Ford 7.3L Power Stroke (1999-2003) :: 2002 - Degas Bottle Is Building Pressure And Coolants Puking Out
My degas bottle is building pressure and coolants puking out. This happens after a light drive started months ago it sat at mechanic for 3 months he never touched it just wanted to replace motor so i brought it home. The truck starts and idles and runs fine temp gauge sits at normal. There was white smoke a few times several months back when it started up but went away after warm up but none now. I don't drive it i have a spare vehicle i tried doing exhaust gas test on degas bottle to check head gaskets today with no luck. They gave me the gasser only fluid with tester. No coolant on the ground and I've added the dye to see it with ultraviolet light no leaks around radiator.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Getting Warm And Puking Coolant
my 2006 6.0 will roll over 300,000 miles this week but today I was pulling a 24' pontoon boat that should only weigh a few thousand pounds from hot springs Ar where there are some small rolling hills and the outside temp was 70 degrees. I was driving between 55-60 most of the drive. On a few of the longer hills my eot got up to 220 with the eot trying to catch up.
On the down side it would fall to 185-190 and the eot would also follow. On about a 5 mile straight stretch the ect was 208 and eot 202. When I got home I opened the hood and I do have coolant puke around the degas bottle. After opening the cap there seemed to be a steam/smoke coming out of the degas bottle. There was still some coolant in the bottom but not a whole lot.
On my drive to work every day my delta is between 6-8 degrees with the ect between 188-194 depending on ambient temp. So does this sound like my head gaskets finally let go? Will them blowing raise the eot/ect when towing?
Ford 6.0L Power Stroke Diesel :: Oil In Degas / Odor Of New Green Coolant
Found this tonight. Looks like oil in the degas. No smell of diesel, just the familiar odor of new green coolant. Cap was still holing pressure when I opened it.
Looks like I need to change the oil cooler. What is the best way to flush the cooling system out that has a leaking cooler and is contaminated with oil?
Ford 6.0L Power Stroke Diesel :: 2005 - Puking Coolant - No Codes?
Ok so I have a 2005 f250 6.0L. It is fully bulletproofed with ARP head studs. I am running a sct anarchy on street tune. My problem is that sometimes it is "puking" coolant from the degas bottle but only a drop every now and then around the cap; it drives fine, no trouble codes, the engine and trans temp is fine and it's not blowing white smoke it still blows black smoke, and there is no coolant smell just straight diesel. What might be causing it to puke a drop of coolant every now and then?
View 9 RepliesFord 6.0L Power Stroke Diesel :: Coolant Dripping Under Degas Bottle / Boot Oil Leak
I have coolant leaking from under my degas bottle. There was a spot on the driveway this morning and upon investigation, I saw a drip hanging from the bottom of the degas. No liquid on top at all. Where this is coming from? Bottom hose?
Also, the boot that connects the tube (right side while looking at front of truck) to the elbow that goes into the intake is leaking oil and making a mess. Whats the best way to fix? Remove boot, clean up, and put back on? Or replace boot? If replace, where can I get that boot?
Ford 6.0L Power Stroke Diesel :: 2006 - Oily Foam In Degas Bottle?
I have a 2006 6.0 with 165,000 miles. No over heating runs fine ,no smoke but I have oily foam in my degas bottle. No coolant in my oil. Scratching my head over this.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2006 F250 - Coolant Leak?
I have a O6 F250. Egr delete and a new oil cooler 20k ago. I have been dealing with missing coolant for about 6 months. A little here or there but it has gotten really bad the last few weeks. My last attempt was to replace the degas cap. Stopped the missing coolant for a 30 mile trip. Just to clarify it had gotten to the point I was adding one gallon per 20 miles. Needless to say I was thrilled. Next morning I came out to find coolant under the truck. Plastic Y under degass, so I replaced it. 25 miles and none missing. Next morning fluid under the truck. Now it's the egr hose.
Replaced it with a gates hose and new clamps. Fill it up with coolant go inside and its leaking in the same location. Its a pure pleasure to undertake. So I assume these leaks weren't previously leaking because the degass cap wasn't pressurizing the system. That being said the leak is on the oil cooler side of the egr hose. The snap lock fitting that was on the original housing spins around. Should that locking mechanism be removed before the hose is secured and clamped? This is the only thing I can come up with as the culprit. I have searched the information on the site but can't find any mention of it needing to be removed. The clamps are the right width and everything is seated.
Ford Excursion :: Coolant Puking And Overflow Tank Smells Like Exhaust
I have owned my 2005 v10 ex since 60000 miles. Have had many dependable family road trips and love my truck.
Recently it has started puking coolant and the overflow tank smells like exhaust. The oil cap has some coolant sludge on it. But there is no coolant mixed with the oil. Or oil in the coolant.
I am pretty certain these are the signs of failing head gaskets. The truck has 193000 miles on it now.
Want to keep it on course. But keep it reliable. So do I buy new engine or do I just replace head gaskets?
Ford 6.7L Power Stroke Diesel :: Coolant Level In The Primary Tank Low
2012 6.7 .... Noticed my coolant level in the primary tank was low. Thought it was totally empty but it had about a half inch left in it. Topped it off and also needed about a quarter inch in the secondary. I would say about a half gallon between the two. Truck was at about 36k. Has 37.5 on it now and haven't noticed any loss. Never smelled anything, no signs of any leakage. Oil looks fine. Is this 'normal'? Owners manual says to check and add. Never had this with a gasser or any of my tractors over the past 30 years. This is my first light diesel.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2003 - Puking From Cap?
I have had this truck for about 8 months now, and it has been the fine only thing it really has is and EGR cooler delete.
It has started puking from the coolant reservoir, and I am not sure why. going to parts store within the next hour or so to get a new one. I have a scan gauge II and always watch my temps very closely. I am normally at 190-205 with never more than a 10-degree delta between EOT, and ECT. I am hoping I will not be taking my truck to Powerstroke specialties tomorrow!
There is pressure in the degas bottle after the truck has been running. also there is pressure after it has been off for a few hours, but much less. I've read this is a bad thing, and also that it is a good thing also i always use ford gold coolant and t6 full syn Rotella with all Motorcraft filters.
Ford 6.7L Power Stroke Diesel :: 2015 F250 - DEF Low Caution With Full Tank?
The DEF low caution is on and counting down the miles to go but the DEF tank is full. The caution goes away for a start or two then comes back. She's a 2015 F250 with the 6.7L. I love this truck but its starting to really bug me. I don't know if its related but she's been in the shop four times for warranty repairs to the wiring harness in the past couple months. Apparently there were loose connections in a couple of cannon plugs that the've now bypassed which were causing loss of communication between computers...
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 - Fuel Gauge At E With 1/2 Tank?
2005 F250 Superduty Crewcab 4x4 6.0L diesel/auto
Wife drove the truck before me and bunched the floor mat under the pedals. I didn't notice the mat issue when I drove the truck today. I accelerated fully after doing a left turn onto a busy highway. The motor spun up hard with the accelerator floored but because of the mats, the pedal stuck all the way down. I was approaching stopped traffic while under full acceleration and I shut the engine off and pulled over to the shoulder all while braking hard ( it was a hell of a ride!). I freed the pedal and restarted the engine.
Now, despite a bit less than 1/2 tank of fuel (I have the 38 gal tank), the dash readout was showing "Low Fuel", the gas gauge was below E and the engine was running like it was running out of fuel. I turned the engine off again and left it off for 1/2 hour before restarting it but the gauge and engine still behaved the same. As I drove to the nearest diesel station, the engine was not running "right". Of course the station I pulled into had 1 diesel pump and the pump was broken.
Because I thought I might actually be out of fuel, an understanding stranger took me to the store to buy some gas cans and then to another station to get 6 gallons of fuel. I got back to the truck and added the 6 gallons of fuel. When I turned the key on, the fuel gauge immediately came up to 1/2 tank. I then drove to that other station and added another 15 gallons of fuel to fill it. This confirmed that I had about 18 gallons of fuel in truck when the "Low fuel" warning occurred.
So, what the heck was going on with the fuel gauge? I am sure the "Low Fuel" warning is tied directly to the gauge but why was the gauge reading low? Is it possible that the "Key-off" while under full acceleration followed by hard braking had confused the ECU? I am just trying to figure out if I have a fuel sender problem or a confused computer that corrected itself. Until this incident, the fuel gauge has never been a problem but the wife messing up the mats has been an issue!
Ford 6.0L Power Stroke Diesel :: 2004 F250 Run Out Of Fuel With Gauge Showing 1/4 Tank
For the second time in 6 weeks My 2004 F250 Powerstroke has run out of fuel with the gauge showing a 1/4 tank. First time it was just under a 1/4 showing I had it towed to dealer and they told me it had sucked in the filters requiring replace and flush of system. The told me that this happening very often and I would be replacing all of the injectors at my cost. I told them that I didn't want this to happen again and to check out the fuel gauge and sending unit and replace if in doubt. Well they checked it out and found nothing wrong, told me it was accurate and should not be an issue again. Now 6 weeks later on the Friday night before a holiday, it did it again, this time with over a 1/4 tank showing. I really don't want to spend 6 grand replacing injectors and would really like to trust my truck again, getting to the point that I'm nervous at 1/2 tank.
View 9 RepliesFord 6.0L Power Stroke Diesel :: 2003 F250 - How Auxiliary Fuel Tank Works
I recently purchased a 2003 F250 Super Duty with a 6.0L Powerstroke Diesel. The truck came with an auxiliary fuel tank in the bed, but how it works. There is a keyed switch in the cab next to another regular switch, and I have not had the courage to try either of them yet since the whole thing looks like a DIY job. I did look under the truck, and can see what appears to be some sort of solenoid setup.
Just wondering, how it works and if it is safe to operate. I do not see any rollover valve, and want to make sure I do not overfill the tank if I use it.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Transmission Temps Hot / Antifreeze Coming Out The Cap On Degas Bottle
Just bought a used 2011 ford f350 with the 6.7 diesel engine. Coming from a 7.3 1999 f350 with 330,000 miles, still going good. Took a 1000 mile trip on the 11 truck with out pulling anything did good. Hooked my enclosed trailer to it did a trip of 900 down and 900 back. Transmission temps were staying around the 250f, almost in yellow on gauge. Highest it went was 255f. Light never came on. Yesterday on trip without trailer was staying at 230f on trans temp. This is the first concern.
Second concern, had antifreeze coming out the cap on the degas bottle. Rolled over the hood and hit the drivers side windshield. Stopped un did the cap, it hissed. Put 2 quarts of antifreeze in drove on, this at 300 miles of trip. Primary water pump went out, half way there, at about 550 miles of trip. On trip back, about 1600 miles of trip, antifreeze was on windshield again. Undid cap, hissed, did not need to add any to it. Drove on no problems since. Have bought a new cap and installed.
Transmission doesn't want to shift right when its cold. First starting out. When it warms up shifts great. That's third problem.
Ford 6.7L Power Stroke Diesel :: 2015 F250 Hard To Start When Fuel Level Reached 1/4 Tank
I recently bought a used 2015 F250. When the fuel level reached 1/4 tank it became hard to start. Sometimes up to 6 seconds of cranking to get it to start. I filled it up with fresh diesel and it fired up as soon as I turned the key. A week later the problem returned, this time I was above 1/2 tank. I run the recommended additives, I changed both fuel filters, but it didn't work. I have only had the truck 3 weeks, and it still has a warranty. There are no fault codes, and the truck run great once started. What could be wrong.
View 7 RepliesFord 6.0L Power Stroke Diesel :: Missing Going Uphill And Blowing Black Smoke / Ruptured Degas Bottle Now Truck Won't Start
I was towing my camper uphill and my 03 6.0 started missing and blowing black kid smoke. Next thing I know I hear a loud pop and steam is coming from under the hood and the truck dies. I pull over and discover the degas lid is stuck on and the bottle came apart at the the seam and the truck will not start. 6.0 with 120k miles
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2007 F250 - Max Oil And Coolant Temps?
I have a 2007 F250 with the 6.0. Towing up a long hill my truck went into limp mode. I didn't have gauges at the time so I didn't know what my temps were. I now have gauges. I know that the coolant and Oil temps should not be more than 10-15* apart, but what is the max temp that oil should EVER get towing up a steep and long hill? Also, what is the max temp that coolant should EVER get towing up a steep and long hill?
View 14 RepliesFord Super Duty (1999-2016) :: 2003 F250 - T-Stat Stuck / Puking Coolant In Front Of Engine
I have an 03 F-250 6.0 Lariat with almost 200,000. The other day my t-stat started sticking and popping at 220 and then would go back to normal. Now it won't pop and it's puking coolant in the front of the engine. Would just a bad t-stat cause this or do I need to do my water pump as well.
View 1 Replies