Ford Super Duty (1999-2016) :: 2007 - Tranny Cooler Line Is Return Line?
Have a 2007 V10 and I want to put in a Magnafine tranny filter. Instructions say to plumb it in to the return line. Which one is this, top or bottom?
View 11 RepliesFord - Explorer :: Adding Tranny Fluid Using Cooler Line?
I live out in the sticks, and leaked out a lot of tranny fluid. the fill plug in the pan is rusted bad. can I add fluid using the cooler line and a pump? so i can drive it to the repair shop.
View 4 RepliesFord - Explorer :: 2002 - Oil Cooler - Coolant Leak On One Of External Line / Hose Bib Elbow
The oil cooler mounted above the oil filter on my 2002 Explorer 4.0L V6 has a major coolant leak on one of the external line/hose bib elbow. I've googled Explorer oil coolers and I've searched this forum with no luck. Can you bypass it without any problems mechanically or electronically (throwing error codes)? I have already purchased a new cooler and the lower oil cooler line. I'm just wondering if I should return the parts and bypass it. If I go through the replacement, I noticed the cooler is mounted by a pass through threaded tube with a hex head molded into it for fastening/loosening purposes. What size hex head socket it is?
View 12 RepliesFord F-150 - 1997-2003 :: Lower Transmission Oil Cooler Line Is Leaking
Transmission oil cooler line, lower one, is leaking. I think to use pvf, black ones, brake line instead of new transmission oil cooler line. I did replaced upper one with new transmission oil cooler line before a few years and it is rusty already as those line are only zinc plated as opposed to plastified brake lines.
View 12 RepliesFord 7.3L Power Stroke (1999-2003) :: How To Remove Transmission Cooler Line
As explained in the photo annotations, I can't figure out how to remove this line from the radiator so I can remove the radiator for cleaning.
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: F250 - Transmission Cooler Line Leaking?
I bought a 2003 F250 7.3 Powerstroke from a buddy of mine with 99,500 miles. It is a former Michigan truck and has some significant rust issues. Oil pan and drivers door will need to be replaced in the not too distant future. And probably bed rails later too.
In any case, I noticed a puddle of tranny fluid on the driveway when I got home today. The passenger side line at the fitting into the bottom of the radiator has corroded through. The fitting into the radiator is pretty rusty, and the line fitting is darn near destroyed. The line itself actually has a hole in it.
I see the same part numbers on different sites with different descriptions. Driver side here, passenger side there, inlet here, outlet there. For the same number.
As near as I can tell, Dorman number 624-059 is the outlet line from the tranny to the passenger side radiator fitting, and should be the part I need. Correct? Dorman 624-058 seems to be the line from the OTA auxiliary cooler and back to the tranny. What I cant find is the line from driver side radiator to the OTA cooler. That fitting is corroded bad too, and I may as well do both of them.
Ford Super Duty (1999-2016) :: 2000 - Transmission Fluid Leaking From Cooler Line
So my 2000 f350 is leaking transmission fluid from the cooler line. It goes to the rear of the transmission, but where does it go to from there?
View 5 RepliesLexus SC430 :: Transmission Cooler Line Location?
What is the location of the Transmission Cooler Line? Is it by the radiator?
View 12 RepliesFord Super Duty (1999-2016) :: 2008 F250 - Transmission Cooler Line Start To Leak
I have a 2008 Ford F250 V-10 Superduty and recently I had a transmission cooler line start to leak. I ordered replacement lines and the tool for the quick disconnect. The line that's leaking is from the radiator to the quick disconnect. I was able to replace the one line, however the second line (problem area) has been a nightmare. The line cracked right at the quick disconnect fitting.
The hard line is tight in the fitting and corroded. broke the tool trying to remove from disconnect. The line is flush with the quick disconnect. How to get that out of the fitting? or another method of fix? Its a hard 1/2 line going into connect crimped to rubber line going to transmission.
Santa FE SM (2001-06) :: 2003 - Transmission Cooler Line Leak
I've just (a couple of weeks ago) purchased an 03 Santa Fe. I noticed some trans fluid on my driveway a week later, and not a small amount. I took the lower cover off of the engine, and the leak is coming from the transmission oil cooler area. I had hopes that it would be something fairly straightforward to repair, so I got a replacement oil cooler and some spare hose, just in case it was just a hose. After getting the front bumper off, I found that the bottom of the oil cooler is clean and dry-- not the issue. It looks as though the leak is coming from what they're calling the Trans oil cooler "tube assembly", as illustrated on the Hyundai Parts Department trans cooler page as item number 5, part number 2547126011. Am I correct in assuming that I'm going to have to remove the entire radiator to get to this thing to replace it? It appears to be fixed in place, but I can't see any hardware to remove it.
View 10 RepliesPassat (B5) :: 2002 / 1.8T - Small Leak In Transmission Cooler Line At Radiator Connection
Had a small leak on show up in my transmission cooler line at the radiator connection. After replacing the o-ring, which was pinched, I had lost some fluid up to about 3-4 oz. I had stopped by the local VW dealer and picked up a liter of ATF fluid and noticed the colors of the fluid differed from what drained out from the cooler line. Fluid that drained out was a cloudy darker green/grey and the new ATF fluid had a clear yellowish tint. Is this vehicle equipped with a closed loop cooling system or does it use the actual ATF fluid as the cooling medium?
View 2 RepliesMonte Carlo :: 2000 Chevy - Removal Of Transmission Cooler Line That Connects To Radiator
I've a 2000 Chevy Monte Carol, 110K miles, 3.4L. How to remove the transmission cooler line that connects to the radiator. Can't seem to break the bolt loose that screws into the radiator. Not sure whether this is a quick connect fitting or not! it definitely doesn't seems like it. Also having problems removing the fan shroud. It doesn't seem to want to come out. Should this be remove prior to removing the cooler line?
View 12 RepliesFord Excursion :: Hole In A/C Line Running To The Rear
I am not sure if it is the high pressure or low pressure line. The line had rubbed on the frame and it wore a hole in the line. I want to get this fixed and wondered any remedies or if I need to replace the whole line. Someone said I could take it to a radiator shop and they could repair the line???
View 14 RepliesFord Excursion :: Brake Line From Front To Back Has Hole?
I have a 2000 ex v10 4x4 the brake line that goes from the front to the back has a hole in it and is rusted out. I need the part number?
View 6 RepliesSanta Fe (CM - 2007-12) :: Where Is Transmission Fluid Filler Hole
I have a 2010 Santa Fe V6. The transmission fluid filler cap is too close to a housing unit that a wrench or a socket won't fit around it but I also noticed another plastic cap that is connected to it and was wondering it that was for (is this where you fill in the oil? seems too small). I've attached a picture and would love to hear what you think. The filler cap is at the bottom and the plastic cap is on the top.
View 12 RepliesFord Excursion :: Trans Line To The Cooler Leaking Fluid
This line is rusted out on my V10 and leaking fluid.
How hard/expensive is this to fix?
I'm in the middle of doing my exhaust manifolds right now, so I'm hoping it's a simple bolt-on fix.
Ford Super Duty (1999-2016) :: Brake Line Going To Rear Right Wheel Has A Rusted Hole
On my '97 F250 the rear brake line going to the rear right wheel has a rusted hole. It measures 50" total. Instead of bending a new metal line. I see they have a "poly armor" line that can be bent by hand( no tools needed). I see Autozone has them.
View 14 RepliesFord F-150 - 1997-2003 :: 2002 - Power Steering Cooler Line Leaking
I have 2002 F150 5.4L gas 4X4 Lariat FX4. Last winter when it got to -30C here in Manitoba one of the lines near the power steering cooler began to leak. I had just bought this truck and upon investigating found that the original line had been replaced and reattached with hose clamps. I had this "farmer fix" redone but then this winter when it hit -30C it blew apart. Obviously something happened to this line before I got it, so I am curious if there is an issue with these power steering cooler lines when it gets really cold. Should I just get factory lines installed and hope for the best?
View 3 RepliesGolf IV R32 :: Hole In The Aluminum AC Line Next To The Radiator Clip
Don't drive my R every day these days. Recently had to get it out and get it smogged when I noticed there is no AC. Turns out the aluminum AC line next to the radiator clip on the passenger side has a hole in it. It has been vibrating against a screw head which finally drilled a hole through the line.
I heard the "ticking in the dashboard" sound.