Ford Excursion :: Stock Front Spring Hanger Length
Measuring the stock suspension length from bolt hole to bolt hole for me? I want to lift the front of my 05 an inch or two with longer hangers and just want to make sure the ones I have now are stock length.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Coolant Leak / Dripping Down Onto Passenger Side Front Leaf Spring
2003 F250 7.3... I noticed a water leak dripping down onto passenger side front leaf spring. I saw this before but attributed it to the AC (which kicks butt) but haven't used the AC. No scent to the clear fluid, temps all look good. Running fine. Where does the AC discharge go? Could AC be on (not on AC but set in blue zone on dial)? Reservoir looks ok but could e small volume of drips.
View 12 RepliesFord Excursion :: After Standard Brake Line Replacement Fluid Leaking On Passenger Side Fitting?
So I had a stuck caliper on the driver rear side. I pushed the piston back and checked everything to make sure all was in working order. After some though and reading about the calipers getting stuck which old brake lines, I decided to upgrade the line with the Russell stainless steal lines.
I got all the lines put in but I seem to have fluid leaking on the passenger side fitting which I can't seem to get to stop. I put the old line back in but it is still leaking. I am not sure what I need to do or check to get it to stop. It seems to be leaking from the thread area. I checked the fittings and they don't look cross threaded so I don't understand why it may be happening.
Ford Excursion :: Coolant Leaking Above Passenger Rear Tire
I'm 650 miles from home in WV and the truck overheated and I saw coolant leaking from the area above the passenger side rear tire.
View 9 RepliesFord Excursion :: Coolant Leaking Right Behind The Front Passenger Fender Well
Alright, yesterday while I am at work, wife calls me up and tells me the Ex is leaking coolant. I got home a little before dark and looked at it. Right behind the front passenger fender well, it appears that either a bolt came out of a bracket, or someone took it off for something and was too lazy to put it on, allowing the metal elbows to swing over and rub on a bracket. So now I have a hole in that elbow, and I need to the excursion for our trip over Christmas leave. Where I might get an elbow to replace that one? Also, need to know the bolt size for that heater hose bracket to keep it from happening again? If I can't find one pretty soon, I will have to JBWeld or something it temporarily to hold us through until after Christmas.
View 6 RepliesFord Excursion :: 2003 - Rear Heater Coolant Line Leak
I have a 2003 Ex with the 7.3. There is a leak in the rear coolant line just in front of the rear right tire. Is there any way to bypass the rear heater under the hood?
View 1 RepliesFord Excursion :: Passenger Side Front Axle Leaking Fluid
Its been awhile since I have been on. Everything has been running great for me until I found my passenger side front axle leaking fluid. I'm sure something has been posted on here but I have limited access to internet right now and need to know what I am getting into to change the seals. From what I have found there is an inner seal in the pumpkin and then an outer seal and dust cover. Are both of these easy to change? Are there any special tools needed? Do I need to remove the gears in the pumpkin? If so, is this difficult and any special tools required for this?
Mine is a 2001 V10-6.8, 4x4 no mods at this point.
Ford Excursion :: 2005 - Rear Axle Seal Leaking On Passenger Side
2005 4wd excursion. I have a leaking rear seal on passenger side.
I have the hub assembly off. I'm down to the spindle. My old seal came out in pieces. There's either a piece of the old seal or another seal on the back of the spindle.
Are there two seals? This what looks like a seal still on the spindle against the plate on the back...
Ford A/C :: 1997 E350 - Rear Heater Line Leaking Coolant
I just purchased an 97 E350 (15 Passenger) and I notice that the two rear heater lines (along the driver side) are rotted and is showing sign of minor leakage. Can I simply replace them with rubber heater hoses or do I need to get the factory heater lines?
View 6 RepliesFord Excursion :: Small Puddle Under Passenger Side Tire / Wheel Area - Front Seal Leaking
So this morning is just getting better and better. Was coming back in from getting the mail and noticed a small puddle under the passenger side tire/wheel area.
I never ever have a puddle of any sort in my drive way so...I start crawling around the truck and this is what I find. I can free spin the dust seal, but its all the fluid that has be worried. With less then 4 days till I have to haul everyone to the airport this is not what I need.
IF (man I feel stupid for asking) IF I leave it in 2 wheel drive how big of an issue would it be to drive it?
None of the parts will be in before I have to drive everyone out to the airport, this is the only reason I'm even considering this..
Plus would this explain a sudden lost of MPG?
Ford Excursion :: Rear Coolant Line Split In The Middle?
So I finally got my truck running on sunday and I come home after work yesterday and my driveway is covered in coolant. the line that goes to the rear had split in the middle and also in the rear?!? Where to get a replacement. I was thinking about just cutting out the messed up section and hose clamping some heater hose in its place?
View 12 RepliesFord 7.3L Power Stroke (1999-2003) :: Oil In Coolant And Cooler Leaking From Front Side
I've had my early 99 f350 7.3L for a lil while now. Starting to see few problems surfacing. while doing my weekly fluid levels found oil in coolant and after looking around found oil covering bottom of driver side engine. As far as i can see it looks like oil cooler leaking from front side.. Should i just replace oil cooler or rebuild?
View 4 RepliesFord Excursion :: Skid Plate In Front Of Passenger Side Rear Shock
Looking to install rear sway bar on 2001 Ex. and noticed a skid plate looking thing in front of passenger side rear shock. Two questions:
1. What is that, and
2. Do I need to remove it to put on sway Bar?
Tiguan :: Water In Floor In Front / Rear Passenger Side - Sunroof Leaking?
I found water in the floor in the front and rear passenger side of the car. I cleaned it up thinking the sunroof may not have been closed all the way at the dealership when they washed it. I drove it today in the rain and the front passenger side is wet again next to the console and near the seat. Where are the drains located at?
View 8 RepliesFord F-150 - 1997-2003 :: Coolant Bubbling Out Of Front Passenger Side Of Intake
Two weeks ago I was driving home from work and my heat stopped working. I pulled over and saw coolant dripping badly out of the bottom of my truck. I popped the hood and sure enough, coolant was bubbling out of the front passenger side of the intake. I took it to a shop to do the work (quoted at 500-550 out the door with a dorman intake). A week goes by and I get a call from the shop, "After two Dorman Intakes, the truck is not running right", what it could be.
The truck has 367k on it (not sure if original motor). Yesterday I get a call from the owner, " we put the original intake back on and fixed the leak with jb weld. The truck still runs bad. They claim they didnt do anything wrong and will not take any blame for ruining my engine. (Keep in mind the truck ran PERFECT when I took it in there). The truck doesnt throw any codes and they are at a loss of what could have happened. They put in 8 new plugs and 2 coils that they broke while in the process of removing the intake. F150 5.4 ...
Ford F-150 - 1997-2003 :: Coolant Leak At Rear Of Engine On Passenger Side Below AC Housing
I have a 1990 F-150 w/351 that I knew had a coolant leak at the back of the engine when I bought. It's a tinker around truck, something for me to play with.
I've traced the leak back to a metal tube/pipe that sticks out of the engine compartment just below the AC housing. I cannot find anything in the Haynes manual or a diagram on the intertron that shows what this is and if it should have a hose on it or...?
Ford F-150 - 1997-2003 :: Leaking Antifreeze Externally At The Front Of Passenger Side Head Gasket?
Working on a 2000 F150 with the 5.4 and as near as I can determine its leaking antifreeze externally at the front of the passenger side head gasket. Seems a little odd. The coolant is a nasty dirty orange color. With the truck running on the hoist it was dripping very steady off of the very front exhaust manifold bolt.
View 3 RepliesFord Excursion :: 2003 - Transmission High Pressure Line Leaking
I have a 2003 Ford Excursion with the high pressure line leaking. My guess is that the original line had a rubber hose and was replaced with a 3/8" ID high pressure hose. My problem is that I can not get the 3/8" ID replacement hose over the second larger bulge on the line going to the radiator cooler. What am I doing wrong?
View 3 RepliesFord Super Duty (1999-2016) :: 2003 F250 5.4L - Axle Leaking On Passenger Side Rear Rotor And All Over
Here's my problem while replacing brake pads i found that my axle has leaked fluid on the pss,side rear rotor and all over .. I been looking for any info on repairing it myself . I found Everything for every other truck just not for this truck.
It's 2003 F-250 w/5.4L all Stock rear axle has 12 bolts and gears are 7.73 ... I believe its a Dana 60. No tags or markings on the Axle to go by..
I live in the Freak-en woods here so i like to order all the right parts once and do over the weekend .. its my only ride so once apart im stuck here.... I did check the Vent Tube its fine..