Ford Excursion :: Leaking Coolant Hose Under Degas Bottle Behind Valve Cover?
My truck has a 6 o powerstroke. I noticed some coolant loss, which I've been monitoring since I had the truck studded 2 years ago. Today I was looking around trying to find a cause of the coolant loss and I noticed some crusty orange residue on a hose that runs under the coolant reservoir. The hose seems to go behind the valve covers along the firewall to the passenger side through a steel line, and then go in a loop back to itself?
I'm guessing it's for the heater core, but I didn't see where it actually goes into the heater core, or anything else for that matter. It is a molded hose that has one of those crimped transitions into the steel line, so I'm not sure if patching it is an option or if I should look at replacing the whole piece. I'm guessing it's going to be expensive. From the fact that it never failed before, I'm thinking it wasn't originally routed with it touching the valve cover and was just something that happened after having the body off during the stud install.
Ford 6.0L Power Stroke Diesel :: 2006 - Oily Foam In Degas Bottle?
I have a 2006 6.0 with 165,000 miles. No over heating runs fine ,no smoke but I have oily foam in my degas bottle. No coolant in my oil. Scratching my head over this.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Coolant Dripping Under Degas Bottle / Boot Oil Leak
I have coolant leaking from under my degas bottle. There was a spot on the driveway this morning and upon investigation, I saw a drip hanging from the bottom of the degas. No liquid on top at all. Where this is coming from? Bottom hose?
Also, the boot that connects the tube (right side while looking at front of truck) to the elbow that goes into the intake is leaking oil and making a mess. Whats the best way to fix? Remove boot, clean up, and put back on? Or replace boot? If replace, where can I get that boot?
Ford 7.3L Power Stroke (1999-2003) :: 2002 - Degas Bottle Is Building Pressure And Coolants Puking Out
My degas bottle is building pressure and coolants puking out. This happens after a light drive started months ago it sat at mechanic for 3 months he never touched it just wanted to replace motor so i brought it home. The truck starts and idles and runs fine temp gauge sits at normal. There was white smoke a few times several months back when it started up but went away after warm up but none now. I don't drive it i have a spare vehicle i tried doing exhaust gas test on degas bottle to check head gaskets today with no luck. They gave me the gasser only fluid with tester. No coolant on the ground and I've added the dye to see it with ultraviolet light no leaks around radiator.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Transmission Temps Hot / Antifreeze Coming Out The Cap On Degas Bottle
Just bought a used 2011 ford f350 with the 6.7 diesel engine. Coming from a 7.3 1999 f350 with 330,000 miles, still going good. Took a 1000 mile trip on the 11 truck with out pulling anything did good. Hooked my enclosed trailer to it did a trip of 900 down and 900 back. Transmission temps were staying around the 250f, almost in yellow on gauge. Highest it went was 255f. Light never came on. Yesterday on trip without trailer was staying at 230f on trans temp. This is the first concern.
Second concern, had antifreeze coming out the cap on the degas bottle. Rolled over the hood and hit the drivers side windshield. Stopped un did the cap, it hissed. Put 2 quarts of antifreeze in drove on, this at 300 miles of trip. Primary water pump went out, half way there, at about 550 miles of trip. On trip back, about 1600 miles of trip, antifreeze was on windshield again. Undid cap, hissed, did not need to add any to it. Drove on no problems since. Have bought a new cap and installed.
Transmission doesn't want to shift right when its cold. First starting out. When it warms up shifts great. That's third problem.
Ford 6.0L Power Stroke Diesel :: Missing Going Uphill And Blowing Black Smoke / Ruptured Degas Bottle Now Truck Won't Start
I was towing my camper uphill and my 03 6.0 started missing and blowing black kid smoke. Next thing I know I hear a loud pop and steam is coming from under the hood and the truck dies. I pull over and discover the degas lid is stuck on and the bottle came apart at the the seam and the truck will not start. 6.0 with 120k miles
View 1 RepliesGolf IV / Jetta IV :: 2000 2.8L V6 - Heavy Black Smoke Pouring Out
2000 Jetta (build date 10/99) 2.8L V6
Pours out heavy black smoke.
New Air Cleaner, pulled plugs, all smell of gasoline, they don't look black, like I normally would expect gas fouled plugs to look. I read that these are prone to clogged fuel injectors? If so, all 6 at once? Also told that the timing slipping can cause this.
Ford 6.0L Power Stroke Diesel :: Oil In Degas / Odor Of New Green Coolant
Found this tonight. Looks like oil in the degas. No smell of diesel, just the familiar odor of new green coolant. Cap was still holing pressure when I opened it.
Looks like I need to change the oil cooler. What is the best way to flush the cooling system out that has a leaking cooler and is contaminated with oil?
Ford 6.0L Power Stroke Diesel :: 2006 F250 - Coolant Puking Out Of The Degas Tank
I've been MIA for a while. 2006 F250 just hit 83k miles. My coolant must be puking out of the degas tank. White residue all over degas and drivers side engine bay. I had my mechanic buddy pressure test coolant system for several hours and he said there weren't any leaks. He told me to replace the degas cap for now. Didn't solve the problem. Temps have always been fine. Never found drops or a puddle of coolant. Even when the truck has sat overnight for over 8 hours, there is still a bunch of pressure built up when cap is removed.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Added Whole Bottle Of Stanadyne?
I was day dreamimng and the fuel pump this mornin and by accident dumped 32 ounces (whole bottle) of Stanadyne and then pumped 33 of 38 gallons of diesel to fill her up. Thats double the spec of what I should have used. Do I need to worry about anything or no big deal?
View 4 RepliesFord 6.0L Power Stroke Diesel :: 2005 - Bottle Rocket Like Noise At Startup
2005 w/ 188,000 miles, A/T. Zero driveability issues. Torque Pro shows VGT % changing as expected, but I think that's just a commanded %, not a measured %.
So for the last month or so, every time I start my truck, I hear a noise about 3-4 seconds later that lasts about half a second. It sounds like a bottle rocket shooting up into the air (that whistle/scream sound). It happens whether I'm in my 55'F garage with the block heater plugged for a few hours (coolant temp 80-100F), or if it's sitting in the parking lot at work at 20'F all day.
I'm guessing the turbo needs to be cleaned (unison ring sticking?) but want to just get a few quick opinions if that's the right direction to go.
I found there's a $60 Ford brand cleaning kit with some new seals and the 3M sanding discs, so I think I'd do that. Plus, I read there's a new/updated turbo oil drain tube I should install while its apart.
So the big questions I have are: is it likely I need a turbo cleaning, and what else should I do at the same time? Oil drain update? Or am I barking up the wrong tree?
And because this thread is worthless without a pic, here I am leading the charge to Rausch Creek last summer!
Ford - Radiators - Explorersporttrac :: Steam Comes Pouring Out Of Hood From Footwell Area
When car is stopped after driving for awhile, steam comes pouring out of hood on passenger side near windshield. Opened the hood and steam was coming from firewall area, not from radiator. Mechanic replaced thermostat etc. for heater core but stll have steam problem. Temperature gauge reads normal and heater doesn't work. It tastes like antifreeze is getting into passenger compartment and it fogs up the windshield.Radiator cap is not even warm. Sounds like antifreeze is not flowing through the radiator.
View 7 RepliesFord Aerostar :: Loud Pop / Antifreeze Burning Smell / Steam Pouring Out From The Hood
Had numerous problems the last 9 months, and we've replaced the thermostat, water pump, clutch fan, flushed radiator. Last week we thought the heater core had died (air blowing cold, but gauge not indicating any overheating). But it just need flushing, had a clog. Has been kicking out the heat ever since.
What is bothering me though is that the temp gauge always seems to be right at the C, even after driving for a while. Before the van had issues, it stayed right between N and O.
Then this morning, I hear a loud pop, smell horrible burning antifreeze and smoke/steam pouring out from the hood (I managed to park it immediately, had just dropped son off at school). After I'm parked, all the antifreeze puddles underneath.
So hubby comes, and we see that the top radiator hose has blown, with a lovely crack/hole from one side to the other. Now, that hose was old, and probably was a big part of the problem.
We fixed it, and I just drove it again, but I am watching the gauge. And the van is blowing nice, HOT air from the heater. But the gauge is staying right at the C. Used to run between N and O. It is jumpy...not jumping towards hot, but little jumps...below the C, above the C, up to the N, back down to C...it just seems strange to me; it doesn't go past the N at all and spends most of its time at or below the C.
I guess I am wondering if there is any other reason why the hose could've blown this morning besides it being old and worn out....for example, excess heat and pressure building up that for some reason is not registering on the temp gauge? It's making me nervous. Is there something else besides the thermostat that could cause erratic temp gauge or cause gauge not to show me the true engine temp?
Ford 6.0L Power Stroke Diesel :: 2004 - Sudden Oil Leak Pouring Out Under The Truck?
I have not been on here for a while my X has never had any problems 140,000+ miles. yesterday went out side to start her and let it warm up went back inside to make coffee came out 10 minutes later and found a server oil leak pouring out under the truck. Immediately turned her off popped the hood and found oil all over the back top of the motor? before I start tearing into it, need to know where to start. I've read IPC sensor, CAC hose, anything else to look for?
View 7 RepliesFord F-150 - 1997-2003 :: Exhaust Is Pouring Out White Smoke With A Sweet Smell
I have a 2003 F150 with a 4.6. Exhaust is pouring out white smoke with a sweet smell. I have replaced upper and lower intake gaskets. Compression test on all cylinders are at 145. Confused and don't know where to go from here.
View 1 RepliesFord Super Duty (1999-2016) :: 2008 F250 - White Smoke Pouring Out
I have a 2008 Ford 250 diesel that is pouring out white smoke from the exhaust when it goes into "cleaning filter" mode. I really don't understand this because I have a dpf delete with a sct tuner. I thought with the tuner and delete the truck wouldn't go into filter cleaning mode. I contacted Ford and they said it was normal for white smoke to come from the exhaust during this process. What's going on maybe tuner is bad?
View 5 RepliesFord 6.0L Power Stroke Diesel :: 2006 F250 - No Boost / Black Smoke Pouring Out When Driving
When I'm driving sometimes it will pour black smoke and make no boost, and then the next time I get on the throttle it goes make to making boost like normal. It has the following thing done in the last 50k. I have a 2006 f-250 lariat FX4 it has the following mods:
EGR delete,
Powermax Turbo,
Rudy's Diesel Up Pipe,
4" Turbo Back Muffler Delete,
New For Injectors,
Blue Spring mod,
Gear Head Tune,
S&B Elbow And S&B Cold air kit
Ford 6.7L Power Stroke Diesel :: Barely Runs / Misses - Fuel Pouring From Underside Of Motor
So, after sitting for about 4 weeks, I go to start my 2011 F350, 16,000 miles, with a 6.7. Barely runs, "misses", fuel pouring from the underside of the motor, all over the ground. I figure out pretty quickly, #8 fuel injector was blown out of its hole. Clamp is busted.
Two days later (this morning), dealer calls and says we have all the parts we need to fix your truck, except the clamp. Guy says no ETA on the clamp from Ford. Truck will just sit, for an indefinite period of time. Asked him what they were going to do. He said, wait for the part to show up.
Putting aside the oddity of the clamp breaking, how is it that Ford doesn't have the part and doesn't know when it will? Is this a Ford problem or a lazy dealer? This really won't do. Its racing season and I need my truck!
Ford 7.3L Power Stroke (1999-2003) :: Transmission Started Pouring Fluid From Inspection Plate
Just pulled into campground pulling 5ver transmission started pouring fluid from inspection plate. Only does when running but it's a gusher. Fluid is nice and red and didn't smell burnt. What should I expect when I have towed to shop?
View 5 Replies