Ford F-150 - 1997-2003 :: Intermittent Fuse Pressure - 20 Amp Fuse Wiggling
I was having intermittent fuel pressure problems. I replaced fuel pump and relay and was still having the problem. A figured out that wiggling the 20 amp fuse would cause the intermittent. Looking at the connections for the fuse, I can see one side was damaged. I figured I could pull the connector out from the back and fix the connector, but when I took the back off (see picture) I have a purple wire (labeled 1) going to one side of the fuse and a multi-connector (labeled 2) from one wire going to the other side. My luck, it's the multi-connector side that is damaged.
It Looks like the multi-connector goes to the Black and yellow wire. Instead of replacing the box, I figured I could just create an inline fuse for the fuel pump with the purple wire and splice it into the Black/yellow wire.
I can't see any problem with this, just looking for a second opinion. And I'm not sure how it would effect the relay. I can't find a fuse panel wiring diagram anywhere.
Ford F-150 - 1997-2003 :: 1996 7.3 - Burning / Loosing Oil
I have a 1996 7.3 Power Stroke with 171,000 miles. I noticed I was burning oil the end of last year and changed the turbo as the seals were out of it and that slowed it down but did not resolve the issue, so i then moved to injector o'rings and replaced all of them, and after 1000 miles with the new orings and a new oil change i have still burnt 3 qrts.
View 1 RepliesFord F-150 - 1997-2003 :: Blue Smoke / Burning Oil / No Low End Power
Alright so In January had head gaskets done on my truck and when I got it back it Dont have any low end power and I noticed it was using oil. If I let it idle 15 min or so and rev it up it blows out a bunch of blue smoke and smells like oil bad. Been trying to figure out whats going on. Ive only put about 800 miles on it since I got it back for the head gaskets And its burned at least 3 quarts of oil. Its going to the shop on Monday gonna start with compression check and go from there I'm Thinking Its valve seals or a bent valve. But machine shop surface and pressured checked the heads. Truck only has 146000 miles on it shouldn't be having these lined of problem. Its an 03 5.4.....
View 7 RepliesFord F-150 - 1997-2003 :: In Cab Fuse Box Just Falls Out
I am having an issue with a fuse in the in cab fuse box, it just falls out. How to get the fuse box down from behind the dash ? If i could get it down I can repair the fuse holder, or something.
View 2 RepliesFord F-150 - 1997-2003 :: PCM 30 Amp Fuse Blowing
Why the 30amp PCM fuse located in the under dash panel would blow. Problem started while truck was running and a simple replace of the fuse would it it back alive again. Now fuse is blowing at ignition on. Truck is 1997 F250 LD.
View 7 RepliesFord F-150 - 1997-2003 :: FX4 - Fuse 23 Keeps Blowing
I am having trouble with fuse 23 under the hood blowing while driving. I have read several threads on this issue but still no luck. I have removed all 4 02 sensors and ac relay and still about 1/4 mile down the road the fuse blows, and is giving the shift solenoid A shift solenoid B and the torque converter clutch solenoid electrical circuit. I have checked both plugs on the trans, I even dropped the pan and ohmed the solenoids out. I dont know what else to do?
View 14 RepliesFord F-150 - 1997-2003 :: 2001 - Fuse Box Diagram
I just bought an 01 F150 and previous owner didn't have the manual.
Need a copy of the fuse box diagram for this truck?
I've been surfing the net, and can't find what looks like the right one.
Ford F-150 - 1997-2003 :: Horn Does Not Work - Fuse?
Is there a fuse or some thing? Can I rig it?
View 6 RepliesFord F-150 - 1997-2003 :: Losing Coolant - Burning Quart Of Oil Every 3000 Miles?
I have a 1997 f 150 4.6l, 145k miles, it seems that very slowly it is loosing coolant but i haven't noticed any leaks, it also burn about a quart of oil every 3000 miles but i was told that was normal?
View 6 RepliesFord F-150 - 1997-2003 :: OBD Port Not Working But Fuse Is Good?
Cigarette lighter works and shared fuse seems fine. OBD port even powers up my cheapo elm bluetooth reader. Unfortunately multiple different readers refuse to connect. I've tried disconnecting negative terminal for a half hour and trying again but no luck.
View 3 RepliesFord F-150 - 1997-2003 :: Fuel Pump Fuse Keeps Blowing
I have a 2000 F150 with @175K miles. Replaced the clutch about a year ago, replaced the front calipers a few weeks ago, due to the right front locking up on my way home from work. Since then, when I try to start, it blows the fuel pump fuse. (#10)...
View 2 RepliesFord F-150 - 1997-2003 :: 30a Fuse Keeps Blowing - Truck Won't Start
2002 F150 5.4L. Keeps blowing fuse in location #30 which is a 30a fuse for the following:
Passive anti theft transceiver
Cluster
Ignition Coils
Powertrain control module relay
Coil on plugs
Radio noise capacitor
ECC diode
Could this be a grounding spark plug wire?
Ford F-150 - 1997-2003 :: Fuse Blowing Down Every Time Overdrive Tries To Engage
My 2002 f150 blows the overdrive fuse (#29) every time the overdrive tries to engage. Could it be the overdrive switch? Where is that switch? Could it be a speed sensor? Truck has an automatic transmission and a 5.4 engine.
View 14 RepliesFord F-150 - 1997-2003 :: Part Number And Location Of Battery Fuse?
Had a question about where the battery fuse is located and it's number. I just put a brand new alternator on.my truck. Turns out I might not have needed one, switched the battery with the new alternator on and the truck still went dead after it ran for about 10-12 seconds. So some told me it may be the battery fuse but I don't know which fuse it could be.
View 2 RepliesFord F-150 - 1997-2003 :: Keeps Blowing Fuse / OD Light Flash / Only Have Two Gears
My 01 f150 keeps blowing a fuse. It makes the O.D. light flash, only have 2nd gear, motor runs real bad. I forget how many codes it had but it was a bunch. It doesn't blow the fuse rite away. Sometimes its days between sometimes its hours. Where to start looking for the short?
View 8 RepliesFord F-150 - 1997-2003 :: Fuse Blown When Shift The Gear Lever To Below D
1997 F150 xlt 4x4 ... When I shift the gear shift lever to below D (2-1) it blows a fuse and I lose instruments. Replacing the fuse is not difficult, just tiresome..
View 6 RepliesFord F-150 - 1997-2003 :: 2001 - Blows Fuse Touching Gas In Reverse
Got a 2001 F150 XLT 4x4,4.6L, When you start the vehicle it seems to run a little rough you can drive around with it OK. Soon as you put it in reverse,It starts to really run rough..touch the gas pedal and fuse position #30 blows.
This fuse is for : Passive Anti theft Transceiver, Cluster Ignition Coils, Powertrain Control Module, Relay Coil on Plugs, Radio noise Capacitor, ECC Diode.
I have checked cables and connections, all seem ok...Relays are fine. Nothing seems burnt on the cable running from the engine to the exhaust. I don't see any wire breakage in the tilt Column.
Cant find a short if it is one.. Even removed the aftermarket Remote starter from the circuit ... still blowing that darn fuse.... What to check now, or what it could be?
Ford F-150 - 1997-2003 :: Automatic Transmission - Overdrive Fuse Keeps Blowing
I have a 2001 f-150 looking for answers to my problem automatic transmission my overdrive fuse keeps blowing. My third and and overdrive don't work. It shifts 1st to second but that is it. No other fuses are blowing.
View 3 RepliesFord F-150 - 1997-2003 :: 1999 - No OBD2 Port And Good Fuse?
I just picked up a 99 F150 for a song because it has an issue with the PATS system and the po doesn't have a clue on what to do with it. I bought a new ignition cylinder and Auto Enginuity to program the PATS. The problem I'm having is that I'm not getting anything from the OBD2 port and the #3 fuse is good. What else would cause the port not to have signal?
View 4 Replies