Ford F-150 (2004-2008) :: Battery Light On And Whining Noise From Pulleys
I have 2005 F150 XLT 5.4 litre engine and my battery light comes on after letting the truck run on idle or sometimes driving.
Last Saturday went out drove it heater on and radio on I smelled something coming from the heater kinda like burning wire smell didn't think anything of it no smoke from heater (indicating the core was bad) no lights on the cluster nothing; went into the bank let it run came back out my battery light on. Drove it home and while driving the light goes off.
Opened the hood and the smell was coming from the alternator. So I turned the truck off. Let it sit for an hour or so then I took my voltmeter to see if the battery was good. The battery was 12.4v with engine off. Checked my battery connection for corrosion or loose connections everything was tight there was some dust on the battery terminals so I brushed them off. I checked the battery cable that goes from positive to the alternator where it connects to the alternator with that nut it was good, clean and tight.
So I started the engine up and I can hear a whining noise from one of the pulleys. Let it idle for 2 minutes no battery light so I put my voltmeter on the battery it read 13.8v, so I turned on the A/C, head lights, radio and the heater tried again the voltage dropped down to 11.9v then the battery light came back on. Also through all this my battery gauge in the cluster always stays a half way mark doesn't drop or go high. Next with the engine turned off I took the belt off checked the pulleys the idler pulleys seem fine and the belt doesn't show any glazing but the alternator was hot almost like touching a hot exhaust manifold.
So for the last 3 days I have been trying to come up with how to resolve this issue obviously it could be the alternator going bad but the battery has never lost a charge yet I let the truck sit for these past 3 days and today I started the truck and it started right up I don't see any dimming lights except it has a whining noise and the battery light didn't come on immediately I let it run for 5-10 minutes before it came on; I even drove it around the block and the whining noise gets louder every time I step on the gas. To me it's either I need new alternator, tension pulley is bad or the idler pulleys are bad but they turn fine.
Ford - Explorer :: 1997 - Whining Noise In Front End When Brake Too Hard
I first heard it start about two or three weeks ago. It started when I would brake too hard. So I took a look at the brakes and the caliper pin was rusty so I loosened it up and it was fine for a day or too. Then all of a sudden it started in the front like something was grinding. Someone told me it was the transfer case. so i put in 4 wheel drive and it goes but then you really hear the grinding. How can I tell if its the transfer case or the front end where the drive shafts go into.
View 1 RepliesLexus GX 2004-09 :: 2006 - Battery Light Came On - Whining Noise?
So about 3 or so weeks ago I brought my 2006 GX470 into the Lexus stealership and had the pulley's, water pump, and timing belt replaced. Fast forward to this morning, about 300 miles driven and it suddenly when started today has a terrible whining sound and the battery light is on the dash.
I need to go over the invoice from what they did but I believe it was 4 different pulley's they wanted to replace. Not sure if it was anything on the accessory belt path, but I imagine if I call they will blame the alternator and tell me to shell out hundreds more?
I didn't run it long like that, only a minute or so. Popped the hood and I could smell the burning rubber smell so I quickly shut it off. Nothing *appeared* seized to me however.
Ford - Explorer :: 2005 - Whining Noise While Driving On A Normal Road With Rear Window Down
2005 Sport Trac 4x4... So, my fiance purchased this new off the floor before i met her (or else she wouldn't have bought it). Had a motor issue which required a new motor after 90k miles.. Anyways, while driving on a normal road, i dropped the rear window and hear this whining noise. Checked the transmission fluid and it was a little low, nothing major. Topped it off with Mercon V... No effect. Where do i look next. It does not have a tow package. Do i check the transfer case, or rear differential?.I am thinking differential because the transfer case is more upfront to where the noise is. you cant hear it with front windows down. Only the rear sliding window or rear passenger's windows.
View 9 RepliesFord - Explorer :: 2004 - Vehicle Stopped Moving / Sounds Like Torque Converter Whining And Will Not Drive In Any Gear Or 4WD
I have a 2004 Explorer 4.0L with 190,000 miles. My wife was driving it and the vehicle stopped moving. Sounds like the torque converter whining and will not drive in any gear or 4wd.
View 1 RepliesCamry :: 2004 - High Pitched Whining Noise At Idle / Battery Light Flicker On And Off
Yesterday as soon as I started my car, I noticed a high pitched whining noise. As I drove, it seemed to stop, but as I slowed down and idled, it came back. After driving a couple miles, the battery light came on, so I turned off the AC, radio, and lights and it went off again, but as I sat at stop lights it would flicker on and off again.
View 4 RepliesFord F-150 (2004-2008) :: Whining Noise In 1st Gear
I've been noticing more and more lately that while my trucks in 1st or maybe 2nd gear, say, slowly coasting around a parking lot for example, there's a whining noise coming from either the rearend or the tranny (cant tell which). It gets louder and more high pitched as I move faster then disappears as soon as the truck shifts gears..
Is this something serious like my transmission on its way out? From what I gather a lot of people seem to have a similar thing going on.. From what I can remember my truck has done this since I bought it, but lately (and maybe its just me) I seem to notice it more like maybe its getting louder..
Ford F-150 (2004-2008) :: Whining Noise - Idler Pulley Going Bad?
I noticed my engine whine more than it usual since the last few days. So, I took it to the dealership and have them check. They said that it is the idler pulley going bad. Just want to see some info on diagnosis.
View 6 RepliesFord F-150 (2004-2008) :: Whining Noise From Engine - Idler Pulley?
I noticed my engine whine more than it usual since the last few days. So, I took it to the dealership and have them check. They said that it is the idler pulley going bad.
View 4 RepliesFord F-150 (2004-2008) :: Whining Noise From The Front End When Turning To Right Or Going Straight
'05 F150 5.4 Sounds like a whining noise from the front end when turning to the right or going straight. Goes away on left turns. Thought it was tire whine but put originals back on and got same thing. 13.5x35 verses 275 Truck has a Fabtech 6" lift. Right CV axle seems tight, rotor assembly replace 2k miles ago. Any other option before going into front diff?
View 2 RepliesFord F-150 (2004-2008) :: 2006 FX4 - Whining / Humming Noise While Accelerating
I just bought a truck, it has a whining noise while accelerating, stops while letting on the gas, does not do it in neutral even if i rev up the engine. Only whines while there is some force on it, ie.. accelerating, or going up a hill at any angle, and does it from about 10-15mph- atleast 60mph.
View 2 RepliesFord F-150 (2004-2008) :: 2005 - Rear End Whining Noise Inside Cabin
I'm new here to the F-150's forum although I've owned a few since 2001. I bought this F-150 '05 5.4L Lariat. Really nice truck. But when I purchased it, it had this weird noise inside the cabin. I thought because it had a camper on it that some tranny noise was coming up thru the camper and the rear cab. After taking camper off, the noise was still there. From everything I've read online, it could be rear pinion seal, differential bearing, tranny, front hubs, etc. I have left a video. Pay close attention to the little whine. Kinda hard to hear if your not listening for it.
Note- when i drive it is most definitely coming from the middle to rear of the truck. But I'm not ruling out anything. I have looked underneath the truck and the differential is dry and the driveshaft area near diff is dry. No leaks. I have not checked fluid in diff. Is there an easy way for these trucks? I have read and heard about adding an additive? The noise starts at about 10-15 mph all the way up to 80. I've never taken it past 80 but I'm sure it's still there.
[URL] .....
Ford - Explorer :: 1999 - Whining From The Rear End
I have a 1999 Explorer that i bought about a year ago. It has a whining noise a friend of mine told me is coming from the rear end. With my hearing I can't tell. It starts out around 15-20 mph and gets higher as I go faster. I checked the lube in the differential and its good. No leaks and fluid looks good. The noise goes away when I take my foot of the accelerator. If I put the truck in neutral, it also goes away. I haven't changed the trans fluid & filter yet.
View 4 RepliesFord F-150 (2004-2008) :: Whining Noise From Front Of Engine Around Idler / Tensioner / Alternator
My 2007,4.6 is making a whinning noise from the front of the engine around the idler/tensioner/alternator. What I have read it might be a problem with the alternator getting cold, I forgot to mention it's cold up here. Fixed by changing the alternator and did the noise come back as it seems to be a design problem?
View 12 RepliesFord F-150 (2004-2008) :: 2005 FX4 - Whining Or Whirring Noise In Rear When Pushing Throttle?
I just bought a 2005 fx4 and there is a whining or whirring sound coming from the rear of the truck when I hit around 70km/h. the second i let go of the accelerator it stops.
Today when I got home after a 15 minute highway drive, i got under the truck and felt the differential area. it was warm but not hot. and there was a wet spot on it. i wiped off a drop of oil. there was also a wet spot on the bottom, seemed to be just water? I'm not sure.
Ford F-150 (2004-2008) :: Loud Whining Noise Coming From Rear Axle Housing
Some family members borrowed my truck, and when they returned I have a loud whining noise coming from the rear axle, which I have determined is a 9.75 rear. I checked oil level and it was high enough, but has a slight leak from the pinion seal. Everything feels solid but I have nothing to compare it to.
Its on a 2005 Super Cab with the 5.4L 183,000 miles. The front pinion seal was replaced in Feb 2 years ago, by the dealer's mechanic, who may have been a shade tree mechanic.
I am a Youtube Certified Mechanic, as in, I watched about 10 videos of people working on their 9.75 differentials, and realize I don't have all of the tools to do the job, such as a press, or race drivers, or the special gauge.
How many of you have tackled this issue? What did you find? What am I looking at for cost? I am on a very small budget.
Ford - Explorer :: 2007 - Loud Whining While Driving
My 2007 Ford Sport Trac 4x4 with 47K on it, has a loud whining noise while driving. I checked the wheel bearings and there is no play side to side or up and down. No noise rotating the wheels. I noticed that both drive shafts turn while rotating a front wheel off the ground. No dash lights are on indicating it`s in 4 wheel drive. Could the 4x4 shift motor be bad and not disengaging 4 wheel drive ? Is there a way to check it ?
View 7 RepliesFord - Explorer :: Subtle Whining Sound Coming Somewhere From Outside The Car
A few days ago I was driving on the freeway for about 20 minutes and started hearing a subtle whining sound coming somewhere from outside the car. To quickly narrow it down to the engine, a wheel or the drive train, I pushed the clutch in, took it out of 5th and waited for the RPMs to drop. Then I hit some noisy rough asphalt and couldn't tell. Oh, well.
Here's the first big clue. When I shifted back into 5th, the gear shifter went into gear with no problem, but the clutch would not re-engage despite the pedal returning to its normal position.
Here's the second clue. Since I couldn't get the clutch to re-engage I decided to try one more data-gathering action. I turned the engine off (still coasting at 70 mph) and tried to restart. It would not restart, exactly as if I had not depressed the clutch pedal. So, I coasted for as long as I could and then walked the remaining 1.5 miles.
Here's the third clue. When I got back to my car about an hour later I tried to start it again. No joy, but then I heard a click underneath the car when I released the clutch pedal. I tried once again and it started. I drove the remaining 1.5 miles to the exit and started to notice the clutch appearing to stick for a second and then suddenly release. When I got to the gas station where I was before, it was done, just like on the freeway. Again, the gear shifter and the clutch pedal operated totally fine, but it seemed that the business end of the clutch would not re-engage until it cooled off. After it cools off, everything seems to work just fine.
So:
1999 Explorer Sport
4L V6 SOHV
5-speed manual
196,000 miles
What should I check?
Ford Super Duty (1999-2016) :: 2003 6.0 4WD - Low Rumble Noise / Whining When At Light Throttle Load And Above 50 - 60 MPH
I have a 2003 F250 SD with 130K miles. I primarily use it to pull a race car, about 5000 lbs is all. It has all the upgrades, from studs to EGR delete. Ford replaced the automatic transmission in 2005. I'm looking at a truck newer than 2011, but thinking either a flex fuel 250 or diesel. I want it loaded and 4WD, but they seem expensive.
Anyway, I have bad front wheel bearings. I know this because of the low rumble noise and how it acts when I rock the steering. How tough are they?? I build my entire race cars, so I have a well-equipped garage and some ability to cuss, but I don't have a lot of time. A buddy wants to do it for $300 total for both sides plus parts cost.
Also, this is the bad part I really need input on. It has a whining when at light throttle load and above 50-60 MPH. This seems to come from the floorboard area behind me. Gear changes do NOT affect the pitch, but a change in throttle crowding makes it louder and weaker. It has no coast down noise at all, and the noise pitch seems to track the drive shaft speed. It is a whine much like the low gear set in an automatic trans, but it does it in any gear with or without 4WD on. The only thing that affects the level is slightly pushing the accelerator, speed, or weight I am towing.