Ford F-150 (2004-2008) :: Whining Noise - Idler Pulley Going Bad?
I noticed my engine whine more than it usual since the last few days. So, I took it to the dealership and have them check. They said that it is the idler pulley going bad. Just want to see some info on diagnosis.
View 6 RepliesFord F-150 (2004-2008) :: Battery Light On And Whining Noise From Pulleys
I have 2005 F150 XLT 5.4 litre engine and my battery light comes on after letting the truck run on idle or sometimes driving.
Last Saturday went out drove it heater on and radio on I smelled something coming from the heater kinda like burning wire smell didn't think anything of it no smoke from heater (indicating the core was bad) no lights on the cluster nothing; went into the bank let it run came back out my battery light on. Drove it home and while driving the light goes off.
Opened the hood and the smell was coming from the alternator. So I turned the truck off. Let it sit for an hour or so then I took my voltmeter to see if the battery was good. The battery was 12.4v with engine off. Checked my battery connection for corrosion or loose connections everything was tight there was some dust on the battery terminals so I brushed them off. I checked the battery cable that goes from positive to the alternator where it connects to the alternator with that nut it was good, clean and tight.
So I started the engine up and I can hear a whining noise from one of the pulleys. Let it idle for 2 minutes no battery light so I put my voltmeter on the battery it read 13.8v, so I turned on the A/C, head lights, radio and the heater tried again the voltage dropped down to 11.9v then the battery light came back on. Also through all this my battery gauge in the cluster always stays a half way mark doesn't drop or go high. Next with the engine turned off I took the belt off checked the pulleys the idler pulleys seem fine and the belt doesn't show any glazing but the alternator was hot almost like touching a hot exhaust manifold.
So for the last 3 days I have been trying to come up with how to resolve this issue obviously it could be the alternator going bad but the battery has never lost a charge yet I let the truck sit for these past 3 days and today I started the truck and it started right up I don't see any dimming lights except it has a whining noise and the battery light didn't come on immediately I let it run for 5-10 minutes before it came on; I even drove it around the block and the whining noise gets louder every time I step on the gas. To me it's either I need new alternator, tension pulley is bad or the idler pulleys are bad but they turn fine.
Ford F-150 (2004-2008) :: Whining Noise From Engine - Idler Pulley?
I noticed my engine whine more than it usual since the last few days. So, I took it to the dealership and have them check. They said that it is the idler pulley going bad.
View 4 RepliesFord F-150 (2004-2008) :: Whining Noise From The Front End When Turning To Right Or Going Straight
'05 F150 5.4 Sounds like a whining noise from the front end when turning to the right or going straight. Goes away on left turns. Thought it was tire whine but put originals back on and got same thing. 13.5x35 verses 275 Truck has a Fabtech 6" lift. Right CV axle seems tight, rotor assembly replace 2k miles ago. Any other option before going into front diff?
View 2 RepliesFord F-150 (2004-2008) :: 2006 FX4 - Whining / Humming Noise While Accelerating
I just bought a truck, it has a whining noise while accelerating, stops while letting on the gas, does not do it in neutral even if i rev up the engine. Only whines while there is some force on it, ie.. accelerating, or going up a hill at any angle, and does it from about 10-15mph- atleast 60mph.
View 2 RepliesFord F-150 (2004-2008) :: 2005 - Rear End Whining Noise Inside Cabin
I'm new here to the F-150's forum although I've owned a few since 2001. I bought this F-150 '05 5.4L Lariat. Really nice truck. But when I purchased it, it had this weird noise inside the cabin. I thought because it had a camper on it that some tranny noise was coming up thru the camper and the rear cab. After taking camper off, the noise was still there. From everything I've read online, it could be rear pinion seal, differential bearing, tranny, front hubs, etc. I have left a video. Pay close attention to the little whine. Kinda hard to hear if your not listening for it.
Note- when i drive it is most definitely coming from the middle to rear of the truck. But I'm not ruling out anything. I have looked underneath the truck and the differential is dry and the driveshaft area near diff is dry. No leaks. I have not checked fluid in diff. Is there an easy way for these trucks? I have read and heard about adding an additive? The noise starts at about 10-15 mph all the way up to 80. I've never taken it past 80 but I'm sure it's still there.
[URL] .....
Ford F-150 (2004-2008) :: Whining Noise From Front Of Engine Around Idler / Tensioner / Alternator
My 2007,4.6 is making a whinning noise from the front of the engine around the idler/tensioner/alternator. What I have read it might be a problem with the alternator getting cold, I forgot to mention it's cold up here. Fixed by changing the alternator and did the noise come back as it seems to be a design problem?
View 12 RepliesFord F-150 (2004-2008) :: 2005 FX4 - Whining Or Whirring Noise In Rear When Pushing Throttle?
I just bought a 2005 fx4 and there is a whining or whirring sound coming from the rear of the truck when I hit around 70km/h. the second i let go of the accelerator it stops.
Today when I got home after a 15 minute highway drive, i got under the truck and felt the differential area. it was warm but not hot. and there was a wet spot on it. i wiped off a drop of oil. there was also a wet spot on the bottom, seemed to be just water? I'm not sure.
Ford F-150 (2004-2008) :: Loud Whining Noise Coming From Rear Axle Housing
Some family members borrowed my truck, and when they returned I have a loud whining noise coming from the rear axle, which I have determined is a 9.75 rear. I checked oil level and it was high enough, but has a slight leak from the pinion seal. Everything feels solid but I have nothing to compare it to.
Its on a 2005 Super Cab with the 5.4L 183,000 miles. The front pinion seal was replaced in Feb 2 years ago, by the dealer's mechanic, who may have been a shade tree mechanic.
I am a Youtube Certified Mechanic, as in, I watched about 10 videos of people working on their 9.75 differentials, and realize I don't have all of the tools to do the job, such as a press, or race drivers, or the special gauge.
How many of you have tackled this issue? What did you find? What am I looking at for cost? I am on a very small budget.
Ford F-150 (2004-2008) :: 2005 - Whining Noise - Loss Of Power And Hard Shifting In The Transmission
I posted awhile back about a loss of power and hard shifting in the transmission. I thought I had it fixed, well I kind of did...... Replaced the IWE that had locked in solid. I replaced both, added some transmission fluid, new front brakes, and a new belt back in July/August. Truck was fine for a few thousand......
Well it's back. Now I have a noticeable whine in the cab. I haven't pin pointed it yet. It is only audible when the truck is running from 35-50 mph. It is not RPM dependent, it doesn't change when I take it in or out of four wheel drive. It isn't there when the truck isn't moving.
The truck has 61,000 on it. I bought it with 35,000 on it because I wanted a vehicle that wouldn't nickel and dime me. Something I could climb in and not worry about making home.
Well here I am less than 30,000 miles later and I have had issues with the fuel controller under the bed, brake calipers sticking, IWE's, new shocks, broken front coil spring, recall for the airbag, tie rods, ball joints, power window regulator, and now what appears to be a transmission.
I come from a long line of "FORD" guys, but I am seriously considering something else. This 04-08 model has to be one of the worst pickups ever built by ford.
Are the newer ones any better? Other than routine maintenance a vehicle shouldn't have to be touched before 61,000.
Ford F-150 (2004-2008) :: 2007 - High Pitch Whining Noise On Front Right Side Of Engine
My 07 SCREW 5.4L 4x4 has 77,000 miles and has a high pitch whining noise on front right side of engine. Sounds worse in the cold,increases with RPMs.
View 5 RepliesFord F-150 (2004-2008) :: 2005 - Slip Or Grinding Noise When Go Up A Hill And It Downshifts Into 3rd Gear
Ok I have been trying to find out what is going on with my truck and I cant seem to find anything on here that points to all the symptoms I am having. I have a 05 xlt 4x4 with 5.4. For the last 5 months or so I have been noticing a slip or grinding noise when I go up a hill and it downshifts into I believe 3rd gear. It sounds like going over rumble strips on the road but only lasts a second. It also does it sometimes when I pull out from a stop.Also when I let off gas or brake to a stop it seems to shudder a bit.
Maybe its my imagination since I keep hearing for the grinding sound, I don't know anymore.Its driving me nuts(er). It doesn't do it all the time either.It has only 65,000 miles on it and never towed. I know I am due for a total tranny flush since it never had one. Could this be the whole problem? Iv been reading other stories that sound close to mine but they never mentioned about the noise when pulling out. Could it be the rear end? I am totally lost on this one.Other then that problem it runs great. Shifts nice.
Ford F-150 (2004-2008) :: Factory Gears Whining At 45 MPH
It has been a long time since I have owned a Ford truck and recently got a good deal on a 2004 Reg. Cab 4x4 (4.6L). It only has 58K miles and still looks, drives and smells like new. I have just noticed that the Rear end gears whine very loudly at 45 mph. It is quite everywhere else accept a little hum at 60mph. No other issues with the truck and perhaps, this is just normal on these newer fords.
View 7 RepliesFord F-150 (2004-2008) :: Rear End Whining And Clunking
05 F150 2WD 4.6 LWB, The rear end whines when letting off the gas and makes a clunk or 2 when taking off and a clunk when I stop. It has 277.000 Miles? Or is it just time for another rear end...
View 3 RepliesFord F-150 (2004-2008) :: Whining Sound When Real Cold Outside?
When my truck sits all day and its cold out, my truck in 2WD will make a whining sound going down the road, sometimes its a grinding sound almost. Appears to be coming from the passenger side of the truck towards the front. Engaging 4x4 gets rid of the noise, and the noise will usually disappear after the truck has been running and warmed up. I've changed my ball joints recently and everything looked good and yes it had done it a time or two before hand. What causes this, and how do I fix it?
View 6 RepliesGolf/GTI VI :: Faint Whining Noise In 2nd Gear Below 2K RPM
I've had my car for less than a week and have noticed something, I want to check with you all here to see if it is common or not.
When in 2nd gear with my foot off the gas between 1-2K RPM, I hear a faint whining sound that gets lower in pitch as the RPMs drop. An example of when this would happen is if I were coming up to a stop sign in a residential area in 2nd gear, coasting to the stop sign. The sound starts a little under 2K RPM.
I don't remember hearing this in 3rd gear and I haven't tried in 1st.
Ford - Explorer :: 2004 - Vehicle Stopped Moving / Sounds Like Torque Converter Whining And Will Not Drive In Any Gear Or 4WD
I have a 2004 Explorer 4.0L with 190,000 miles. My wife was driving it and the vehicle stopped moving. Sounds like the torque converter whining and will not drive in any gear or 4wd.
View 1 RepliesFord F-150 (2004-2008) :: Whining Sound Coming From Transmission Or Somewhere Else In Drivetrain
2008 F150 HD Payload package with 5.4L and 4spd auto, 61,000 miles.
Recently developed a whining sound coming from the transmission or somewhere else in the drivetrain. Does not sound like rear axle because it changes pitch with the change of gears. I proved this by disengaging OD while driving and the whine was higher pitched once the transmission down shifted. I did some other research and found a reference to the #9 bearing going bad in a 4R75 trasnmission in a Crown Victoria. I am going to fight for any repair to be covered by the powertrain warranty even though it just clicked 61,000. The dealer has done ALL maintenance on this truck since it was new (following severe duty recommendations).
Ford F-150 (2004-2008) :: 2005 - Whining While Driving Down The Road Or Sitting Still
My F150 has started whining while driving down the road or sitting still. It gets louder as the RPMs increase. I have also noticed that the transmission has started taking longer / slipping going into 2nd gear. I also smelled the transmission fluid and it has an "odd" odor to it. Could the transmission going out cause this noise?
Here is a vid of the noise : 05 f150 - YouTube....