They tell me its working fine, but I find that hard to believe. No Ford I've ever had has had trouble keeping the cab ice cold even on the hottest days... How are your air conditioners working? Do they keep the cab cold? What I should look at?
Ford F-150 (2004-2008) :: Trans Bangs Between Two Gears If Slightly Accelerate
I picked up my 2005 F150 4x4 last winter. It has 135k miles & a slight tranny problem.
When cruising around 45 mph - right between where it wants to be in top gear or not - if I slightly accelerate the trans BANGS between the two gears.
I mean repeatedly bangs - it is not a smooth shift where it can't decide which gear to use - it is a hard BANG where it can't decide which gear to be in.
What gives? I can usually stop it if I turn on the towing button - shutting off high gear.
Ford Super Duty (1999-2016) :: 2008 - Losing Coolant - Overheating On Interstate?
I have a 2008 6.4 f-250. It has 139,00 Miles and I have a problem with the truck losing coolant and overheating on the interstate. When cruising 75-80 my truck will sometimes begin to puke coolant from the degas bottle and my cooling fan will begin to run. Engine coolant temp once spiked to 240 degrees before I could get off onto the shoulder. Around town the truck does fine although I do notice a loss of coolant but no overheating issues what so ever. I have the Dpf Deleted and Egr coolers are off. I run an H+S on a mild tune. Is there any other thing that could be wrong with this truck besides head gaskets? I am not looking forward flipping that bill. Trying the exhaust all other possibilities first.
View 3 RepliesPrius (Gen 2) :: Power Loss While Driving On Interstate
Prius Loses Power While Driving on Interstate.
View 19 RepliesGolf IV / Jetta IV :: EPC Light Came On While Driving Down The Interstate
SO like the title suggests i had my EPC light come on while driving down the interstate. I was on cruise and had been for about an hour. then the motor seemed to stall and then pick up right away but wasnt at full power. i had the gas pedal to the floor and was losing speed. the cruise had come off as soon as the motor faulted. the light stayed on constant and i did not get any other lights or sounds to accompany it.
I pulled off at the next exit and stopped in a parking lot. I turned off the car and then turned the key to see if my check engine light was still operating. it was so i listened to the car as i turned the key on completely. I didn't hear any odd sounds and the EPC light was no longer on. I pressed the gas pedal and the motor responded with full power. Not sure what would cause this 2 occur but I am concerned that it may happen again and i may get stuck somewhere.
Accent LC (2000-05) :: When Driving On Interstate Car Died Now Will Not Start
I have a 2004 Accent. When driving on the interstate yesterday, I turned the turn signal on and my car died for a moment. After I parked it, it would not start. It did not turn over. Took the battery out to get checked. It was good. Put back in and then the car started. Drove home. The radio and clock would flicker intermittently but made it home. Today it will not start at all. Nothing comes on.
View 14 RepliesLexus GX 2004-09 :: Vibration At 1500 RPM Happens In All Gears While Driving 08 GX470
I just bought my first Lexus, picked up a 2008 GX 470 with only 35k miles!
I just had the TSB for the "Clunk" issue fixed and I had a tire sensor that was leaking and had that fixed.
The ONLY other issue I am having is that there is a vibration at between 1250-2000 RPM and it's most prevalent at 1500 RPM, but it is gone above 2000 RPM. This happens while in park and hitting the accelerator to get to those RPM and it happens in all gears while driving, which is especially annoying because the SUV typically is sitting right at 1500 RPM while driving.
The Lexus dealer thought the driveshaft TSB would take care of the vibration, but it didn't.