Ford F-150 (2004-2008) :: How To Replace Front CV Axle
Tried searching, but I couldn't find any good write-ups on how to replace a front CV axle. The boot on mine is ripped and spraying grease so I figure I should just replace the whole axle while I'm in there. In a previous post, I also found out that replacing the CV axle (joint?) is easier than replacing just the boot.
View 1 RepliesFord F-150 (2004-2008) :: 2005 FX4 5.4L - B6 Axle Code
Unable to decode the B6 axle code on my f150,5.4 L,FX4 2005. Clearly located on the drives side door is the label 'axle' directly below that is B6 ! Unable to locate a listing for this code any where?
View 3 RepliesFord Excursion :: Front Axle Gears Removal
Well the old ball ball joints are out, new ones are in and now I'm working on removing gear assembly so I can change the inner axle seals. I've been trying to get it out. It haven't had much luck. I've loosened the cap bolts, prayed, pulled, hit, and still no luck. The only thing I've been successful at is screwing up the first few threads of the bolt holes for the passenger side cap. Tomorrow I'll be getting a tap and chasing the threads to clean them up. Hope I haven't screwed it up too bad. How to get the gear assembly out?
View 8 RepliesFord F-150 (2004-2008) :: 2005 - Rear Axle Whine Over 25 - 70 MPH?
had a leaking rear driveshaft seal at the axle and replaced it and fluid. 75W145 full synthetic as recommended. it was changed at 128000 and I've started to get an axle whine over 25 MPH up to 65-70MPH. quites down around 80 MPH. I just checked it after 2 months (whine just started) with 133000. Any TSB. does this fall under TSB 05-23-3? Noise sounds like I've got really aggressive tires on the truck. Only have Dayton HT all season. Did not add the XL3 additive. Would this work at this juncture.
View 5 RepliesFord F-150 (2004-2008) :: 2006 - Axle Code H9 Means?
I have a 2006 F-150 Lariat with a 3.55 Ratio axle. What does the Axle Code H9 mean?
View 2 RepliesFord F-150 (2004-2008) :: Rear Axle Vent Hose Missing?
I had a loud whine from the rear axle of my 04 SCREW and had the bearings replaced at the dealership. It has been about a year/12k miles since it was done and I just noticed that the vent hose is missing. I'm not sure if they left it off or if it fell off on its own. Anyway, my question is, do I need to replace the fluid once I put a new hose on? I'm not sure how much if any dirt or water might have gotten in there. Also, where does the hose go up to? I figure it must clip to the frame somewhere.
View 5 RepliesFord F-150 (2004-2008) :: Front Differential / Axle Vent Location?
Looking to change out my front differential cover tomorrow, cover is pitted, rusted, corroded, and leaking at the seals. While under there I want to inspect the vent for the axle and differential (and replace if it's clogged - which I believe is leading to the seal leaking). Looking for info about the vent tube location on the front axle? Thought I read somewhere it was on the cover itself, turns out that's a negative.
View 1 RepliesFord F-150 (2004-2008) :: Factory Gears Whining At 45 MPH
It has been a long time since I have owned a Ford truck and recently got a good deal on a 2004 Reg. Cab 4x4 (4.6L). It only has 58K miles and still looks, drives and smells like new. I have just noticed that the Rear end gears whine very loudly at 45 mph. It is quite everywhere else accept a little hum at 60mph. No other issues with the truck and perhaps, this is just normal on these newer fords.
View 7 RepliesFord F-150 (2004-2008) :: Miles Per Gallon With 373 Gears?
I just bought a 08 Screw with the 5.4 3 valve, 4x4 with the 373 gears, and 25,000 miles on it. I love the truck, but what is the best that you have gotten for mileage on your trucks with the 373 gears? Does it do better at 75 mph or 55? I haven't checked mine yet so I am wondering what to expect...
View 8 RepliesFord F-150 (2004-2008) :: Gear Oil Coming Out Of Rear Axle Vent Tube?
I own a 2004 F-150 FX4 5.7L V8, I notice this morning that I had gear oil coming out of my rear Axle Vent Tube. What would cause this issue? I'm kinda at a loss as to what would cause it.
View 3 RepliesFord F-150 (2004-2008) :: No Gears Work When Driving On Interstate At About 70 Mph
Today I was driving on the interstate at about 70 mph and my truck seemed like it popped out of gear...no loud noise or anything. I was able to coast off the off ramp and my truck was still running but sounded a little odd when I revved it. No gears work and when i revved it in gear it sounded like something loose in the bell housing area maybe. After I turned it off I was not able to restart it, sounded like the starter was just free spinning. Flywheel maybe?
View 6 RepliesFord F-150 (2004-2008) :: Grinding Sound Coming From Right Front Side Related To Axle
I have a 2004 F150, 5.4L V8. A few years back I was in an accident when someone slammed into the front of my truck. The right front wheel & tire took the brunt of the accident. I thought the repair shop had everything back to normal until recently I occasionally have a grinding sound coming from the right front side, seems to be related to the axle. It doesn't do it all the time just at random while I'm driving. The only solution I can find is to pull over or slow my speed to a crawl. Once I slow down enough or turn my wheel one way or the other its like something SLAMS back into place. I had it looked at by a local mechanic and they couldn't find anything wrong. Could it be something in my right front axle?
View 7 RepliesFord F-150 (2004-2008) :: Loud Whining Noise Coming From Rear Axle Housing
Some family members borrowed my truck, and when they returned I have a loud whining noise coming from the rear axle, which I have determined is a 9.75 rear. I checked oil level and it was high enough, but has a slight leak from the pinion seal. Everything feels solid but I have nothing to compare it to.
Its on a 2005 Super Cab with the 5.4L 183,000 miles. The front pinion seal was replaced in Feb 2 years ago, by the dealer's mechanic, who may have been a shade tree mechanic.
I am a Youtube Certified Mechanic, as in, I watched about 10 videos of people working on their 9.75 differentials, and realize I don't have all of the tools to do the job, such as a press, or race drivers, or the special gauge.
How many of you have tackled this issue? What did you find? What am I looking at for cost? I am on a very small budget.
Ford F-150 (2004-2008) :: Trans Bangs Between Two Gears If Slightly Accelerate
I picked up my 2005 F150 4x4 last winter. It has 135k miles & a slight tranny problem.
When cruising around 45 mph - right between where it wants to be in top gear or not - if I slightly accelerate the trans BANGS between the two gears.
I mean repeatedly bangs - it is not a smooth shift where it can't decide which gear to use - it is a hard BANG where it can't decide which gear to be in.
What gives? I can usually stop it if I turn on the towing button - shutting off high gear.
Ford F-150 (2004-2008) :: Truck Recently Started Sounding Like Trying To Shift Into 4X4 Mode While Driving - Gears Grinding
At a loss right now. My 2004 F150 4X4 and just recently started sounding like the truck is trying to shift into 4X4 mode while driving it. It stops if it's switched into 4X4. I have taken it to a local mechanic shop I use and they said it was the Actuators and they replaced those. I got it back and the same day the noise came back. Took it back and they have had it for another week and still unable to figure it out. I even took it to another shop that was highly recommended and they say to take it to a Ford dealership. I have read that some say it could be the vacuum operated hubs? Need to figure out what it was and had it fixed?
View 1 RepliesFord F-150 (2004-2008) :: Rear Axle Seal Relationship To Rear Diff
I recently had my rear axle seals replaced due to leaking. Does the rear diff fluid get replaced on that repair since the rear diff cover comes off? Trying to figure out when my next interval for changing rear diff fluid should be.
View 1 RepliesFord Super Duty (1999-2016) :: 2008 F350 - Sensor On Rear Axle?
What exactly does the sensor on the rear axle do? 08' f350. I know it's a speed sensor of some sort, but what does it do or control exactly.
View 3 RepliesFord Super Duty (1999-2016) :: 2008 F450 - Front Axle Removal
How do I get the front axles out of of the knuckle? It seems like the seals are holding them in? Is there any trick to to getting them out,I am trying to do my ball joints
View 1 RepliesFord Super Duty (1999-2016) :: 2008 F250 - Changing Rear Axle Ratio - Lower RPM?
My truck is a 2008 F250 6.4 Powerstroke 4x4 King Ranch, CrewCab, Shortbed.
I don't know which rear axle ratio it has - maybe someone can help me. the tires mounted are 275/60R17 and in fifth gear (TC locked) the engine has 2000rpm @ 70mph. I think it is a bit to much so I want to install a kit with and lower ratio. I pull trailers just sometimes and here in germany these only have 3,5tons max weight. So I think I don't need this power at 70mph. 1750rpm would be enough. How do I have to modify the front axle ratio if I get a lower-ratio-rear-axle?
I want to lower the fuel consumption. After some modifications, the truck needs round about 12-13L/100km (18-20mpg) and I think it is possible to lower this as bit.