Ford Excursion :: Building A Custom Roof Rack - Where To Mount It
I've seen a lot of off road racks mounted into rain gutters or the side of jeeps and whatnot, but can I just use the factory rails? Which way is better? The idea would be to remove the factory cross bars, and saddle up the custom rack in the rails that came with the vehicle.
Also, as far as weight is concerned the rack is going to be about 112" x 52" with a custom light bar in the front. The rack itself is going to weigh about 120-160 lbs. 1" square aluminum tubing., with 1 and 1/4 inch base, about 16-18" tall in the back, 10" in the front
I would like to be able to use a ladder and get up on it myself (200lbs), but I have a feeling this might be too much weight. me+sparetire+rack = fail?????
I know the rack itself can handle it I can jump up and down on it on the floor, but x roof is going to hold up or buckle?
Tiguan :: How To Remove Roof Rails
How to remove the roof rails? I'm planning on doing a Vinyl roof so need to get these things off!
View 3 RepliesSanta Fe (CM - 2007-12) :: Roof Rails Becoming Quite Loose
I have a 2007 Santa Fe CRD+ with integrated roof rails and roof rack. The roof rails have started to come quite loose - is there a simple way to tighten them? Or is this a main dealer job? I am worried about damaging the trim and there are no obvious bolts, screws etc to be seen
View 1 RepliesTouareg :: 2012 - How To Remove Roof Rails
I have a 2012 Touareg TDI Exec. I have paint damage on the roof and need to remove the roof rails. I can't see any obvious exposed bolts. How to remove the rails?
View 2 RepliesFord Aerostar :: 1991 - How To Remove Roof Rack
How to remove roof rack on 91 Aerostar? Google and search box here yielded no result so a new thread is likely in order. I have leaky roof. Not windows.
View 8 RepliesTouareg :: Broken Roof Rack?
I have a new question regarding my Touareg. Recently my roof rack broke, a latch on one side of one of the crossbars broke almost off. The part that the key goes into and pulls away to release its hold to the roof was broken when trying to force it closed after adjusting the rack's position. Can this piece be replaced or does the rack have to be replaced?
View 6 RepliesGolf/GTI VI :: Roof Rack Have Scratches And Outlines
I've been using roof racks for years and despite the towers being padded, I always end up with some scratches and or 'outlines' of the tower pad left behind. On my new car I wanted to avoid this so I made up some pads from paint protection film. They're practically invisible when the rack is off the car. I was really happy with the way they turned out so I'm thinking of producing them in quantity but would like some feedback first. I use a Yak rack but the pads would be made large enough to accommodate just about any of the popular roof systems available.
View 8 RepliesTouareg :: Roof Rack Locked - How To Unlock
I bought my treg a couple of months ago and it came with the stock roof rack. I never thought anything of it, since I barely use it. But the other day I wanted to see what it looks like if i separated the rack. It looks like it takes a key to unlock it, i thought it was the cars ignition key but it's not. How I could unlock it or get a key to do this?
View 4 RepliesGolf/GTI VI :: Wind Noise From Roof Rack
Would a Yakima 44" Fairing fit on the OEM roof rack? And are there any simple mods to get rid of the wind noise from the roof rack?
View 1 RepliesTouareg :: After Mounting Roof Rack Loud Sound Coming
In preparing for my end of lease inspection, I mounted my '04 roof racks back on my Treg, and a few days later, I noticed this very loud hmmm/vibration, sounding almost like a steady fog horn, coming from behind me. It lasted about ten seconds, and at first, all I could think of was "that is not us! Until a few minutes later, when it recurred, and I realized that it was probably going to be speed dependent. I eventually realized that the one thing that was different since the prior week was that I put the racks back on the car. When I installed them, I dropped them into their recessed slots, and slid them back to the rear, where I think they are supposed to make the least noise.
Well, not anymore. I think I have to either slide one forward, say to the next detent in the tracks, or get the dealer to back the X3 up better. I think I will slide the forward rack up some, or take them both out for the last month of the lease.
Touareg :: Sudden Vibration From Roof Rack When Driving On Highway
Driving my V10 at around 140 km/hr (87 mph) along the highway and passing a truck (in a tunnel), all of a sudden there was a violent vibration from the roof rack. It seems like it went into its resonance frequency because as soon as I slowed down it went away, and didn't reappear again.
View 2 RepliesLexus RX 2004-09 :: How To Remove Roof Rack Cross Bars
How to remove roofrack cross bars? Pix would be nice...
View 14 RepliesTouareg :: Vibration Coming From Roof Rack Or Rear Of Vehicle?
Vibration coming from either the roof rack or rear of the vehicle? I seem to get it in cold weather sometimes or when I accelerate from between 40 and about 60 mph. I have checked to see if the roof rack needs tightening but it looks good. Of course, every time I bring in for service, guess what, they cannot replicate the sound.
View 8 RepliesLexus GX 2004-09 :: Roof Rack Bar Snapped On The Rear Passenger Side
I have a 2004 GX470 and when driving on the freeway, the OEM roof rack bar snapped on the rear passenger side . [URL]......
View 5 RepliesFord Excursion :: Light Rust On Frame Rails And Hitch Receiver
I've never used a rust converter, so I have no experience and wanted to hear from those who have. I've got some light rust on the frame rails and the hitch receiver. What product would you recommend, or do these products work well enough to consider? According to all of the websites, they all work miracles...
View 3 RepliesPrius (2010-12) :: Removing Roof Antenna?
I'm going to wrap my roof but I dont know how to remove the roof antenna. Is there a write up somewhere?
View 1 RepliesFord Excursion :: Rusting Roof - Solution?
Looking for any creative solution for roof rusting that does not involve a major body shop repair and paint job. I was wondering if it could be chemically neutralized and then covered (sealed) with something like Line X?
View 9 RepliesFord Excursion :: Roof Vents Falling Out?
How to keep roof vents from falling out? I had one that was falling out in 3rd row for quite a while which did not bother me to much but today had 1 on passenger 2rd fall & hit my mother. So my question is what can I do to keep them in? It's like PO wrecked all of them he was very messing owner I'm still finding pop in spots on the headliner.
View 10 RepliesFord Excursion :: 2004 - Roof Paint Cracking And Lifting
I happened to look at the top of my 04 Excursion yesterday and found the paint cracking and lifting off the roof. So the first thing I did was to come look here and see if it was a common issue. I searched and found a couple threads about this issue from 2 and 4 years ago.
Apparently, the paint was applied too thick and that is why it cracks, lifts and breaks off. Some said they went to ford and ford has offered some type of discount on the repair.
But, that was years ago and I'm not sure if I think that ford is liable to fix this on an 8 year old vehicle.
I uploaded a couple pictures of the sots : Roof Paint Cracking - Picture