Ford F-150 (2004-2008) :: Low Fuel Light Came On While Turning And Fuel Gauge Is Well Below Empty With Half Tank
I have a 2004 F150 XLT 5.4 L 79,000 miles. Yesterday i was driving home turned a corner and the low fuel light came on and the fuel gauge is well below empty. I had approx 1/2 tank of fuel when it happened. I have since filled tank all the way but the gauge will not move and low fuel light stays on. Everything else is working fine! I have never run the truck low enough on fuel to make the dummy light come on.....
View 5 RepliesFord F-150 (2004-2008) :: 2007 F150 Sputtering After Fill Up - Fuel Tank Pressure Sensor
The ole 5.4l hit a snag today. I was on my way to fill her up and she started sputtering and damn near died! i filled her up and it was like nothing ever happened. Took her to AutoZone and the diagnosis was a Fuel Tank Pressure Sensor.
I have a connection with Bumper-to-Bumper to get the part for cheap but I'm not sure if i want to dive into either moving the bed or dropping the tank. I'd prefer to move the bed.
Ford F-150 - 1997-2003 :: How To Patch Puncture Hole In Steel Gas Tank
Suppose a puncture hole were to inadvertently appear in the bottom of my gas tank? What would be some good ways to plug the hole? I'm thinking a fine thread stainless steel flat head screw that was screwed into a tapped hole with special glue/sealant and a washer would probably work.
You're probably catching on now... A non electric drill would probably be best to drill into the bottom of a full gas tank but all I have presently are battery powered and 100volt drills.
Metro :: 2000 - Hole In Gasoline Tank Fill Tube
2K Metro has a hole in the gasoline tank fill tube, between the gas cap and tank. It doesn't leak only when putting gas in. Is this hard to change or patch? I just found a replacement fuel filler neck. Is this hard to change. Can you change it with gas in the tank if you're careful?
View 4 RepliesFiat - Abarth :: 1972 - Gas Tank Has Larger Filler Hole
i have a 1972 fiat abarth and the gas tank has the larger filler hole for the old leaded gas fille nozzles Can i buy an adaptor for the gas tank filler hole to accomodate the new skinnier gas filler nozzles?
View 8 RepliesPrius (Gen 2) :: 2008 Fuel Gauge Broken - New Gas Tank?
As of recently, my 2008 Prius fuel gauge shows only 1 flashing bar unless the fuel level is more than half-full.
I just got a quote from the dealer; they said it will cost me $ 900 + to replace the whole fuel tank, as fuel gauge is not a replaceable part. Yap, the whole gas tank needs to be replaced for fuel sender!
Well, I find this hard to believe, but i guess it is possible that they have built everything together as one big replaceable unit.
BTW, if this is true then Toyota is not making environmentally friendly vehicles, when we have to throw away perfectly good gas tank and other parts within in order to replace a moving part that is most likely to fail.
Elantra HD (2006-10) :: 2007 - Hole In Bottom Of Windshield Washer Tank
We just purchased a used 2007 Elantra sedan. Noticed it was out of washer fluid when we got home. Went to fill it and as I was pouring in the washer fluid, I could hear it running onto garage floor.
When I looked underneath, I see there is a hole, 1 1/4" in diameter in the bottom of the tank. Obviously something was supposed to go in that hole. Low fluid sensor perhaps...even though I don't have a warning light indicator on my dash. The owners manual indicates that this light indicator on certain models where equipped.
Since my model is not equipped with this feature, is there a rubber plug or grommet that should plug up this hole?
Golf V R32 :: 2008 - Popping Noise Coming From Fuel Tank
I have a 08 r32, hearing a popping noise that sound like its coming from fuel tank. When sitting not running in garage, bout 15 to 20 seconds between pops. Maybe evap system? Just notice after filling up with gas.
View 4 RepliesFord 6.0L Power Stroke Diesel :: 2004 F250 Run Out Of Fuel With Gauge Showing 1/4 Tank
For the second time in 6 weeks My 2004 F250 Powerstroke has run out of fuel with the gauge showing a 1/4 tank. First time it was just under a 1/4 showing I had it towed to dealer and they told me it had sucked in the filters requiring replace and flush of system. The told me that this happening very often and I would be replacing all of the injectors at my cost. I told them that I didn't want this to happen again and to check out the fuel gauge and sending unit and replace if in doubt. Well they checked it out and found nothing wrong, told me it was accurate and should not be an issue again. Now 6 weeks later on the Friday night before a holiday, it did it again, this time with over a 1/4 tank showing. I really don't want to spend 6 grand replacing injectors and would really like to trust my truck again, getting to the point that I'm nervous at 1/2 tank.
View 9 RepliesFord F-150 (2004-2008) :: Gas Gauge Seems To Be Stuck On Half Tank
I have a 2004 F-150 and the gas gauge seems to be stuck on a half tank, sometimes it will go to full tank. How do I fix this.
View 3 RepliesFord F-150 (2004-2008) :: 1998 - Fuel Pump Can Be Heard Running But No Fuel Gets To Engine
5.4 L, Engine runs if primed at the intake. Fuel pump can be heard running but no fuel gets to the engine. Truck is mint and being sold real cheap due to this issue.
Fuel Pump? Filter? Both? I haven't seen the truck, a friend is considering buying it and rolling the dice it is a quick fix. Fuel is in the tank .....
Prius (2004-09) Fuel :: Less Miles Per Tank But MPG Same
In the last month, I've been getting less miles per fill up. Previously the gas light would hit 1 bar around 400 miles. Now its hitting 1 bar around 350-360 miles. But when I fill up, I only fill up about 8 gallons so I haven't lost any gas mileage. It feels as if the tank shrunk on me.
View 6 RepliesChevrolet - Suburban :: 2004 Not Able To Access Last 1/4 Tank Of Fuel
I have a 2004 suburban with approximately 125k miles on it, it is nominally my wife's car.
Recently it seems to not be able to access the last 1/4 tank of fuel. A couple of weeks ago my wife (who likes to run it down to the dregs) got it sub 1/4 tank, and it cranked but didn't start...put in 2 gallons from a can, started right up...took it to a gas station, filled it up (less the approximate 1/4 tank of fuel).
So, fuel pump? Pickup clogged? If so, what does it take to replace/repair...
Ford Super Duty (1999-2016) :: 2004 - Fuel Gauge Showing 1/4 Tank - Computer Flashing 5 Miles Empty?
I just bought a used 2004 F-350, 4x4, crew cab, short bed, 6.0L diesel. I'm having a WTF moment on fuel. Gage indicates just under 1/4 of a tank of diesel but the on-board computer is flashing like crazy stating 5 miles to empty, what the hell is that all about?
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Ran Out Of Fuel With 1/8 Tank And No Low Fuel Light?
So my 7.3 started sputtering and lost power, died on the side of the road. I wasn't far from home put about 8 gallon of diesel in the tank with a couple of fuel jugs and it fired right up.
Gauge was reading 1/8 of a tank and low fuel light did not come on. (low fuel light comes on when you start) Gauge came up to about 1/2 after putting fuel in.
What happened? Gauge was always reliable and low fuel light always did work. Only work done to fuel system was had new tank straps put on a couple of months ago.
Ford 6.0L Power Stroke Diesel :: How Much Fuel Left In The Tank When Low Fuel Light Comes On
I have a 2006 F250 c/c LB and I am curious, how much fuel is left in the tank when the low fuel light comes on?
View 8 RepliesFord Fuel System :: E350 - Fuel Tank / Pump Noise After Cutoff
This van has had a couple of fuel pumps, no surprise there, and i need to look through my paperwork and find out how many miles the current one has on it, but it has the STRANGEST habit I've ever had on any vehicle. Starts fine, runs fine, no fuel pump noise when van is running, and when you turn it off, the fuel pump creeks on and off for several minutes.
I mean a strange creaking noise almost like a shorted electrical device or a vehicle's brakes when you park it on a hill and the breaks creak as it settles into place. I'm probably doing a lousy job of describing this but i don't know how else to describe it!
ALSO, if you lay under the van and wait til it stops creaking, you can tap the bottom of the tank and it will creak for a few more seconds. You can tap repeatedly and make it creak more. Is it about to explode? Can i trust it on a road trip?
Ford Fuel System :: 1976 F150 - Fuel Draining All The Way Back To Tank
My vehicle:
1976 F150 2wd Extended cab
390 4bbl
c6 transmission
4BBL Edlebrock Carb
Dual fuel tanks, only rear main tank connected
My problem: For the first year I owned the truck, everything ran fine and it started up really quickly even after it sat for a few days or a few weeks. I have since, for about the last year or so, had to crank it for 30-45 seconds to get it to start. This all started around the time my fuel pump went out. I replaced it with an Airtex fuel pump from Autozone. I also installed a glass in line filter before the carb in front of the distributor.
I noticed that after about 4-6 hours, the fuel had drained out of the filter and that's when I would have to crank it forever to get it going. It also seems like there is no fuel in the carb as it doesn't even try to start when it first gets cranked. I thought this was a bad pump, so I bought a new one last week and tried it again. Sure enough after about 4-6 hours, everything is empty again and it takes forever to start it. So it's not a bad pump, or so I think.
The other day I backed it into my driveway and left it, something I never do. I checked about 4 days later and there was still fuel in the filter. This makes me think that gravity is making it drain back to the tank.
Is there something that would cause this? Also I have found a one way fuel check valve online that is supposed to remedy this type of problem. Do they work for this situation? Or is there something else I should be doing to fix this? It has taken a bit of a toll on my starting system having to crank so long all the time. I have so far had to replace my starter, starter solenoid, and all the battery cables, starter cable, terminals, etc. due to excessive wear.
The valve I found is here : [URL] .....
Ford Fuel System :: 1990 - Fuel Tank Leaking - Seal Or Replace?
1990 f150
I have a leak in my rear fuel tank, the front tank has been blocked off and is not used, The leak is at the seam of the two part tank, once removed is there a way to seal this? or should I just replace it?