Ford F-150 - 1997-2003 :: 2002 - Have Rear Disc Brakes?
I have 2002 f150 XL 4.6 L 2 wheel drive.Do i have rear discs?Need to change them not sure what to buy.
View 5 RepliesFord F-150 - 1997-2003 :: Rear Brakes Drum To Disc Conversion
Changing rear drum brakes to discs? I've done it with my 94 explorer, and i was wondering if the axles are the same, just swap the hardware like the explorers are.
View 14 RepliesFord F-150 - 1997-2003 :: 2002 - Rear Axle Drum To Disc Brakes
I got a 2002 f150, right now it has a 9.75 with disc brakes. But it exploded. I can only find a 9.75 with drums in the wrecking yard. Can I just swap my disc brakes on to the axle with drums?
View 1 RepliesFord F-150 - 1997-2003 :: Rattle When Going Over Uneven Roads / Rear Disc Brakes Noisy
I've had this "rattle" when going over uneven roads for about the past few months and I think I narrowed it down to the rear calipers. They are both tight, but it seems as though the "floating" ability of the caliper is loose.....does that make any sense? I mean you can grab the caliper and it'll make a rattling noise, but the bolts are tight..
View 5 RepliesFord Brakes/Suspension :: 1997 F150 - Converting Drum Brakes To Rear Disc Brakes?
I have a 1997 F150, 4X4. My mechanic says its time for new brakes and was curious if it would be worth possibly converting from drum brakes to disc brakes??
My mechanic has quoted me $300 to do the rear brakes, would it be worth the extra money to convert??? I really don't care for drum brakes. I have done a search on the internet and every time it brings up the issue with the parking brake.
Smart - Fortwo :: Dust Coming Off The Front Disc Brakes / Front Wheels Look Filthy
I really enjoy my 2009 Smart car, excellent gas mileage, fun to drive too. The only drawback is all the dust coming off the front disc brakes that makes my front wheels look filthy even when the rest of the car is clean. Are there other brake pads that work as good as the factory originals yet don't give off so much dust?
View 4 RepliesFord Super Duty (1999-2016) :: Little Wire Spring That Applies Pressure For Brake Pads On Front Disc Brakes Lost
My 18 year old launched the little wire spring thing that applies pressure for the brake pads on front disc brakes. Could have gone in to neighbor's yard! Actually lost one on each side. He put it all back together without one on each side. I said it would still work fine. What's the deal really? Can't be that important are they?
View 14 RepliesJeep - Cherokee :: Front Disc Brakes Are Creating A Small Amount Of Drag On Rotor
My front disc brakes are creating a small amount of drag on the rotor. With the car jacked up and wheel off I am able to easily turn the rotor by hand, but there is a small amount of drag. I haven't had any problems with my brakes, they have never frozen or overheated, etc. I put new brake pads and rotors on the front about 6 months ago only because it was time for replacement. The question is: how much disc brake drag is acceptable? Looking around on the internet for answers there doesn't seem to be a consensus: some people say absolutely no brake drag, some say that a small amount is normal. What do you think?
View 6 RepliesFord Brakes/Suspension :: 2002 - Deleting ABS System 2wd All Disc Brakes?
Im wanting to delete my abs brake system in my f150 2002 2wd all disc brakes.
I have to change the module with some kinda valve? and turn off the Abs in a tune?
I know the basics of a brake system, but im lost in the abs stuff.
Ford F-150 - 1997-2003 :: 1999 - 2004 Radio Can Work With 6 Disc Changer?
Can I or could I make an 04 Radio with a 6 disc changer work in a 1999 F150. The radio in the truck now is having some issues and I don't want to put an after market in so I am just wondering if it could work.
View 2 RepliesFord F-150 - 1997-2003 :: 1999 - Front Brakes Lock Up
I had both front brakes lock up on me the other day and burnt the shoes out so I replaced the pads and installed new calipers and flex lines. I also went ahead and replaced the rear shoes and both wheel cylinders since this truck had been sitting up for the past few years I figured why not. I flushed the system out but I can not get all the air out of the right rear wheel cylinder. My question is could the new wheel cylinder be bad? The new left cylinder blew out when I first started bleeding the right side. I could not get any pressure at all and I looked over and seen fluid pouring out the left side. I put the old one back on only due to time restraints. Should I replace the right side again as well? I have used up 4 1/2 bottles of 3e2 oz brake fluid and still have air in that side.
View 4 RepliesFord F-150 - 1997-2003 :: 2001 - Disc Brake - Pads Will Smoke If Do A Hard Stop
2001 supercrew 4x4 all wheel disc brakes. Driver side brake is stopping harder than all the rest to the point that the pads will smoke if you do a hard stop
thought it was the caliper sticking. Replaced caliper and mount. Still same problem. Thought possibly there was air in the lines. Bled all 4 brakes several times. And still the driver front wheel still stopping harder than the rest. I wouldn't think it would be the master cylinder.
Ford F-150 - 1997-2003 :: Rear Brakes Have More Power Than Front And ABS Code
So when I got this truck everything on the brakes were messed up. So long story short I got a new master cylinder new pads and all lines are bled. Now this hole time my ABS light has been on so I looked at all the sensors and i found one connector that goes to the rear axle but it has no where to plug into. But I also found some writing on the axle which tells me that is a different axle and may not have had ABS set up. But I am not sure. Now the problem I am having is when I hit the breaks i don't have much bite but if i push on them harder the rear will lock up and the front brakes are biting just a little like 50% power. So how can I get more stopping power to the front pads ? And if its that unconnected sensor is there anyway i can loop in out of the system ?.
View 6 RepliesFord F-150 - 1997-2003 :: 1999 4x4 Lariat - Both Front Brakes Dragging?
I have a 99 f150 4x4 that has done this twice, once last year and once this year during hot (90+) weather. I'll notice the vehicle seems like it doesn't want to go. Park overnight and it will work ok. Last time it happened the other day I stopped at wally world and both front wheels were real hot and I could smell the brakes. Came out hour later and when I pushed the brake pedal to put it in gear the pedal went to the floor.
Pumped up pedal and drove off but truck would barely move, drove 10 mph to a buddy of mines shop and it sat overnight and worked perfect the next day. He inspected everything and seems to think it might be the abs control unit. He noticed a small amount of fluid had come out of the unit and dripped on the ground. Also no abs light or brake light has ever come on
Ford F-150 - 1997-2003 :: 1999 - Front Brakes Dragging / Sticky Caliper
Bought a high mileage 99 f150 4x4 yesterday. In the process of cleaning her up, the water hose hit the disc brakes on the drivers side and it was hotter than a BBQ grill! Ok, immediately I thought this isn't good. Jacked her up and pulled the caliper. Pads were almost gone so replaced them with a new set, went for a drive. Now the damn things were smoking so bad I thought they were gonna catch fire! Sticky caliper , right? Stopped and got one then realized that the passenger side started doing it too.
Another trip for the other caliper and new pads because these were toast. I mean just burnt to hell. Before I started working on the truck again, I checked on here and I'll be darned if I didn't find out that the old brake hoses might be acting like a check valve because of rust and deterioration. Got a set of brakes hoses too. Put everything on this morning and works like a charm.
1999 4.6 XL
Passenger side done
Ford F-150 - 1997-2003 :: Front Right Wheel Locked Up When Lightly Applied Brakes
Going down a steep loose gravel drive way, going maybe 5 miles per hour. About 50 feet before the stop sign we lightly applied the brakes and the front right wheel completely locked up. If we didn't turn into the grass we would of stopped in the middle of the busy street. We picked up speed when we applied the brakes, like we were on ice. When I got out, I could see the one long brake mark in the driveway. This happened on a paved road about 6 months ago, it had some loose gravel at the stop sign. I couldn't tell which wheel locked up at the time. This happened on snow in December to, twice. Since the ABS light never came on. Brake pads and rotors needed replacing about 9 months ago. Tires have been rotated, no change. Not sure what it could be. I disconnected the Abs fuse for now.
View 5 RepliesFord F-150 - 1997-2003 :: 1998 - New Front Calipers / Brakes Barely Functioning
I just bought a 1998 F150 2wd with the 4.6L(no ABS) to be my beater home depot truck. The brakes barely functioned, so I replaced the front bearings, rotors, pads, and calipers. I bled the brakes exactly like I normally do. When I tried to move the truck, the rear tires spun with the front completely locked(also discovered the right rear line had a hole and crimped the line for a moment, but it was the tire that was spinning).
I searched and many people said that bad rubber lines cause the calipers to lockup. I loosened the bleed valves and the fronts were still locked(jacked up the truck and used a breaker bar on lug nuts trying to rotate each tire). I am guessing that it has to be master cylinder or the steel lines. Any tests I could do to narrow down this issue further?
Ford F-150 - 1997-2003 :: Rubbing Sound At Front End Only Audible When Brakes Applied
I have a 2001 f150 4x4 5.4 Liter 72000 miles. There is a rubbing sound that is only audible when the brakes are applied. And only when applied with light pressure. The noise will continue intermittently until you come to a complete stop. If the brake is applied aggressively there is no sound at all. I am not sure if it is a brake issue or some thing in the front end that is flexing when slowing down.
View 3 RepliesFord F-150 - 1997-2003 :: 2002 - Brakes Pulsing In Front Like Antilock As If Braking On Ice
It's a farm truck, lumber getter trailer puller. Not driven often, after sitting for awhile the brakes seem to be pulsing in front like antilock, as if braking on ice. I checked both front caliper springs or plunger slides and they are free not froze up.
View 1 Replies