Ford Excursion :: Coolant Dripping Off Of The Power Steering Pump
6L Turbo Diesel .... I still have this returning oil drop on the oil pressure regulator. That fluid does seem to be oil.
Now I found what appears to be coolant dripping off the power steering pump. I have had to add a small amount of coolant every week...not much but definitely noticeable.
I have a new OPR which I will replace. These pics are from looking up at the mail pulley and to the left (power steering)..
Ford Excursion :: Steering Loose While Cruising Then Feels Tight When Straighten Out After A Turn
The steering on my Ex isn't working like it should. At times it feels loose when cruising then feels tight when straightening back out after a turn... the wander is really bad...
My PS fluid is also turning into a muddy brown goo every 5k... I changed the PS pump this summer with a supposedly good used one...
What should I be looking at/checking for?
Golf/GTI VI :: 2013 - Steering Feels Sticky If Stop For About Five Seconds
I have a 2013 GTI (which I love) however the steering feels like it sticks very slightly. If I hold the wheel on center then apply a little pressure to turn if pops off center about 1/8 of inch and then moves fine. As long as I keep moving it, its fine. If I stop for about five seconds it sticks again. This really faint but annoying. It reminds me of an old recirculating ball steering system where the wheel had slop in it.
View 4 RepliesFord Super Duty (1999-2016) :: 2001 F250 - Power Steering Fluid Leaking From Lower Portion Of Gearbox
OK so my 2001 F250 was leaking power steering fluid from the lower portion of the gearbox (where the pitman arm attaches).
I found a thread on this forum where it showed how you could change the seals out WITHOUT taking the gearbox out.
So I got the pitman arm off with a heavy duty puller. Then I scraped out the 1st rubber seal hoping to reveal a snap ring behind it. Well, the seal is 99% scraped off, but there is not evidence of a snap ring. It does seem like there is some metallic ring holding another rubber seal in behind it. But again, I can't find the little open spots that you put your snap ring pliers in to get snap rings out.
How do I get this metallic thingy out???? I already broke a small drill bit trying to drill it out. It just doesn't seem like the best way to go about it.
Lexus LS 2007+ :: Power Steering Feels Hard On LS460
I have purchased LS 460, 2010 with 21000 miles on it. Dealer said he put new Kumho tires on it. But the power steering feels hard, and is not even as soft as my Honda Pilot 2009. I have made an appointment with Lexus dealership for this concern ( I had the vehicle checked by Lexus store before purchasing.) I have read good reviews about Michelin tires, am wondering perhaps I need better quality tires. Do not know what the dealer is going to recommend.
View 3 RepliesVenture :: 2004 - Power Steering Feels Tight / Fuel Level Is Good
I have a 2004 Venture where the power steering feels tight. Fluid level is good. No leaks (had it repaired a year ago where line was leaking, and now repaired).
Turning the wheel under most circumstances feels pretty normal. However, say, doing parking maneuvers SOMETIMES feels like I have non-power steering for maybe a quarter turn, and then it picks up again.
Sonata I45 (YF - 2011+) :: Little Knock In Gearbox Handle When Brake And Stop The Car
I'm new member and recently have bought 2011 sonata YF. I feel a little knock in gearbox handle when I brake and stop the car ( in D mode), and knock again when i release brake pedal. This knock can't be heard and just feel by hand. is it normal or failure?
View 2 RepliesChevrolet - 2500 :: 2006 - Leaking Steering Gearbox
I have a 2006 Chevy 2500 with a leaking steering gearbox. It is leaking where the steering column goes into it. What do I have to do to repair this problem?
View 7 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Power Steering Pump Replacement
When replacing the power steering pump on my 2006 should I go OEM on the pump or save some money and get a Napa or aftermarket remaned unit with the pulley installed? Also, whar is the fluid capacity of the power steering system?
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Replace Power Steering Pump?
So, I'm replacing the Steering Box today and read an article that said you should replace the pump at the same time. what do you all think?? I have clear access to it now and they are not all that expensive?? Or are the ford one's bullet proof and leave it alone???
I don't have any leaks and it feels ok I guess..just pushing close to 200K on it.
Ford 7.3L Power Stroke (1999-2003) :: Power Steering Loss Intermittent - New Pump?
I have a 2000 Excursion. This weekend, I noticed some intermittent failure of the power steering where it seemed like the pump was not engaging and then would all of the sudden. Deciding to try to head off a failure, I got a reman unit from Oreilly and installed it this morning. It was fine when I tested, had good brakes and went locked to lock quietly without fuss. Let the house and within a mile, I lost steering and brake assist. I stopped and turned around, but what I am noticing is that at idle, I have no power steering, but when the RPM's are up, I do.
View 3 RepliesFord 6.0L Power Stroke Diesel :: Coolant Leak / Drips Off The Power Steering Pump
I am having a heck of a time finding this coolant leak. It drips off the power steering pump. I replaced the upper radiator hose and the heater "y" hose that goes to the bottom of the Degas bottle. I recently replaced the lower radiator hose as well. So the truck runs normal. When the system is under pressure I do not see any leaks. But after the engine is completely cold it starts leaking a small puddle of coolant. Its appears to be coming from the power steering pump. But I am sure its something above or near it. This is on my 2005 Excursion with a 6.0. Can the water pump be going bad and leaking this direction. I would expect a water pump to leak straight down the middle of the engine. What to look for? The thermostat seal stays dry. but it has to be in that area. What is really messing with me is. When it is hot and pressured up It does not seem to leak. Only after it has been sitting for hours and cools off..........What the heck!
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Power Steering Pump Camp Keeps Coming Off
My power steering pump camp keeps coming off. Almost like it's got too much pressure. I'm stumped as to why but it makes a mess whenever it comes off.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Power Steering Pump Making A Loud Whining Sound
My power steering pump was making a loud whining sound. No problem, changed the pump. Now after the truck is started I will have no power steering or brake assist, give the truck a little gas and you can hear the power steering pump "start". I have tried every way to get the air out, or is that not the problem. I even lifted the front of the truck off the ground with a forklift and with the truck off turned the wheel about six times stop to stop. Fluid level looks good and has since adding after the change.
View 4 RepliesFord 7.3L Power Stroke (1999-2003) :: Replaced Power Steering Pump / Gear Box Still PS Bleeds?
I just replaced my power steering pump and gear box and I flushed the system until the fluid came out good. I have done the whole lock to lock and pump the brakes but nothing is getting better.
View 3 RepliesFord 7.3L Power Stroke (1999-2003) :: Hose Seal Leaking At Power Steering Pump
Looking for a write-up on replacing the seals on the hose that leaks at the power steering pump? I replace them once but may of over tightened them. I pour in atf and see it dripping on drivers side of power steering pump. Can I just use regular o rings?
View 5 RepliesFord 7.3L Power Stroke (1999-2003) :: Lost Power Steering And Brakes / Pump Started Growling
Driving home from movies tonight, I lost power steering and power brakes and the pump started growling. Looked in the reservoir and it was all foamed up. Within the last 20k mi I have flushed the system and refilled with power steering fluid. No apparent leaks at this time. And happened like someone flipped a switch. Fine one turn, nothing the next. What are the chances this is a fluid issue and not a mechanical one? Start with flushing system and adding Mercon V? Or is it likely pump is damaged?
View 7 RepliesFord Excursion :: 2001 - No Power To Windshield Washer Pump?
2001 XLT V10 4x4 Excursion
If I push button for windshield washer the wipers come on but no fluid sprays on windshield. Same with rear....wiper comes on but no spray.
Jumped washer pump directly from battery and pump comes on and water squirted on windshield.
Had kids push washer button while I held volt meter on washer pump power and ground wires.....Nothing 0.0 volts at pump, but wipers came on.
All fuses are new, is there a relay? I did swap them around with no change.
Phaeton :: 2003 - Gearbox Malfunction - OK Button Won't Work On Steering Wheel - TPMS System Not Working
I just bought a 2003 W12 Phaeton with 55.000 km on the clock and a few problems that were knocked off the price.
The car is absolutely fantastic, so much better than my previous 4.2 A8, although I bought with a gearbox problem that dropped the price down to USD 8.000.
The gearbox issue is that it jumps from 1st to 2nd gear with a 'clock' and much harder when the other way around (2nd to 1st). Sometimes so hard that it automatically engages the "safe mode" with the yellow PRNDS sign on the screen. Once on 2nd gear and up, it runs smoothly.
My plan is to take the gearbox off the car and bring it to an expert mechanic on ZF gearboxes, as the VW dealer quotes USD 9.000 for a new gearbox.
Re the other issues, I have plugged in the VCDS after changing both batteries (a standard 90 Ah on the right, a VARTA G14 95 Ah on the left) which show many faults that I can't really identify. The problem I have noticed is that one button on the steering (the OK push button on the right) does not work and when it is pushed, the cruise is deactivated (?). Looks like this module will need to be replaced (VCDS says 'control module defective').
The other issue I have noticed is that the TPMS system doesn't work. On the screen it shows clocks on each wheel... and nothing happens. I guess it's the batteries of the sensors, so I am thinking of replacing them. Would this solve the problem?
I just realized that I did my last VAG-COM check before clearing previous DTCs, so I will do that now and come back to post it.