Ford Exhaust System :: Exhaust Pipe Cut Just Behind The Rear Of Cab - No Muffler
i have my 4 inch exhaust pipe cut just behind the rear of the cab right now with no muffler. If i cut it further up maybe jsut under the front seat or so what would this to the sound? would it make it deeper or louder?
View 7 RepliesFord Exhaust System :: Side Exhaust With No Muffler?
I own a 2005 F350 Diesel and I want to remove my stock exhaust and run a side exhaust with no muffler. Has any Diesel owners out there run a side exhaust system?
View 14 RepliesFord Exhaust System :: Position Of Muffler In The System Affect Performance?
Was just mulling over redoing part of the exhaust system on my truck. As it stands the original y-pipe is still intact but some bozo reduced the rest of the system down to 2.25 inch with an ancient glasspack for a muffler. Maybe he thought it would net some kind of benefit, maybe he was just throwing together parts from his backyard. Either way it's going, I'm planning to keep the Y-pipe but step it up to 3 inch with a Flowmaster chambered muffler and I just suddenly wondered if the position of the muffler in the system affects performance. If I put it directly after the Y-pipe the exhaust pulses would hit it sooner...
View 14 RepliesFord Exhaust System :: Should Get Rid Of Muffler Or Cat?
i plan on getting rid of either the cat or the muffler probly in about a week...which one would be better to lose?
i dont care about the sound cause either way i go if i keep one it shouldnt get much louder right and either one will increase power/torque... im wondering which one bill better my mpgs the most im leaning towards muffler it will be easier and more legal...then again my truck already passed inspection
Ford Exhaust System :: Drain Hole In New Muffler?
I just got a Walker SoundFX muffler and there is no drain hole for condensation. Should I make one?
View 3 RepliesGolf IV R32 :: Exhaust System - Clamp Connecting Resonator And Catalytic Converter Leaking Around The Edges
The clamp connecting the resonator and the catalytic converter is leaking around the edges. I changed the bolts and tightened the clamp but still leaking.
View 24 RepliesFord Exhaust System :: Loud Pop While Cruising At 60 Mph - Muffler Blowout And Rough Engine
Yesterday, I heard a loud "pop" while cruising at 60mph. Pull into a rest stop and and discovered a hole in the muffler. The engine now idled roughly, but seem to smooth out about 2000 rpm.
Question for the experts: can the loss of a muffler cause the engine to run rough? It's a 460cid in a '77 F350.
Ford Exhaust System :: 1994 F250 - Replacing Exhaust?
I have been thinking about toying with my exhaust. I don't have a crazy amount of money. I got a 94 F250 with the 5.8 liter 351. Heres what I was thinking. Get rid of everything after the cat, and then run a single 3 inch pipe from the cat to a flowmaster 40 series, and then exit either right before the back tire or right after it.
View 7 RepliesFord - Taurus :: 1993 - Exhaust Clamp Between Resonator And Exhaust Pipe Came Off
I have a 93 ford taurus 3.8L V6 automatic GL. The exhaust clamp between the resonator and exhaust pipe came off and I need to know what size clamp I will need to replace it. I think it is a 2 inch but I am not sure.
View 1 RepliesFord Exhaust System :: Removing Cats - O2 Sensor Will Be Effected?
I am getting my truck back today after all the work that has been done to it over the past 3 weeks, and well, I have always wanted to gut my cats, but have been worried to waste the cats buy gutting them and didnt want to cause a disturbence in the airflow by gutting them, so i figured atleast if i was aching to be illegal and gut them, the least i could do is just remove them, but my question is, will it mess the o2 sensors up? Currently the o2 sensors arnt connected to the cats at all, so my feelings is it wouldn't mess with the truck or would it? I was thinking of just removing the two cats in the true dual, and replacing the segments with pieces of pipe, would that be sufficient?
View 12 RepliesFord Super Duty (1999-2016) :: 2003 - Muffler Delete On Stock Exhaust Sound?
How will a muffler delete on stock exhaust sound? I don't want to remove the cat because I don't want it to be too loud. I want it to sound good but not too much whistle (considering my truck is a 2003 the whistle would be very loud) Should I just to a delete pipe on the stock exhaust, or do a cat-back 4 inch straight pipe? what will sound better? Also doing the cat back exhaust will cost a lot more.. but is it worth it? What I should do.
View 4 RepliesFord Exhaust System :: 2003 V10 - Running Little Bit Rough / Exhaust Leak?
I just purchased a 2003 V10 with 270 000kms. The truck had had regular maintenance. It has an exhaust leak and runs a little bit rough. Could the exhaust leak cause the truck to run a little rough or am I dealing with another issue?
View 2 RepliesFord F-150 - 1997-2003 :: Replaced IAC But Still Shaking - Replacing Exhaust Manifolds?
So i replaced my IAC(Idle Air Control) Valve and the idiling is much better! However my shaking/jerking has not stopped. I have found the problem which is the exhaust manifolds! I was wondering if when i replace them which i am probably going to get headers should i use metal gaskets?
View 14 RepliesGolf V R32 :: Exhaust Suddenly Got Super Loud / Broken Resonator
Was driving to work this morning and my exhaust suddenly got super loud. I did not hit anything. I was cruising through the interstate. Took the car to the dealer to find out my resonator is broken. I have a GHL exhaust. Why would this happen?
View 24 RepliesPrius (Gen 2) :: Exhaust Louder - Water Drip Out From Engine Side Of Resonator
Noticed a louder sound to my exhaust. Cuts out when ice shuts off. Haven't got a good look at the whole exhaust system from underneath but did see water drip out from the engine side of the resonator when the car was warming up. The sound is coming from about midpoint between the taiI pipe and the engine. I suspect the weld at the resonator junction is breaking. Is this common? 2008, Canada, 130000 km.
View 7 RepliesElantra MD (2010-15) :: Rattle In The Undercarriage - Exhaust Resonator Pipe Replacement?
I had my E in for service today to get her fluids changed and to replace her engine oil with Synthetic finally (second service for her).
I had noticed a rattle in the undercarriage for a few weeks now and assumed it was a common TSB for a heat shield that rattles. As it turns out, it is the resonator pipe that needs to be replaced (under warranty). I've never had to replace one before so hopefully it's just a one-off!
Otherwise, I can already tell she's happy to be filled with some wonderful Synthetic...
Ford Exhaust :: 2006 - Delete Cat Or Muffler?
I've got a 2006 6.0 350 with stock exhaust and am wanting to either delete the cat or the muffler, but not both. I'm curious how each would sound? For example, would deleting the cat make it louder than deleting the muffler, or will one make the turbo whine more audible than the other? Also, is there any benefit to deleting one over the other, performance wise? Oh, I'm not really looking for loud and obnoxious, but more turbo whine wouldn't be too bad .
View 2 RepliesFord Exhaust :: 1994 F150 - Huge Stock Muffler Cut Off
I have a 94 f150 with the 351 and i was wondering how loud it would be with that huge stock muffler cut off and jsut the two cats still in place. I heard the cats will still quite it down a little bit cuz I don't want anything obnoxiously loud...
View 1 RepliesFord Exhaust :: 2008 F250 - Replacing Exhaust Manifolds
replacing exhaust manifolds on my 2008 f250 super duty got a broken stud on right front top tried to drill it out but there's no room somebody said to weld a nut to the broken stud but if I do this will the weld mess up the aluminum head.
View 1 Replies