Ford Excursion :: Won't Start Intermittently?
So yesterday I got off the interstate and stopped to get lunch. When I came back out to start the X all I got was a cranking engine but no fire. After two passes I got out and lifted the hood to take a look...everything looked normal. Got back in and cranked it again for 20 seconds or so and it fired up. Today it works fine. Fires up on first crank.
New battery. Starter engaged. No engine warning lights showing. Did fill up tank and add a quart of oil before I started and drove about two hours. Anything like vapor lock possible with fuel injection?
Ford Excursion :: A/C Shuts Off Intermittently?
We are having an air conditioning issue with our '03 6.0 Excursion so...
Since about 60,000 miles our air conditioner will Intermittently shut off (meaning the actual head or face unit in the dash is or does not have any power to it). Yes...I have checked fuses, and the possibility of any disconnected wiring and have found no issues. It will eventually just start working again without fail. (Note: Of course this only happens when we are in extreme weather conditions = River/Desert 110+)
Recently it stopped working - after an air conditioning service (recharge) so I took it back to the dealer in Arizona that performed the service. The advisor told me (without checking with a tech) that it was most likely a "head unit" that was out and it would cost about 1000.00 to replace. He also stated that he "sees this alot" and that they have replaced many.
Ford Excursion :: A/C Clutch Cycles Intermittently?
The clutch is on 2 seconds and off 2 seconds, and there is a click up on top that clicks every 2 seconds ?..........no cold air either.
View 12 RepliesFord Excursion :: 2001 - Intermittently Shaking At 45-50 Mph?
I have a 2001 5.4L excursion that intermittently shakes (feels like rumble strips/rough pavement) usually at 45-50 mph when the rpms are between 1500-2000. Increasing or decreasing rpms stopps the shaking. What could this be? I'm trying to figure out how much I might have to pay for repairs (pretty sure I'm not up to diying this one) without an expensive estimate.
View 9 RepliesFord Excursion :: 2000 - ABS Light On And Off Intermittently?
I have a 2000 with the v10 4x4 with 130,000 miles problem started one day when putting on brakes the peddle felt like it pulsated a little like the abs had activated, then a couple of minutes later the light came on. Did not do again and the light went off, started doing it on and off every so often same thing. Took to private machenic he checked all the brakes and found the pins froze up on one in the back and one in the front. Took home did it again, took back he ran codes and found the vss coded changed it did it again before I got home.
Took back drove mechenic around with scanner hooked up did it again and showed code for vss. Got on here did search and could not find anything that really matched what I have happening. Seen several threads about the cops causing this but when it happens to me I dont lose my speedo or gauges only the abs light comes on and then after a while goes off. Now the light is coming on sometimes without hitting the brakes. The only other thing the mechenic said when we drove around was that the front wheel sensors one was reading a couple of mph faster than the other one untill you hit 20mph than they both read the same. going back to shop Wednesday but we dont have a clue where to go next.
Ford Excursion :: Battery Light Came On Intermittently
Came on intermittently other day, got it home then did not start. Charged for a bit, it started on the charger then off the charger a few times I assumed out was the alternator just replaced it. Battery light now on continually, hope I didn't destroy two batteries driving out for 20 mom after light first illuminated, they already to be only one year old. In addition to the ABS light now and the brakes feel unboosted? Hopefully fuses popped?
View 2 RepliesFord Excursion :: OD Light Flashes - CEL Comes On Intermittently?
Pulled the codes and erased them a few days ago for the first time and now it's about a once a day thing. I can drive for 2-3 stops and then I come out of a place, get in the truck, and when I start it up I have the light and the OD flashing.
View 14 RepliesFord Excursion :: Smell From Vents Intermittently?
Been noticing this lately. Kinda smells like coolant I think but it's intermittent and for a short period of time. Notice it more when turning the heater on or when setting the temp to a higher setting.
Havent noticed any leaks on the carpet. Heater core? Why intermittent?
Ford Excursion :: Cruise Control Not Working Intermittently?
I had had intermittent issues with the cruise control not working in my excursion. most of the time it was fine though. after a recent 150 mile trip it stopped working half way through. i didnt worry about it too much..got back into town and checked under the hood. i found brake fluid running down the inner fender well! all over everything under the master cylinder. finally tracked it down to the cruise control switch on the master cylinder leaking. I pulled the plug apart and it was full of brake fluid.
Meanwhile the master cylinder was about half full, so i replaced it with the same switch out of a '96 parts explorer which is the same part luckily. also yes i have had the cruise control recall done. So if you have lost CC and you have a leak replace the switch! seems it can leak..and at a pretty good rate..alittle scary! glad i figured it out before my 800+ mile trip later this week/weekend.
Ford Excursion :: Parking Brake Light On Intermittently?
I've been having a problem lately where I'm driving down the road and the brake light comes on and starts binging. I stop push the parking brake and release it a few times, then the light goes out and I'm on my way. Sometimes when I first release it the light doesn't extinguish and sometimes it is never on. I'm guessing there is a switch somewhere for the parking brake that isn't working so great. Is it around the pedal or somewhere in the brakes themselves? Is this a typical problem?
View 14 RepliesFord Excursion :: 2000 - High Idle Intermittently?
I have a 2000 X V10 and am having an intermittent high idle condition. I have searched the forums and found some useful info but nothing that addresses this issue. Here's what I've done. New IAC, found PCV valve hose leaking-replaced also new valve, found another vacuum leak-repaired, tested TPS and that was fine according to the specs I found. So here's my problem-upon starting engine occasionally "stumbles" then roars to life idles 8-1100rpm. Drives well till stopping at an intersection and idles 1100-1200 rpm.(lots of brake) Can pull into parking spot place in park and will idle up 1500-1800 rpm and then only drop to 1200 or so. I have checked everything I know. ALL these idle conditions are INTERMITTENT. (and yes I did check for codes "0" ) There is no loss of power.
View 8 RepliesFord Excursion :: 6 Disc Stereo Works Intermittently?
Cuz then there wouldn't be nothing wrong with my radio. So my factory 6 disc stereo has been giving me guff. Sometimes when I start my X it comes on normally and other times it puts out no sounds. Like the display is working just fine and i can turn the volume up and down and see the bars move across the display like the volume is changing but there's no actual volume from the speakers. Sometimes I never get output from the speakers for my entire 30 minute drive and other times it may just instantly without warning start playing over the speakers.
When it's not working changing stations or changing to cd/dvd doesn't fix it. It's completely random? I've been searching the net for issues like this and I've found a Taurus forum and a poster had the same issue with his factory Taurus stereo. He replace the RCM, which I assume is a radio control module, and it fixed the issue. Does the excursion have an RCM?
Ford Excursion :: 2002 - Cruise Control Would Come On Intermittently
2002 Ford Excursion cruise control inoperable. Problem began when cruise would come on intermittently. I would push the on button then set, at which point the green cruise icon light would either come on and the cruise would set or she would flash and not set. Sometimes holding the switch down worked, other times not. Now no matter what I do the cruise will not engage.
I have had the recall done for the cruise control by the dealership.
I have checked the fuse on the recall module, the 2.5 is in good shape and not blown.
I also found this guide to a self test (copied below). I used the test, turning the key on with the off button depressed yields a green speed icon light. Letting go and pressing on yields a green flash as well. But when I move on to pressing resume I get no lights at all, same if I continue through the other switches, no more lights.
Here is the self test guide -
*cruise control self test
Enter self-test diagnostics by depressing the speed control OFF switch while turning the ignition key ON, making sure the engine does not start and is not running. The speed control indicator on the instrument panel will flash once to indicate that speed control module entered the diagnostic mode. Five additional flashes at this point indicate a defective speed control servo.
Release the OFF switch.
Press the remaining switches in this sequence: ON, RESUME, COAST and SET/ACCEL. If the ON switch is not depressed within five seconds after entering the diagnostics mode, the module times out and the procedure must be started over.
The speed control indicator lamp will flash as each switch is depressed. Press each switch in the sequence immediately after the indicator light goes out for the previous switch. NOTE: There will be a slight delay when the last button is pressed and the lamp flashes.
A lamp flash with the last button (SET/ACCEL) indicates that the static test passed. If the lamp does not flash with the last button and there are no additional flashes of the lamp, the switch is defective. If the lamp does not flash with the last button, and additional flashes occur, follow the chart below for trouble codes:
2 flashes - BPP defective, circuit is defective, brake applied, CPP switch or jumper (if equipped).
3 flashes - deactivator switch is open or circuit defective.
4 flashes - vehicle speed signal is out of range or circuit is defective.
Immediately (.25 second delay) after the static test, the speed control servo does a dynamic test by automatically actuating the throttle lever from 8 mm (0.315 in) to 12 mm (0.472 in) of travel from the idle position. During the dynamic throttle pull, observe throttle movement to witness any binding or sticking of the speed control cable and correct connection of speed control cable to throttle lever. Make sure the throttle returns to the idle position.
Ford Excursion :: Clunk Sound From The Back Of Vehicle Intermittently
Went for a drive last night in my "new" 2002, 4wd and which brought up some newbe excursion owner questions. First of all it has 95,000 miles on it and it is a V10. I noticed a clunk sound from the back of vehicle intermittently. u joints?, rear springs? or rear end?
Noticed that the front springs looked like they were sagging, is this normal or do I have an excuse to lift it? Also the shocks appear to be the original units and I figure that they are going to be on their way out. In the past I had good results with KYB gas-a just on a old F250 2wd.
Ford Excursion :: Interior Lights Just Started Staying On Intermittently
My interior lights just started staying on intermittently. Seems like the front passenger door. I'll have to pull the panel and lube the switch.
View 7 RepliesFord Excursion :: 2002 - Battery Light Keeps Coming Intermittently?
My battery light keeps coming on and off, batteries were replaced by the dealer and checked out good at advanced auto parts.
2002 Limited 7.3L
Ford Excursion :: 2000 - A/C Blows Out Of Defroster Vents Intermittently?
Today im driving along in my 2000 X v-10 limited and had the AC blowing on high. All of a sudden it started to blow out the defroster vents, then back to the correct dash vents, then back and forth intermittently.....No vacuum leaks that I could find.. Is that controls what vent doors open to control air flow?
View 14 RepliesFord Excursion :: 2003 - Battery Light On Intermittently - Test?
My battery light is coming on intermittently but the truck seems to be running fine need to know how to test it to make sure that is the problem.
View 9 RepliesFord Excursion :: 2003 2WD - Cruise Control Working Intermittently
2003 X limited 2wd 6.0L ... My cruise control was working intermittently. Could it be the buttons on the steering wheel itself? there is a cluster that I see. Does it pop off to expose the connectors/switches? Can these go bad? Can I buy new switches for the steering wheel?
View 2 Replies