Ford - Aviator :: 2004 - ABS Light Is On Almost All Of The Time / Code C1155
Bought an '04 Aviator 2wd on Saturday. ABS light is on almost all of the time, but it has turned off a few times. Pulled a C1155 code. I removed the left front sensor, and there was no dirt, metal, debris, etc in the hole. Before I buy a new sensor, is there a test procedure to follow on the old sensor??
View 2 RepliesFord - Aviator :: 2005 - Airbag Light Constantly On - Code 33 Staying?
Just recently started getting what started as an intermittent air bag light that is now on constant. I seem to be getting a code 33.
View 5 RepliesFord F-150 (2004-2008) :: Airbag Light - Code 25 Flashing
So I swapped in a new cluster fx4 to stx to get my airbag light to work. It now works but flashes code 25. Is code 25 the passenger airbag deactivation switch?
View 2 RepliesFord Transmission :: Check Engine Light On / OD Light Flashing Sometimes - Code P1747
I have a 1998 expedition 4.6 4x4 check engine light on od light flashing sometimes checked it and got p1747 code i was told epc solenoid or short on trans wiring. I already dropped the trans pan, looking for a step by step easy way to diagnose and find the short or if i need to replace any of the solenoids. I have voltmeter and taste light....
View 3 RepliesFord - Aviator :: 2004 AWD - Shudder Shifting Into OD
We have a 2004 Aviator AWD. 73k miles. Trans has been shuddering on the upshift to OD intermittantly. No codes no other symptoms.
I dropped the pan, replaced the filter and 5-6 quarts of fluid with Mercron V fluid. No metal in pan, fluid was not burned, filter only had a small amount of dirt. Very small amount (fine dust)of metal on the magnet. Drove it about 50 miles and noticed the shudder again this morning. I planned on replacing the fluid in the pan again after some miles and time so as to get most of the 12 or so quarts replaced.
I have no codes or CEL. No flashing OD light either...
Ford - Aviator :: 2004 - Exhaust Stud Removal?
I have a broken exhaust stud on my 2004 Aviator. The stud broke even with the nut surface, not flush with the head. It's also the easiest stud to access without removing the manifold.
I center punched the stud and started to drill it, but unfortunately the chuck of my drill interfered slightly with the heat shield and caused me to drill off center. I sprayed the bolts for the heat shield down, let them soak overnight, then tried to remove them but the very first one broke off. So I bought a drill bit extension and aimed the drill hole back toward the center, but that's not working much. I have a 5/32" hole in the stud and have sprayed the stud and manifold interface with the gasket and head down with Blaster 3 times over the course of a day and a half but the EZ-Out isn't spinning the stud out.
The labor rate for replacing the manifold is 1.8 hours but I don't see how that is realistic. It doesn't look very easy, and I'm afraid other studs may brake if I try to remove the manifold. What else I might try to get the stud replaced? And "take it to an exhaust shop and let them fight it" is NOT out of the question.
Ford - Aviator :: 2004 - Front Drive Shaft Removal?
I am wanting to remove my front drive shaft from my 2004 Aviator for a couple of month's while I save money to have my transfer case replaced. Are there any safety concerns with this? just need a couple of month's to get the money together....
View 5 RepliesFord - Aviator :: 2004 - ABS Ratchets On During A Normal Stop - No Codes
I am working on a 2004 aviator 2wd that the abs ratchets on during a normal stop. No codes and all the wheel speed sensors read correctly and match. What happens is the pedal will fall and then hit back up like the abs is ratcheting.
View 3 RepliesFord - Ranger :: 1995 - Airbag Light Flashing / Code 41
The airbag light on my 1995 Ford Ranger is flashing a code 41 (four flashes, pause, then one flash...does this a few times when I start the engine, then goes to a solid light which stays on while I drive.) It has been doing this for several months, and to be perfectly honest, this has not been a concern for me but now that my state inspection is coming up in December, I need to do something about it. Just before I noticed it to begin with, I had a major repair done--the dreaded heater core replacement--which involved removal of the dashboard. I never associated the flashing with that repair and the possibility that the repair shop might have inadvertently neglected to reattach something when reassembling the dashboard and now so much time has passed, that I can't just go back to the repair shop.
View 4 RepliesFord Aerostar :: 1996 - Airbag Light Comes On - Code 41 Flashing
Got an air bag code 41. Comes on and flashes the code a number of times, then goes off for the rest of the ride. It is a 96 Arerostar, XLT, 4LV6. From what I read it is a short someplace. Where are the crash sensors and how do you check them for "shorts"? I don't understand much about the whole system.
View 12 RepliesFord - Explorer :: 2003 - O/D Light Flashing - Code P0775?
I've got a 2003 Ford Explorer The transmission O/D light is flashing, and the check engine light came on. I'm getting and Code of P0775 Pres. Ctrl Solenoid B Circuit Malfunction. Also it shifts rough between gears, the rpms ramp up to much before it shifts. What the problem is, and how to fix it?
View 13 RepliesFord Excursion :: O/D Light Started Flashing - Code P0743
On the way home tonight, the O/D light started flashing. I happened to have the Bluetooth OBD adapter with me, so I plugged it in and opened Torque. It comes up with a "pending" code of P0743. After a little bit, the light quit flashing so we drove the last mile home. The O/D light began flashing again the last couple hundred feet before our driveway. There didn't seem to be any loss of power or anything like that the whole time.
After we got the kids to bed I went back out to check the fluid level. (It had cooled some, so I let it run a bit before I checked it - the light wasn't flashing this time.) The level is at the second dot, right below the crosshatch. It's almost transparent, but I don't know when it was last flushed (if ever). From what I've seen on here, I'm guessing this is an electrical short somewhere?
Ford F-150 (2004-2008) :: Airbag Flashing Code 42 Now 16
Ok I have a 2004 F150. The airbag was flashing 42, I have since replaced that sensor and now its flashing code 16. I have searched everywhere and cannot find the answer to my question. Any clue as to what this code is trying to tell me. Lost 1, this is lost 3, are you lost 2?
View 4 RepliesFord - Aviator :: 2004 - Check Backup Assist Message When In Reverse
My wifes 04 Aviator gives a check backup assist when in reverse. Checked fuse no problem.
View 2 RepliesFord Ranger / B-Series :: 2002 - Airbag Light Is Flashing Code 46
My 2002 Ford Airbag light is flashing 46. I believe this is the Drivers side crash senor. I am repairing the left front fender and left front wheel suspension. I have replaced the two air bags and airbag control module. Where is the left front crash sensor?
View 13 RepliesFord F-150 - 1997-2003 :: OD Light Began Flashing / Code P1728
It is a 1997 Ford f150 5.4 4x4 extended cab 175k miles. Took a 600 mile trip, first 300 no problems, then the "od" light began flashing, the truck shifted fine so I kept going, drove for about a 100 miles then stopped for fuel and read the code, (p1728) cleared the code and drove another 200 miles, no light no problem. The whole time there was no drivability issues. Yesterday I drove all over town, stop and go traffic, locking the TC and it would also unlock, no problems all day, drivability was fine. What to do?
1. Just keep driving it?
2. Does changing fluid fix this problem?
3. Rebuild the trans, because this was just the first notice.
4. Sell it quick no light and drives fine.?
Ford F-150 - 1997-2003 :: 2000 - Code P0705 - O/D Light Flashing?
To start I was driving to work tonight and noticed the o/d "off" light flashing. it shifted hard one time then felt normal the rest of the way to work. At red lights the o/d light world turn off and about 3 minutes later it would flash again. When I got to work, I checked my code reader which gave me the p0705. I have searched around the net for about an hour and one thing i am seeing is that the fluid is "hot" or that there isn't enough. i have checked it and it looks slightly low like right above the add indication.
The only sound I here from under the truck is a rattle when in drive and at idle, but once I give it some gas it goes away. On they way home that night the o/d light was still flashing but it drove fine just at higher rpm, it down shifted hard one time but there were no other issues. I checked the fuses and they are all good.
Ford Transmission :: 2002 F350 - Tow Light Is Flashing - Code P1876 Came Up
I have a '02 F350 just over 114k miles, tow light is flashing and just had P1876 code come up. 4h and 4l engage and disengage with out a problem. Code reads 2wd solenoid circuit failure. Where is this solenoid is located?
View 1 RepliesFord F-150 (2004-2008) :: 2006 - Airbag Code 42 Flashing
2006 F150, FX4, 5.4, super crew. Had the infamous airbag code 42 flashing at me the other day, replaced the sensor in the front of the radiator support, and am still getting the same code. The old senser had some corrosion inside the sensor itself, but the connections were clean on both the sensor and the pigtail. Is there something I may have missed?
View 3 Replies