Ford 7.3L Power Stroke (1999-2003) :: F250 - No Power / Shuddering Under Load
I will start with what I have done to my truck. Hutch and harpoon mod, fuel pump, new orings on fuel lines, fuel filter, air box, 4" exhaust. My issue only happens when my engine is warmed up and I put it under a load(driving up a long hill or pulling up a long hill). My truck starts to shudder and feels like missing until it looses all power to where it won't even pull itself and will just barely idle. It doesn't die though. I watch the engine oil temp and it seems to be around 195-200 when it occurs. I can turn the truck off and let the oil temp cool to 150-160 and then start the truck up it will miss for a second then clear up. I will start driving again and it seems fine until the oil temp gets up and start putting it under a load. I have read many posts and can't figure out exactly where I need to start. Some of the codes I pulled are P0603, P0470, P0732, P0542 and P1211.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: 1994 F250 Missing Under Load / Loses Power
1994 f250 7.3 turbo problem.. runs great on the level.. Cruises 65 no problem.. We have an 8% grade coming from town and half way up it starts cutting out and sounds like a jack brake under the hood and loses power.. Once over the top it clears out and runs fine again.... I just changed the fuel filters but no luck... I have been wrenching on cars all my life but no diesels..
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Runs Hot Under Load
Been fighting a coolant issue on '02 F250 4x4 with 7.3. Truck runs hot when under load (ie towing, or ac running on a hot day going down the road). Will sit and idle all day with ac on high and 100 outside. I hear my fan at cold start as normal but that's the only time I hear it. Still has original water pump, fan clutch and radiator. I know all three could stand to be replaced with 340,000 on it. But can't afford to do it all at once.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Loud Whistle While Under A Load
First off I have a 2001 7.3 with 294000 miles. While pulling my camper after it gets warm it puts out a very loud whistle it seems to happen when the fan clutch kicks in it does not sound like a belt squeal it almost sounds like it's coming from the turbo area. The engine seems to Surge while this is going on but the RPM gauge doesn't dictate that it almost sounds like it's the fan clutch surging. I took a short video of it while it was doing it ...
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: AC On / Vents Start Pushing Hot Air When Under A Load
I have an 03 F250 7.3litre. I have noticed the last few times driving while hauling that my vents start pushing hot air when under a load (example: driving up a long, steep pull) even if I have the AC on. It's starting make me a lot hot under the collar (pun intended) .....
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Excessive Blue Smoke Under Load?
Ok, I have owned my truck for almost a year and it has 151,000 miles. I have noticed on a few occasions puffs of blue smoke and especially at night in the headlights behind me I notice a lot of smoke when I'm getting into the throttle hard. Under normal driving conditions I don't usually see anything.
Today I noticed it when I was backing my camper(8000lbs) up a small hill onto the side of my garage. It was puffing blue pretty good going up the hill while it was under load.
I have no check engine light on, the truck seems to be running fine. My oil consumption is about 2 quarts every 3-4000 miles. I tried the blow by test with the oil cap but besides some smoke out the filler neck no problems... I don't know very much about diesels so for me to try and trouble shoot this is a problem.
Ford 7.3L Power Stroke (1999-2003) :: Turbo Chatter Under Load - Boost Was Around 17 - 18 Psi
I have done some searching on this, seen a video on YouTube but haven't read anything that is firm on what it is. We pulled our 5er for the first time last weekend and the chatter was pretty pronounced in the Arbuckles here in OK. I was running around 65 mph when I hit the largest hill and as I was climbing my speed naturally dropped, boost was around 17 - 18 psi when the chatter started.
Is it something to be really concerned about? Is there anything to be done to prevent it? I'm pretty much still stock, only deletes have been airbox to 6637, and I deleted the heater by turbo for the boost gauge. Other than that everything on truck is still stock.
Ford 7.3L Power Stroke (1999-2003) :: 2001 F450 - SES Light Came On Followed By Loss Of Power Under Load And White Smoke From Exhaust
I have a 2001 F450 7.3 chassis cab with just over 100k. I have a new problem... So far on two different occasions the service engine came on followed by a loss of power under a load and white smoke from the exhaust. Took it to the shop the first time, they determined it to be a dirty air filter, which seemed odd since it just happened all of a sudden. They changed air & fuel filter, problem gone- for two weeks..
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - 305-75-20 Tires Work On 4x4?
I want to put 305-75-20 on my stock f250 4x4 will they work?
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Smokes While Driving Under Load And Shuddering At 2k RPMs
Ill start off with my mods and recent maintenance things I have done before fully describing the issue.
E99 7.3l with 190k on the clock
Full 5" turbo back
TS-6 chip
EGT, Boost and trans temp gauge
New ford glow plugs
Re-orings injectors
new valve cover gaskets
new fuel filter and fuel lines
new turbo with a ww2
Newer trans and oil pan
I think that should do it, now for my problem. The truck starts good cranks over once and is running with no hesitation, the engine run a little rough, more than normal vibration at idle almost like a small miss. No smoke at idle.
While driving with no/little load on the engine runs great , but under load there is a good amount of white smoke/ oil smell. The turbo is new and is not leaking oil I have already checked over that and the exhaust is new but there is some oil that is at the tail pipe in liquid form. The exhaust up pipe that goes to the turbo is not covered in oil either
The truck cruising in OD or in 3rd with O/D off around 2k rpms it shudders real bad almost like the truck is going to shake its self apart. but at like 2400 rpms and above its fine. Where is a good place to start the diagnosis as I am pretty new to the Diesel world. From what I've read it looks to be either rings are junk or maybe I have some bad injectors (thats what it feels like to me) but would that cause it to smoke like crazy?
Ford 7.3L Power Stroke (1999-2003) :: Front Tires Started Rubbing
About two weeks ago my front tires started rubbing. I've been running the same size tires as long as I've owned this truck, and the PO ran the same size too. The rub is more noticeable when turning up an incline, but I've heard/felt the run on flat ground too. What would cause this "out of the blue"? Are my springs wearing out? FYI...I replaced the shocks less than a year ago, and bought the tires in March.
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: Vibration Noise When Taking Off With A Load On Drive Line
My rearmost drive shaft u-joint is bad and has slop. I've been having vibration for about 7-8 months, but just started hearing a noise within the past week, especially when taking off with a load on the drive line (uphill or heavy acceleration). The vibration has not gotten worse, just that the noise has just begun to show itself.
I have one u-joint which is OE and has 275K miles on it, and it seems to be OK at the moment. The other two (including the rearmost unit) both have about 100K miles, as does the center support bearing.
Just because I don't want to worry about anything, I'm going to replace all three u-joints with Moog Super Strength units, and will also replace the Center Bearing with a new Spicer unit... just because I can and don't want to be pecked to death with multiple failures in the same drive line. I ordered the Moog joints because the only Spicer joints I could find were for the 4wd configuration.
That's the context... here's my question... The parts are on order and won't get here for several days. I've been driving the truck like it is at about 1500 miles monthly. Do I continue to drive the truck for another week before getting the joints and bearing installed? I know it's a guess... just looking for more perspective.
Ford 7.3L Power Stroke (1999-2003) :: 1997 V8 - Right Side Exhaust Tick When In Gear And Under Load
I only hear it in gear under load so I can't stick my head under the hood to pin point it. I dont see any black streaks and I replaced the EGR tube. Is it commonly just the gasket or do the manifolds crack? If they crack where?
View 11 RepliesFord 7.3L Power Stroke (1999-2003) :: 4wd - Tires Not Pulling When Manually Lock Hubs
My transfer case engages the front drive shaft spins but even when I manually lock my hubs neither of my tires will pull! I was thinking either the hubs are shot but I was told it could be the 4wd locking solenoid??
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Black Smoke Appears To Pulse Erratically Under Acceleration With Load
Was hauling a bobcat this AM and noticed something odd in my rear view. Under steady accelleration (either light or heavy foot pedal pressure - steady either way), the exhaust would puff out sporadic extreme dark clouds of smoke. The puffs weren't fast like every cylinder rotation.. but every second or so.. puff of very thick black smoke mixed in with the expected black smoke we see.
Truck has 350k miles with regular oil changes. Year ago someone hooked the injectors up to the computer software (buzz test) and all of them checked out to be in very good condition.
The same tech pointed out some dark blowby at the uppipe on the back of the engine. Other than that the truck is in pretty good condition for its age. What could the sporadic very thick/dark puffs of black smoke indicate?
Ford 7.3L Power Stroke (1999-2003) :: F350 - Front Tires Cupping / Bouncing Down The Road
I have been "fighting" a front tire cupping problem on my L99 F350 Dually 2wd since I have owned it.
I got LOTS of paperwork with it, one of which was a service ticket from the dealer where it was bought new (with VERY low miles on it) saying several passing motorists had informed them that the front tires were bouncing down the road.
I have read this service complaint several times and I now feel that has something to do with it. I bought the truck with 70k on it some 8 years ago-the PO had installed EXPENSIVE Michelin XPS Rib steering tires on it and they were already destroyed by cupping.
I replaced all 4 shocks, and all 6 tires, begged the folks to FIND something wrong/loose/worn out on the front suspension/steering and they found nothing, they aligned it. THAT set of Cooper Discoverer HT tires did exactly the same thing, except I spent a lot of $$ having the tires rotated.
Now I have a set of Firestone TransForce tires on it and its been to a HD truck shop where I begged them to rip into the front end and FIND something wrong-THEY DIDN'T. THEY installed camber bolts and aligned it, yep, you guessed it STILL CUPPING!!
So, now I'm thinking is it possible that the wrong coil springs were installed at the factory causing this bouncing that the original owner reported to the dealer? I have now destroyed 2 more tires and getting tired of it.
Ford 7.3L Power Stroke (1999-2003) :: Shaking At Higher Speeds - 40 MPH And Above - Loss Of Power
I have a 2000 Excursion 7.3, 6 position tune, and exhaust as far as mods (on truck when bought). Last couple of weeks I get no power while on the throttle, foot on the gas and the whole truck shakes at higher speeds - 40mph and above. At first it wouldn't go above 60 or so, would hit the gas and Rpms would just stop not be able to generate any further power. Changed the IPR, ICP, and CPS.
I still get the high/low range ICP codes, P1280, P1281. First night the IPR was changed I got it up to 90mph and thought it was all solved but got a little shake right at the top and I let off the gas. Next day back to square one and has seemed to get progressively worse, almost wasn't able to make it up a hill by my house not even going 20mph, but it's like intermittent. I have a scan tool, here is at idle and at around 60mph ....
Ford 7.3L Power Stroke (1999-2003) :: 2000 - Vibration While Towing At Low Speeds
I have a 2000 with a six speed and through the first 2 gears while giving it only a little throttle, worse on hills and worse while towing I have a pretty decent vibration. Once you get to 3rd and up its fine. I have read about axle wrap and due to the fact my springs are pretty wore out I think this is a big part of it. Any other things to look at other than new springs? The u joints all look and feel fine so I haven't touched them.
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Coolant Temp Higher Than Oil Temp Under Load
Coolant temps getting much higher than oil temps under load. Is there any problem that could cause this other than a bad temperature sensor? Reading temps with an Edge CTS 2 monitor. Think I'm going to hook up a mechanical gauge in the morning and see what it shows.
View 8 Replies