Ford Super Duty (1999-2016) :: 2002 - Gas Engine Won't Start After Replacing Fuel Filter / Pump Relay / Air Filter?
After replacing fuel filter, pump relay, and air filter for good measure my 2002 f250 v10 gas engine still wont start. What to do?
View 13 RepliesFord - Explorer :: 2000 - Runs Rough And Egg Smell After Replacing The Fuel Pump
I have a 2000 Ford Explorer with 4.0 SOHC engine, I have had some cold start problems. I cleaned the IAC and the problem went away for a few months and then came back. Two days ago the temps got very cold and it would not start at all, I re-cleaned the IAC and still no start. I replaced the fuel pump with an aftermarket pump and engine started right away. Now I have a rough idle, bad skip and bad exhaust odor. I am still thinking IAC but I am concerned that the aftermarket fuel pump is pumping to high pressure or that I may have crimped the return line. I have driven about 30 miles hoping the computer would make adjustments, still runs rough and the check engine light has not come on.
View 12 RepliesFord Excursion :: 2002 - Replacing Manual Hubs?
So I will be replacing the manual hubs on my Ford 2002 Excursion 7.3 diesel 4x4 with the WARN 38826. Just a few questions. Will I need to use the small snap ring? Also, do I have to worry about blocking the vacuum lines going to each stock hub? Any videos or step by step instructions with pictures for my truck.
View 12 RepliesNissan - Quest :: 2001 - Won't Start After Replacing Fuel Pump And Filter
Replaced fuel pump and filter on our 2001 Nissan Quest. It started up for a few minutes but once it got hot it sputtered out. We sprayed some starter fluid in it. Still nothing.
View 13 RepliesToyota - Matrix :: Multiple Misfires After Replacing All Coils And Fuel Pump
2003 Toyota Matrix with 217,000 miles (most on a rural mail route). Check engine light stays on with readings for multiple misfires, all four coils (which have all been replaced) and just replaced fuel pump. Gas mileage has plummeted.
View 16 RepliesFord Excursion :: Installing Fuel Pump?
I just got my Bosch fuel pump from Riff Faff and will be installing it this weekend.
I want to add a Pre and Post filters to the pump and had a couple of questions
1) the threaded end that's under pressure what is that connection.. I would like it hard connected to a filter and then the stock line connected to the out put of the filter.
2) for Pre Filter its a push Lock connection... Should I keep it or look for something that works better under Vacuum?
Ford Excursion :: Won't Start - Fuel Pump?
Before I left on Spring Break last week, truck wouldn't start. It was a Saturday morning, so I had it towed to the only open shop in town. He said the fuel pump was going out. He got it started maximizing the fuel pressure with his scan tool.
The unusual thing is I replaced the fuel pump (I have a V-10) earlier this year with a Motorcraft Pump from Amazon. I also replaced the fuel filter about 60,000 miles ago.
Does this sound right? I have never heard of turning up the pump with a scan tool.
It did fine over Spring Break, but is in my driveway right now refusing to start. I can't believe the fuel pump went out that quickly.
Does it sound like the fuel pump?
Ford Excursion :: Start Then Die Immediately - Fuel Pump?
As in a previous post, i have been having issues with my truck starting then immediately dieing if i dont keep my foot on the gas.
Ive learned how to drive with 2 feet because of it, but I'm afraid i might be doing some type of damage since it keeps dieing and I have to keep starting it.
Once i get going for about 10-15 minutes its fine but its happening every time i start the truck.
Before it starts running correctly, it only idles around 400 rpm.
I think its the fuel pump, since my mechanic put a code scanner on there and it didn't throw any codes, he thinks it might be the fuel pump.
My question is, should i go with a ford pump from the dealer or are the ones sold from discount/o'reilly/napa just as good?
Ford Excursion :: Fuel Pump Access Hatch?
Have any of you tried to cut an access hatch in the rear of your truck to get to the fuel pump without dropping the tank? Am I way off? can it even be done? My fuel pump took a dump with about a quarter of a tank. I'm trying to find a work around.
View 14 RepliesFord Excursion :: 2000 V10 - Fuel Pump Wiring Diagram
Looking for a link to the fuel pump wiring for a 2000 V10 Ex? I'm trying to pinpoint my no start issue and want to make sure I don't miss anything. I think it goes from 20 amp fuse under hood to inertia switch to relay under hood to pump? 20 amp fuse has power but at the inertia switch I have no voltage, just approx 35 ohms resistance to ground on both outside wires. Does the inertia switch close a ground or should it have voltage?
View 10 RepliesFord Excursion :: 2003 - Won't Start But Strong Crank - Fuel Pump?
I own a 2003 Limited with the 6.8 V10. I drove the truck on Sunday and all appeared to be fine, gas gauge was setting just under a half tank. When I went to start it yesterday, it would not start. Strong crank, no start. I checked my fuse and it was fine. Fast forward to this morning, since I had kind of depleted the battery with attempting to start, I put my little jump start pack on it and gave it a whirl. Truck started fine but the gas gauge was sitting on empty. I had five gallons of gas in the garage so I added that to the tank then drove to the local gas station to add more fuel. I put another 10 gallons in the tank so it should have roughly 16 or 17 gallons in the tank. Gauge shows 3/4 tank but miles to empty is right around 175 miles which would seem right with 17 gallons in the tank. I suspect the fuel pump. I don't really want to spend $500 on the Motorcraft unit but was wondering if the group believes the Delphi or the Bosch units are quality replacement parts?
View 7 RepliesFord Excursion :: Fuel Pump Died After Rough Running Randomly
I have been chasing down what was a perceived vacuum leak...
My Ex (V10, 4x4, 217K miles) started to have an intermittent rough running/no power situation very randomly. No codes on the scanner, and no real apparent cause or condition to pin it down. I noticed what sounded like a like throttle ping...figured it was a vacuum leak someplace in the spaghetti under the hood.
I began to run down the possibilities. I have recently had the entire suspension replaced and upgraded all 4 corners to Power Stop brakes. Figured it might be something related like the classic lines to the hubs.
Replaced the vacuum lines to the hubs - ran OK for a bit, then rough start/idle/no power.
Replaced the vacuum switch for the hubs - ran OK for a bit, then rough start/idle/no power.
Replaced fuel filter - ran OK for a bit, then rough start/idle/no power.
Ordered a new vacuum reservoir...
While waiting on that, changed all 10 plugs and coils. Not. Cheap. Ran OK for a bit, then rough start/idle/no power.
Replaced IAC - ran OK for a bit, then rough start/idle/no power.
As I was getting ready to install the vacuum res, it just croaked. it would turned over like it wanted to start, but wouldn't catch.
Of course.... So, now it had to be towed and yes, the fuel pump puked and that was that. I've never had one do anything but just quit suddenly before, so lesson learned. Evidently these pump can act up for a bit before they die.
Ford Excursion :: Bad Fuel Pump Relay / Fuse Panel Replacement?
- Fuse Box - Part # 3C7T-14A067-DC Engineering Number on white label.
- Ford Dealer Part # 3C7Z-14A068-DB
I have a 2004 Ford Excursion 6.8L 4x4 that has a bad fuel pump relay. I am looking for a used replacement fuse panel.
Of all these number and letters which of them tells me the real part number? Does the last two letters mean anything "DC" or "DB"?
So I don't get one for a diesel, what is the prefix for the diesel? I am assuming the 3C7T is gas and the year model?
Also, will this fuse panel interchange with a F250/F350 6.8L or do I need to stick with a fuse panel from an Excursion?
Ford Excursion :: Replaced Battery And Fuel Pump Relay / Only Crank / Won't Start?
Black Beauty finally gave up. Replaced battery, replaced fuel pump relay. Would only run with starter fluid sprayed into the air intake. She'll crank but not start. Here she sits at the dealership.
View 14 RepliesFord - Explorer :: 2002 - Fuel Pump Not Turning On
I have a 2002 ford explore 4.0 sport 4wd. I have a problem with my car, one day I tried starting the car and it didn't want to start. So i replaced the fuel filter and the car started. then after starting it a few times it didn't want to start anymore, so i took of the fuel tank (thinking bad gas, and there was stuff in the gas) so i take out the old gas out and put new gas, and bought a new fuel pump and filter, and when i put the gas tank back on the car, it still didnt want to start, so i take the fuel pump and find a random battery and connected it to the fuel pump and the pump spins so it works. I connected the pump to the car by itself not it the fuel tank (from underneath the car) and i was under the car to see if the pump turns on and someone tuned the car on, and the pump doesn't turn on (doesn't spin or anything). Long Story short, what i should do? Also I was looking for the fuel pump fuse and couldn't find it (thinking it might be the fuse) what is the fuse number or where its located.. i know where the fuel pump relay is, but just not the fuse. Why the pump wouldn't turned on??? The pic is how my fuse box looks like(there are many different version of the fuse box just wanted to show you how mine looks)...
View 11 RepliesFord Excursion :: Fuel Gauge Sender Quit Working - Pump Assembly Replacement?
The fuel gauge sender quit the other day so Im replacing the pump assembly. I believe in replacing fuel and ignition related parts with factory equipment. So I was going to get a Ford Motorcraft pump, but my wife checked for one through her work(local parts store). The counter guy found one that said original equipment, called them and was told "It is the same pump that gets installed on the assembly line". Well it came in today and its a Delphi. I was expecting a Ford pump. I associate Delphi with GM and I know GM pumps go out all the time. I know Ford pumps go out too, but I know several people with GMs that have replaced pumps multiple times within 100000 miles. Is Delphi worth taking a chance on?
View 6 RepliesFord Excursion :: Cranks And Fires On Few Cylinders Then Quits - Signs Of Failing Fuel Pump
My eXcursion is showing the typical signs of a failing fuel pump. It cranks and fires on a few cylinders, then quits. I released the schrader valve on the fuel rail but very little pressure is released. From these indications, and after checking for a blown fuse, it appears the fuel pump is going. I say going because it did start after this happened, but would you trust it?
I ordered a new fuel pump, it's due in tomorrow. I remember seeing instructions on how to drop the tank but can't locate them with the search function. I'm also concerned with how to remove the pump from inside the tank. I know you have to spin off the big plastic ring, how do you get the pump off the bottom of the tank?
Ford - Explorer :: 2002 V6 Won't Start / Fuel Pump Not Engaging
My parent's bought a 2002 Explorer 4.0 V6 very early, either late '01 or early '02 when it first came out. Besides the dash blackout (which I found a fix for, need to do) it's been plauged latley (since Nov/Dec 2010) with the intermittent issue of when... You turn the key on to start, you dont hear the fuel pump enguage, thus no start. Get towed, it works like a champ.
It's blown a fuse 1 or 2 times cause of this, had the fuel pump recently replaced (dec/jan this year) and just did it again. Our local Ford dealership figured the fuel pump went bad from sitting, the vehicle only has about 33k miles on it (dad dont drive much). What appears to be a bad fuel pump, only to have it get towed, or sit overnight and start like nothing ever happened?
Dad's ranting about not trusting the vehicle anymore, he's 80yrs old so I can't blame him for wanting to feel comfortable with knowing his vehicle should start, but it is a machine, they do break but we cant seem to get this fixed.
Ford F-150 - 1997-2003 :: 2002 - Stumbles - Hesitates During Acceleration - Fuel Pump?
My 02 F150 4.6 has 84K miles on it, and started stumbling/hesitating during accellartion about three weeks ago. Before this problem started (about 2,000 miles ago), I installed a new fuel filter and air filter. Since I noticed the problem, I installed new plugs. The problem didn't go away, so today I checked the fuel pressure. At idle the pressure is 32psi with the vacuum line left on the fuel pressure regulator (30-45 is normal as per Chilton's), and 42 with the vacuum line off (40-50 is normal as per Chilton's). I also had someone else rev the engine so I could observe, and found that the fuel pressure went as low as 28 when the engine speed was quickly increased. The standing fuel line pressure is 30 (30 is normal as per Chilton's) Does this sound like a fuel pump problem, or is there something else that I'm missing.
View 10 Replies