Ford 7.3L Power Stroke (1999-2003) :: Cranks / No Start Sometimes Stalls At Idle
1999 7.3l 6spd standard 4x4. Just bought the truck 4 months ago knowing it had a problem that once warm occasionally would t start. Happened a few times every week or two. But wait 15 minutes and the truck would fire back up. Then it started happening more often throughout a day. And I would have to wait longer for it to cool to start it up.
Icp has been changed
Cam sensor
Pulled valve covers to check to see if there were any injector o rings failing. They were all good. Put it all back together.
Pulled the IPR and tore it apart cleaned it all out
Started driving it ran great for a week. Then today sitting at a light the truck died just as if I had turned the key off. Wouldn't start for 3 hours. The. Fired up. Took it to buddies show and started checking things out again. Both batteries load test great and fully charged. Alternator pumping out 13.5 and up.
Codes i have pulled are waste gate to high /low
I forget the number for that one. The second was P1211. Cps has been changed and ipr cleaned. Think that I should replace the ipr of this happens again?
I did get w code a few weeks ago about low voltage at module. this code doesn't appear anymore. Since I checked the plug ins all looks good. But the PCM wasn't mounted properly. So I fixed that up and checked battery connections. They were very good so I re did all of that.
Anyway. Back to the problem. After ipr clean. Drove as she should until sitting at a light a week later. Truck just quit. Would t start back up until cold. Any thoughts. New IPR? Oil in hpop within half inch from top. And I don't seem to have any oil leaks. Did oil change fuel and air filter. Not low on any fluids. I had a 1997 too and threw a bunch of cash at it like this one trying to find the issues.
Passat (B5) :: 1997 VR6 Stalls Or Stutters Hard After Clutch Drop
Just started doing it last week some time and only happens when I am launching it from stop or grabbing gears hard.
This is a little idea on whats happening.. At stop light next to some random ricer.. maintaining 2500 rpms on tach
drop (stage 4) clutch on green
Car squeaks and dies out like a stall and dash lights flash as well as lights on controll/radio area (around abs light) radio shuts off like a stall.
Ford F-150 - 1997-2003 :: Cranks But Won't Start?
I'm trying to diagnose a no start issue on my son's 1997 F150 4.6L W code motor. It quit on him while driving and we haven't been able to get it re-started since. We immediately assumed the fuel pump was bad as we were not getting any fuel pressure and we cannot hear the pump running at key on. So we pulled the pump and bench tested it, and the pump itself seems fine.
We then checked for spark, we have spark in all cylinders. After that we started checking fuses and #30 under the dash was blown. We replaced that and it blew again at Key on. We ended up going through about a 1/2 dozen of them while poking and prodding at misc. wire harnesses trying to figure out why it keeps blowing. Today we put a new one in and have tried restarting and that one is not blowing anymore, but we still cannot get fuel pressure. We've checked all fuses and swapped relays around. We noticed that under the dash #20 and #21 do not have power, but the fuses are ok. Are we finally on to something here?
Ford F-150 - 1997-2003 :: 2003 F150 Cranks But Won't Start
This has happened twice in 3 years....I get regular service from a Ford dealer and am overdue.... I think it may be temp related. Has been below freezing the last few nights. Truck was parked on an incline during the last two "shutdowns" ( engine lower than bed slightly), I drifted to a level position and it started. This has only happened twice previously. Now it seems to be a permanent problem but I am unable to get to the dealer without a tow... which I am trying to avoid.
View 2 RepliesFord F-150 - 1997-2003 :: 2001 - Cranks But Will Not Start
I have a 2001 F150 Supercrew Lariat. About a month ago I stopped to fill up with gas and afterwards it would crank but not start. After a few tries the engine would no longer turn over. My battery was 7 years old so I replaced it and the problem went away for about 5 days. Then the same thing, crank but no start. I checked all the fuses & called the local Ford dealer.
After talking with the parts dept. I tried hitting the panic button then the truck started. After talking to parts again I replaced the PATS transceiver. After 3 weeks with no issues the problem came back. This time I locked the doors with the keyless entry remote then unlocked them & the truck started. So I'm wondering what is my problem. Could it be the PATS module or something with the keyless entry module or some other issue.
Ford F-150 - 1997-2003 :: 2001 - Cranks But Won't Start?
F-150 Super Crew 5.4 4X4 cranks won't start. what and where do I check first?
View 8 RepliesFord F-150 - 1997-2003 :: Cranks - Won't Start Intermittently?
Several months ago, my truck begins having starting issues. Intermittently, the truck will not start, even though it cranks fine. I have done the following:
- checked inertia fuel switch. Okay.
- checked connections under hood for corrosion. Okay.
- checked fuses & start relay. Also swapped relays with no luck fixing the problem.
- sprayed water at various locations under the hood and bed, since the problem occurs more often when raining. No luck stressing the problem.
- changed fuel filter a couple weeks ago. No luck fixing the problem.
- changed battery over the winter (due to my 8 year old battery was becoming weak). No luck fixing the intermittent starting problem.
- changed the starter a month ago (since the truck stopped cranking). No luck fixing the intermittent starting problem.
- Installed a fuel pressure gauge on the fuel rail.
- Tried banging on the fuel tank with a rubber mallet. No luck fixing the intermittent starting issue.
When the truck refuses to start, the fuel pressure reads 0. Sometimes I can wait 5-10 minutes, and it will start. The truck runs fine after starting.
Sometimes waiting 5-10 minutes will not solve the problem (fuel pressure remains 0). Then, I hook my battery charger to the battery, and the voltage climbs from ~12.5V to 14.7V. The fuel pressure climbs to 30, and the truck starts.
I'm apprehensive to change the fuel pump, since it seems like more an electrical problem than a pump problem. Any diagnostic test that will tell the true problem source?
Ford F-150 - 1997-2003 :: 2000 - Cranks But Won't Start
Here's the deal. Ive got a 2000 f150 4.6 4x4xlt 170000 miles, About 2 ears ago or so the truck would not start on the first try or two. now this only occurred every once and a while. Last winter it became more of a problem. All i had to do was cycle the key a couple times listen for the pump to prime and was good to go. Summer rolls around no problem at all. Fall rolls around and here we go again no prime. cycle the key a couple times good to go. As it gets colder the problem gets worse. No we fast forward to couple a weeks ago, was out in the woods cutting firewood i go to move the truck and it wont start. I have to cycle the key like 30-40 times. Now its doing it like every time i go to mov the truck until yesterday. Now it wont prime at all. Now every time it primed in the past it runs perfect after it starts . the filter has been changed every 12-15000 or every fall, Ive replaces the fuel pump relay to try it no change, tryed the other key no difference. Im leaning towards a pump but ive never heard of one doing this before.
View 6 RepliesFord F-150 - 1997-2003 :: 2001 - Cranks But Won't Start
About a month ago, my 2001 f150 supercrew (4x4 5.4L) didn't want to start one morning. This was after a very cold night (15 degree temps). It sounded like it had plenty of juice in the battery (cranked good), just wouldn't start. Later in the day, after it warmed up, still no start. I dug thru here, and someone recommended disconnecting the positive battery cable for a minute then retrying. I did it, and it worked. All was good.
About a week ago, no start in the morning again. Tried the positive cable disconnect, no luck. After several hours, it just seemed to randomly start, and all was well again.
Today, truck started right up in the morning, but later in the afternoon (warm winter day 45 degrees) no start. Tried the positive cable disconnect, no luck. After screwing with the truck for about an hour, I decided to put the fuel pressure gauge on the rail. NO fuel pressure.
Is fuel pressure associated with the PATS, or is this a straight up fuel system problem?
Additional info: My gas tank fell out this summer, (recall on those tank straps), and I had a new tank, pump, straps and lines installed. I had a no crank, no start issue this summer, but that turned out to be the transmission not registering in park. I assume the two issues are unrelated.
Ford F-150 - 1997-2003 :: Engine Cranks Over Fine But Won't Start?
The Engine cranks over fine, but won't start. When it does start everything is okay and it runs good with no codes. I noticed that by taking the key out of the ignition, I was checking under the hood, and put it back in the truck fired right up. Also it has never done this to the second driver who has a different key. The truck runs fine at all speeds and loads, even when hauling twenty bags of wet mulch. It's a 2001, 4.6 L, RWD. Could the PATS Chip be failing?
View 9 RepliesFord F-150 - 1997-2003 :: 2001 - Cranks But Intermittent No Start
01 supercrew 4.6. Have had intermittent no start. The first few times it did start with a jump. Cranks fine but I thought the battery was weak. Replaced battery, same issue. 40 psi gas pressure at the fuel rail with analog gage. Theft light blinks with battery inserted. Theft light not illuminated while cranking. Battery light flashes while cranking. Battery is brand-new and charged. Opened and closed inertia switch several times to check.
View 12 RepliesFord F-150 - 1997-2003 :: 1998 4.6L - Engine Cranks But Will Not Start
I have a 98 F150, 4.6L with approx. 245,000 miles on it. recently it started, then studdered a little bit and died. I managed to get it re-started, it then shuddered a little more although I was able to drive it back up the drive way and park it. Now, it will crank however it does not even attempt to fire. The sound that it makes when trying to start seems odd to me. Like the engine is just turning against a constant resistance instead of the normal starting sound. I tried shooting a little starter fluid into the throttle body and nothing changed. I pressed on the shrader valve and got a spew of fuel to come out so it seems that it might not be a fuel problem though it sure sounds like one. Just curious, what are the symptoms of a truck with no compression?
View 4 RepliesFord F-150 - 1997-2003 :: 1999 - Truck Cranks Over But Won't Start
Last night my boyfriend took a friend to the check cashing store, truck ran fine. shut it off, and when he came out the truck would not start. it cranks over but won't start. Took ignition coil off and had it tested but its fine. What else could be wrong or what can i do to try to get it to start again.
View 5 RepliesFord F-150 - 1997-2003 :: Cranks But Takes 10 - 15 Seconds To Start?
It driving me crazy. Every 10th start of engine it cranks over and over before it fires up, no codes, changed plugs, wires, crank trigger, fuel filter, upper and lower intake gaskets, injectors, iacv. I have no clue. Runs great all time just starting issue every 10th or so start takes 10- 15 seconds to start
View 2 RepliesFord F-150 - 1997-2003 :: 2002 Suddenly Won't Start / Cranks But No Spark
All of a sudden my 2002 F150 6cyl, will crank but won't start. First thing I did was hook up my timing light to see if I'm getting spark when I crank. Tried a few different plug wires.....no spark. Can a coil just go out like that? I have a multimeter, what do I check to see if the plug that goes to the coil is providing correct power and input?
View 14 RepliesFord F-150 - 1997-2003 :: Changed Instrument Cluster Now Cranks But No Start
So I noticed this is a common problem in several scenarios. Some are electric failures and key failures and computer failures....And other times they happen when you switch the cluster.
I had a blacked out cluster with a couple broken gauges and after spending an hour swapping the cluster I get a crank but no start. I tried switching the 301 and 304 fuses (fuel pump and PCM) as that was mentioned somewhere online but it did nothing. Any quick fixes or do I need to tow it to a dealership?
2001 Supercrew with 4.6L and 4x4
Ford F-150 - 1997-2003 :: 2001 - Cranks But No Start After Hard Rain
I have a 2001 F150 Supercrew that cranks but will not start after a hard rain. The mechanic checked the gem module and the fuse box, the gem module looked good but the fuse box had some corrosion he thought from water so he replaced the fuse box and had a body shop reseal the windshield. The first time it rained it started right up but after the next rain it would not start. I went out 12 hours later and it fired right up. I wonder if I would be better off taking to a Ford dealer. What to do next.
View 2 RepliesFord F-150 - 1997-2003 :: 2000 2WD - Engine Cranks Great But Will Not Start
2000 F150 4.6L Romeo 2WD. Engine cranks great. Fuel pump working. Changed fuel filter. Will not start. No codes. Fixed A/C day before yesterday, only had air coming out defroster, disintegrated vacuum hose at firewall. Ran errands yesterday, no problems whatsoever. Get in truck today to go to work and no start at all, engine turns over fine. What next?
View 7 RepliesFord F-150 - 1997-2003 :: 2000 Truck Cranks But Won't Start - No Fire
2000 ford f150 4.6 auto. Will spin over but won't start. checked coil for fire, no fire. Check fuel rail for fuel, no fuel. No theft light flashing and no check engine light on. Has new battery and plenty of fuel in tank. Started fine yesterday but not today.
View 5 Replies