Ford Aerostar :: 1995 4.0 No Longer Likes To Shift Out Of First Gear / Vacuum Modulator Oddity
My '95 Aerostar 4.0 no longer likes to shift out of first gear. It will if I accelerate to maybe 25mph and completely get off the throttle for a few seconds. (It also revs freely at full-throttle kick down, as though it was in neutral.) A fluid and filter change didn't work, so I dug into forum posts. I found the vacuum modulator, and there's no ATF in the vacuum line, but it's an adjustable one which has me baffled...
The modulator has a thumb wheel on the outside of it. It will unscrew completely - and then it comes off, with a pin attached to it. This is very different from the ones I've seen pictures of here, where the pin is moved by the diaphragm. Is this the same pin, or some kind of preload device for the actual pin farther inside?
There's enough else wrong with the Aerostar that I'm not willing to sink very much more money into it. It'll run as is, as long as I'm careful. I'm just trying to get a few more miles out of it... might a regular, non-adjustable modulator?
Ford Aerostar :: 1995 - Automatic Transmission Won't Shift Into Overdrive
My 95 ford Aerostar 3.0 automatic trans wont shift into overdrive, here's what happened. a small hose on the side of the transmission came off, this must have popped off when I was stepping on the gas with the brake on in drive and reverse. It took 2 months to find the hose off, during those 2 months I had to shift the van manually, you had to get high RPMS before it would shift.
About 2 weeks before I found the problem I notice the van would not kick into overdrive. When I finally found the issue and reconnected the hose the trans shifted fine but still would not kick into overdrive though. Is there another vacuum hose that goes to the main vacuum housing? or an adjustment on the linkage area? This has been like this for about 6 months now and I can go on a highway..
Ford Aerostar :: 1993 - Transmission Dropping Out Of Overdrive
I have a 1993 Aerostar 3.0L, automatic. The transmission has started dropping out of overdrive into drive while at speed. It's very inconsistent as sometimes it will drive without incident and sometimes it will barely go into overdrive and then drop back out and remain in drive for an extend period of time. I changed the fluid/filter/gasket thinking it was just overdue for changing but no luck. The fluid level is fine, perhaps even a little high. Fluid looks clean on the stick, so I don't think it was a lack of draining enough fluid. The problem seems to be more pronounced when warmed up.
Also when cold, I've had an issue with it stalling while taking off from a stop. I wouldn't necessarily relate the two problems, but someone mentioned they thought they might both be a symptom of a slipping torque converter or something. But the stalling issue seems to go away when it's warmed up.
Also had an issue with the van not wanting to start when damp. But I attributed this to water getting on the coil or plugs or something. What I could try before taking it to a shop and risking getting taken?
Ford Aerostar :: 1997 - Auto Transmission Starting To Slip A Lot In Overdrive
Have a 1997 Ford Aerostar van 4.0 L v-6 RWD 119,754 miles. Auto Transmission starting to slip alot in overdrive. Fluid and filter changes at 86,119miles. Have a Haynes Repair manual that only cover vehicles to 1996... Talks about the transmissions A4LD 4-Speed that uses electronic controls integrated into the on-board EEC-IV system.. Rather that covers my 1997 I don't know. Fluid looks very clean on dipstick. Crawled under van.... On side of transmission #P97GT7006BBR 750Nn. Took to a national brand Transmission chain.... Said trans overdrive wearing out. Anything else I can check or am i getting ripped off ?
View 8 RepliesFord Aerostar :: Transmission Code P1744 - No Flashing Overdrive Light On Shifter
I got this code and symptoms of 1-2 hard shift and no torque converter lockup. No flashing overdrive light on shifter. If I switch off engine all shifts are smooth until I pass 45mph. I would feel the TCC lockup. This doesn't happen the as i come to a stop I get a harsh 2-1 shift. Key off restart then shifts smoothly up and down provided I dont exceed the TCC lockup speed. This leads me to the TCC solenoid I think. Fluid has been changed regularly.
Had to drive 300 miles to get home. Only for the plate trans cooler the fluid would have overheated as on inclines on cruise control the engine would rev to 3k to keep the speed at 70mph and I could see the fluid temp increasing. Fuel consumption was very bad almost a full tank (with no ac). Doing some research there is talk about valve gasket blowout Epc solenoids etc, though these were for Rangers and Explorers, no real mention of Aerostar.
Ford Aerostar :: 1994 - Fuse That Controls Overdrive Torque Converter Lockup
Looking for the fuse that controls the overdrive torque converter clutch/lock up/engagement. Had a look in the owner's manual, didn't find anything. Pulled a couple fuses that I thought might be the one, no go.
I had found this fuse b4 but now a couple years later can't remember which one it is and can't remember where I found the info on what # the fuse was.
Ford - Explorer :: 1998 - Won't Shift Into Overdrive / No Reverse Right Away?
Got a call from my little sister about two weeks ago that her Ford Explorer would not drive forward. Checked it out and put it into second to get it home.Last weekend me and my dad changed the filter and fluid and then drove it for a bit. It sounded a little better but still would go into drive or reverse. We shifted into second which we knew worked and then back into reverse immediately and now reverse worked, although sluggish. The same was true for drive. A few days later dad changed a solenoid and now it will go into drive and go up to 15mph, but will not shift from first to overdrive first. And still no reverse right away. She is able to get to school with second gear and pop into drive when she gets up to 40-45mph. If she has to backup from start, first she has to put it into second and then back to reverse. Something in overdrive doesn't seem to be doing its job right.
View 3 RepliesFord - Explorer :: 2009 - Bucking Before Shift Into Overdrive
I own a 2009 ford explorer 4wd 5 speed auto with only 44,000 miles when I drive using overdrive just before it shifts into overdrive it bucks and when I slow down below 50 mph before it will down shift to 4th gear it bucks. I have had the suv to a ford dealer repair service 2 times and they ran a diagnostic computer check on it both times and found nothing. What I need to do next?
View 1 RepliesFord F-150 (2004-2008) :: Jerking When Shift Into Overdrive
I have an 05 f150 5.4 and when it shifts into overdrive the whole truck starts jerking, if I turn overdrive off it shifts and runs smooth through all other gears. When it does start jerking if i give it gas and speed up it stops and runs smooth?
View 9 RepliesFord Transmission :: 1998 F150 4.6 4x4 Won't Shift Into 3rd Or Overdrive
I have a 1998 F150 with auto lock 4x4 and a automatic transmission. The problem I am having is after setting for about a week I drove it and 1st to second shift normally but when the RMP's/MPH hits time ti shift to third I get RMP increase and no third. I have shifted it manually 1 then 2 and into drive same result RMP's increase just like it is in neutral.
Miles on trans is about 120K have been serviced about 10K ago with no poor color or smell. Mechanic said transmission and filter looked good no metal or junk in oil. I drive down the road and it shifts from first into second then about 35-40 it hits what should be third but nothing free RPM's. I let it slow down to below 35-30 second kicks back in and away we go again until it's ready to shift into third.
I have been told possible speed sensor problem, possible other sensor problems looking for leads on where to look and what items to check. Just had Shop Mechanic drive it and he was baffled for everything looks good that he checked such as oil, and how it drove until it tries to shift into third. No over drive light flashing or anything and no engine codes showing at all everything clean in memory.
Ford - Explorer :: Automatic Transmission - Rough Shift Into Overdrive
My 2002 Explorer LTD with 155K miles on it is in terrific shape except for a worsening rough shift into overdrive (automatic transmission) and a clunk which occurs with increasing frequency when I shift into reverse. I would love to keep the car but don't want to spend the money for a new or rebuilt transmission. There is no access for owner approach to transmission fluid - I have already looked in the manual. I would need to take the truck to a garage as I cannot do repairs myself.
View 2 RepliesFord Excursion :: Overdrive Button On The Gear Shift Does Not Work
I have an '05 V10 with 74,000 miles. The overdrive button on the gear shift does not work and it keeps me in trailering mode. If I put it in park and jostle the shifter and steering wheel, sometimes it works. Also, the back-up sensors no longer work.
View 5 RepliesFord F-150 - 1997-2003 :: Overdrive Button Blinking On Shift Lever
So I drive a 19 97 F150 v8 5.4 4x4 and while on the freeway I noticed that my overdrive button was blinking on the shift lever. The truck wasn't driving any different than usual, so Im just trying to figure out what this means.
View 1 RepliesFord Aerostar :: 1995 - Won't Shift From 1st To 2nd / 2nd To Third?
This van has the A4LD transmission. I know nothing about transmissions, so, when it wouldn't shift from 1st to 2nd, or, 2nd to third, I researched it on here and found a lot of bad reviews. I also found out that it was likely the modulator gone bad, and how to replace it. I replaced it, and although the new one was restricted and the old one wasn't, shifting was back to normal. So, I was thinking, that was easy enough, pretty good for the original tranny which has 297,623 miles on it, and hasn't been serviced since the first 1k!
Well, that lasted about 75 miles. Now it won't go forward or backward. Everything is still in place, no leaks, fluid level is full. I didn't change the fluid or do anything other than change the modulator. (My friend can't afford to service it properly. Now it may need replacing!) I have only seen problems shifting between gears and OD, TC lockup, etc., but, nothing about not moving at all. What might be the problem? Is the tranny history?
Ford Aerostar :: 1995 Won't Shift Out Of Park
I just picked up Aerostar #6 and am in the process of transferring parts etc. Got this one cheap as it was badly abused and has issues. Big problem, the shifter takes a lot of wiggling etc to get out of park. Is the interlock easy to disable? If so how? Or would a good column from my 93 be an easy plug and play proposition?
View 1 RepliesFord Aerostar :: Shift Lever Broken?
Ok, my shift lever is broken where the OD button is located. Not the cap and button, the whole end of the lever has snapped off.
View 5 RepliesFord Aerostar :: 1995 - Hard To Shift Out Of Park
I have a 95 Aerostar that when in park it is hard to shift into reverse, drive etc. It is an automatic, 3.0 liter.
View 7 RepliesFord Aerostar :: A4LD Transmission Won't Shift Automatically?
For a while now my transmission has only been able to shift manually for about the first mile of travel when cold or if it sits for more than a couple of hrs.
I drove it that way for a while. Now it only shifts manually all the time and I have to shift from 2nd straight to overdrive. It won't shift to 3rd but stays in second gear until I shift to OD. Then I do have OD.
Ford Super Duty (1999-2016) :: 2006 F250 Auto - Trans Won't Shift Into Overdrive?
I have a 2006 F250 with the 6.0 PowerStroke and automatic transmission. I just purchased this truck at an auction about a month ago.
Today I notice the transmission is not shifting into overdrive. No warning lights. If I press the tow/haul button in no change but the tow/haul light does come on. If I press it again (to turn it off) the tow/haul light goes out but still the transmission will not shift into overdrive.
This leaves me at about 2000 RPM at 68 MPH. I just had a Ford dealer perform Transmission service last week. (20,000 miles after the last recorded service.)
I am already not happy with the service I received at the dealer so I am really hesitant to take it back to them if it is something not related to the transmission service they performed.