Ford Excursion :: 2000 - When Turn The Key Won't Crank Over / Fire Up When Jump The Selonoid
I have a 2000 excursion with the 7.3 in it. When I turn the key it wont crank over but i can jump the selonoid and it will fire right up. I replaced the selonoid and I don't know what else it could be???
View 8 RepliesFord F-150 - 1997-2003 :: 2002 - Crank But No Start Or Spark
I have a 2002 F150 5.4L (VIN-L) that has been sitting in the driveway since February. I have been a mechanic for 30 years for large commercial trucks, and my own truck has me stumped. I'm sure I've forgotten something but I'll try to list everything I have tried so far. It started with crank no start, no check engine light, checked for trouble codes got a trouble code for the CHT(cylinder head temperature) sensor.
- Replaced the CHT sensor. Cleared codes.
- Dash lights up fine, shows mileage, and anti-theft is not flashing while cranking.
- Fuel Pump does not seem make any sounds. Hit the tank with a hammer. Nothing.
- A little fuel comes out of the schrader valve on the fuel rail when I push on it. I have not checked it with a pressure gauge.
- Attempted to start with ether, nothing, so I'm assuming no spark.
- Fuel pump inertia switch isn't triggered.
- Checked several ground connections to the frame and checked ground connections in the PCM harness. All have less than 5 ohm resistance.
- Unplugged and plugged back in cam shaft sensor.
- Checked voltage on the TPS(throttle position sensor) I'm unsure about the results, if the TPS was bad wouldn't it just idle funny and/or stall?
Fuel Pump and PCM relays in the underhood fuse block appear to be good. All other fuses and relays appear to be good. I have been swapping the relays with one I think is good, although. Searched all over for additional relays, and found 3 inside the cab behind the passenger air-bag. Can't seem to find anything in the Haynes/Chilton manual that lists what they do. They are about half the size of the fuel pump relay.
Manually grounded the fuel pump relay, relay clicks but I don't hear a buzz from the fuel pump. Id like to run 12V to the fuel pump directly to see if that's my issue, but I'm not sure where to connect it without frying something important.
I bought the alldata.com DIY guide for my truck and it hasn't worked much. I have read extensively about others with similar problems and I just don't know what to do next. My main question here is, if the fuel pump is bad, would that stop the spark plugs from working? I'd rather not replace the fuel pump without being absolutely sure.
Ford F-150 - 1997-2003 :: Truck Died While Driving - Crank But No Spark / No Fuel
My Truck : 1999 Ford F-150 Extended Cab 4x4 5.4L V8
So the other day I was driving the truck and it just dies on me. Tried starting but it just cranked and cranked. Got it pulled over to a parking lot and then tried to start and I got it to run again. Died a couple mins later uo the road and it will not start at all anymore. I got it towed to my driveway and I've started diagnosing some things.
I dropped the tank thinking it was a pump I replaced awhile back. The pump wasn't running but jumped to conclusions and took it back to the auto parts store. They bench tested and it works fine. I checked for voltage at the pump connector. NOTHING. So I'm not getting power to Fuel pump. Then I checked the fuse and relay for the fuel pump. Everything was okay.
I did some research and decided to check for spark. NO SPARK. Another thing I noticed the other day was that the odometer is displaying all dashes. So I'm really unsure on what to really troubleshoot. I am going back to the truck tomorrow to check a few other things. I'm not sure if the Theft light is blinking or not so I will check that tomorrow and get back to you.
What to check? Any other relays or fuses besides the fuel pump? What about any modules to check like PCM, GEM, etc. Or I've heard the crankshaft sensor could be an issue.
Golf IV R32 :: RPM Reading On Crank But No Spark Or Fuel
Coilpacks get 12V during ACESS, 9V when cranking. Crank sensor gets 10V, and VAG reads RPMs on crank, but no spark, no fuel.
View 2 RepliesToyota - Camry :: 2002 - Hard To Start / Starter Would Crank Just Fine But Engine Would Not Fire
Camry 2002 LE (4 cyl Auto), 140K mi
This morning, for the first time I can recall, the car would not start right away. Had been sitting in the garage for 2+ days. Starter would crank just fine, but engine would not fire. No lites were left on overnite. Finally (after about 6+ attempts), engine started -- runs fine now.
Took it to TOY dealer. Their diagnosis: weak battery, alternator low output.Happy, had recently (6 mos) replaced battery after 4 years of use, so got a new battery N/C.TOY ran a charging system check and it shows "Alternator Condition: OK" (midway between shitty and great I recall).
Funny, but my first thought when it would not start was the fuel system (fuel pump) or dirty ignitors. I did ask my regular mechanic for an opinion, and he thinks it might indeed be the fuel pump -- perhaps a clogged filter.
Camry :: 2007 4 Cyl Crank But Won't Start - Not Show Any Signs Of Fuel Or Spark
I brought the car home last night and shut it off. This morning went out and engine will crank but doesn't show any signs of fuel or spark. Removed one plug and grounded it to block while someone cranked it. No spark. I dumped a little fuel in the cylinder just to see if I could get it to cough or something, but nothing. I tried looking for blown fuses under hood and under dash but I haven't noticed anything out of the ordinary. I pulled out all relays and tapped them and reinstalled. I tried disconnecting the battery to reset ecu and that didn't work either. There are some relays marked that I don't recognize.
View 12 RepliesFord Excursion :: 2003 - Won't Start But Strong Crank - Fuel Pump?
I own a 2003 Limited with the 6.8 V10. I drove the truck on Sunday and all appeared to be fine, gas gauge was setting just under a half tank. When I went to start it yesterday, it would not start. Strong crank, no start. I checked my fuse and it was fine. Fast forward to this morning, since I had kind of depleted the battery with attempting to start, I put my little jump start pack on it and gave it a whirl. Truck started fine but the gas gauge was sitting on empty. I had five gallons of gas in the garage so I added that to the tank then drove to the local gas station to add more fuel. I put another 10 gallons in the tank so it should have roughly 16 or 17 gallons in the tank. Gauge shows 3/4 tank but miles to empty is right around 175 miles which would seem right with 17 gallons in the tank. I suspect the fuel pump. I don't really want to spend $500 on the Motorcraft unit but was wondering if the group believes the Delphi or the Bosch units are quality replacement parts?
View 7 RepliesFord Excursion :: Replaced Battery And Fuel Pump Relay / Only Crank / Won't Start?
Black Beauty finally gave up. Replaced battery, replaced fuel pump relay. Would only run with starter fluid sprayed into the air intake. She'll crank but not start. Here she sits at the dealership.
View 14 RepliesFord Excursion :: Long Crank Required To Turn Over V10 - Fuel Pressure Dropped
Ok. So. 2005 excursion v10 270k miles. Never ever had an issue starting. Today it was about 30 degrees in Detroit. Had to crank for about 4 seconds. Usually it turns over within one second of cranking. So I get to work and hook up a fuel pressure tester to it. Got to 35psi while running, upon shutting off it dropped to 0 within 30 seconds. I have no codes. And absolutely no drive ability issues. No gas smell. And I'm really hoping its just z fuel pump check valve cause then I can just prime it by doing key on key off then crank...also hoping not injector cause I won't be able to pull the injectors till Sunday snd I really don't wanna hydro lock my motor >.< best way to test injector/fuel pump valve? I like to fix issues as soon as they pop up. Wanna get my v10 to 400k.
View 8 RepliesPassat (B5) :: 2002 V6 Won't Start / No Spark Or Fuel
Freshly rebuilt 2.8 V6
Car turns over but is not getting spark or fuel. The timing is good (checked multiple times, and I have done numerous TBs on these engines). Compression is good.
The car has sat for ~2 months. It broke the timing belt (and bent or broke multiple valves), so I know it had both spark and fuel before this.
I have gone through and double checked every connection and everything is connected and seated properly. I used a stethoscope to listen to the injectors and there is no click during cranking, and using an extra plug I checked spark and there is none. I also hooked up my inductive timing light and it doesn't sense a spark.
I have VAG-COM and there are no fault codes. I have checked all fuses and they are good. If I do the tests on VAG-COM I can make the injectors cycle, but they don't cycle when cranking. I tested the crank position sensor (and tried a new one) and it tested good (and the new one made no difference). Using VAG-COM, I confirmed that it does sense the engine RPM when cranking. The battery voltage stays above 12V during cranking as well.
A couple other tidbits of info:
The fuel pump does work (and comes on when cranking... confirmed by disconnecting the hose and pumping fuel into a can)
When cranking for a few seconds, the display says STOP and flashes the oil light (I'm assuming because it is cranking at such low RPM)
The Check engine light and EPC light come on when the key is put in the on position and turn off during cranking (like they should)
The immobilizer light comes on for a few seconds as well, but it doesn't flash like it would if it was immobilizing the engine.
After looking at wiring diagrams, it appears that the ignition coils and the fuel injectors both run off of the same relay, but I am unsure which one or even if I am right about that. But assuming I am correct about that, wouldn't the injectors not fire during the test if that was bad?
Ford Excursion :: 2002 5.4L - Truck Start With Starting Fluid But Will Not Crank On Its Own
Having some problems with my truck.... First off I bought a 2002 excursion and drove it for one day. Then I was at the car wash cleaning up the truck. Then I saw the window fogging up so I turned the car off. Now it won't start.
I had previously installed a new stereo, but had some problems, so I ran the remote wire to the fuse box, because the wire in the harness wasn't getting power.. So after a little trouble shooting we found out that the fuel pump wasn't working or was bad.
We replaced it, now it has pressure but will not start, will start with starting fluid but will not crank on its own. someone told me it may be a bad PCM? and a dealer can only replace it... I don't have tons of cash, as i bought this truck on 8/30/12 and this happened the day after i bought it.
The previous owner has paid or the fuel pump replacing but I don't think its right on my part to have him pay more money as this may be a mess up on my part with hooking the radio up to the fuse box... we have tried the fuses,realys, crank sensors...
Ford Ranger / B-Series :: 1998 - No Spark / Cranks But Does Not Fire
My father in law has a 98 4wd, 4.0L that cranks but doesn't fire. We pulled a plug to check for spark....no spark. Possibly coil pack, or crank position sensor?
View 5 RepliesSaturn - SL2 :: 2002 - No Spark And Fuel Pump Will Not Engage
I was on my way to work and my car would not start after I stopped at the gas station. One of the people at the station gave me a jump start and I continued to work. I asked one of my co workers to give me a jump to get home and when I started the car there were sparks and a bit of smoke from the battery. We hooked it up right and it will turn over but not start. The fuses are all good, the dash lights come on (service engine soon, check engine and security). We replaced the battery, and the coil assembly (I think that contains the ICM, but not sure). I called the mechanic I normally use and he said it was probably time to buy a replacement car. My friend (the one who hooked it up wrong) thinks it might be fixable, he has some mechanic experience and stated we are getting no spark and the fuel pump will not engage. We hooked up a car scanner to it and it was unable to communicate.
View 6 RepliesFord Ranger / B-Series :: 2005 Has Spark And Injector Pulse But Will Not Fire
I have a 2005 ford ranger, 4.0 auto, 4x4, 60psi fuel presser, has spark and injector pulse, will try to start if you hold the throttle a little over 3/4 the way down, but will not fire on starting fluid.
View 3 RepliesFord - Explorer :: 2002 - Won't Start / Crank Till Battery Dies But Is Not Getting Fuel
I've got a 2002 Ford Sports Trac that won't start ! It will crank till battery dies but is not getting fuel. I have had it towed 4 times in the past year. of the 4 times,this last time it wont start. Every time that I have had it towed back to my house and dropped in the driveway it has started up with no problems. It will run for a few months or more.This last time it would not.
Could this be an electrical problem.Maybe loose ground somewhere or something else. Would like to rule out some things before investing in a fuel filter or fuel pump. Would hate to buy new FuelPump and that not be the problem. Can't find free wiring diaghrams for this issue.
Ford Fuel System :: Changed Fuel Filter Now Just Cranks But Won't Fire / Start
2002 E-250 with the 4.6 V-6. Pulled the 30 amp fuse, replaced the fuel filter, replaced the fuse, now the truck wont start. Checked the fuse and the kill switch under the passenger kick cover, all ok. Cranks and cranks but wont fire. No problem prior to changing the filter. Even swithed out the relay with another, no luck.
View 4 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 7.3L Will Crank Forever But No Start (bad Fuel Pump)
I just got delivered a 7.3L from down south. Batteries were dead so replaced both. Fuel was a couple notches above red line (much closer to red line than 1/4 tank) so I added about 7-8 gallons.
It will crank forever and ever...Won't start.
With starter fluid it starts but not strong enough to pump the pedal and rev it up to keep it idling.
I know s-fluid is bad but if I continuously spray with key turned forward it will run but as soon as I let go of key it shuts off.
20 degree weather and it was delivered to a parking lot so I cannot plug it in.
Was told to check filter cap, turn key, and see if it fills bowl with fuel....if not then it is fuel pump. Someone else mentioned that it could be bad crank position sensor? Does this sound like fuel pump?
S-10 :: 1997 Got Spark But Won't Fire
Heres the deal...less than 2 weeks ago i had the clutch replaced in my 97 s10 2wd 2.2 5spd. this truck has been nothing but problems mostly self inflicted (by myself) 20000 miles since February 9th... anyways I was driving down the road to work running not perfect but running. All of a sudden the truck shut off while going fast enough to go down another street into a lot. came back at the end of the work day tried to start it with nothing. It got spark but wont fire. Replaced the fuel pump and filter, checked all the lines to see if they were messed up during the clutch repair, the gas is circulating all the way through, so i took out the spark plugs and no of them are getting wet. Then we tried something and tried to get it to start and it shot a backfire and flames out the intake manifold...
View 2 RepliesSierra :: 97 GMC 5.7 Just Died - No Spark / Fire
Going down interstate running fine. Then just died, changed timing chain & gears, camshaft, crank, throttle pos. sensors, New cap & rotor,new gear on bottom of distributor, new coil and module, everything but the knock sensor and computer. Still no fire, Plug wires are good.
View 1 Replies