Ford 7.3L Power Stroke (1999-2003) :: 2002 F250 - Door Ajar Light Is Lit Up On The Dash
I have a 2002 f250 screw. my door ajar light is lit up on the dash. I have tried the wd40 trick, pulled the sensors and bench tested them. What are the codes the instrument cluster test has for each door?
What I am thinking is, if we get a list posted it would be much easier to diagnose the door sensors for others. there should be a open/closed bit for each door. possibly a code for all doors open too. I am curious if there is a code for bad communication on the VSM.
From what I have read, correctly working the doors should read 00 when they are closed. drivers front open=80, pass front open=40 ... My door code does not change no matter what combination of door open/close I use.
Truck is 2002 f250 crew cab ...
My code is C0 ...
Ford - Explorer :: 2002 - Door Ajar Light Keeps Staying On
02 limited explorer with 114k. The door ajar light keeps staying on and the dome light wont go off. This has happened 5 times now in 2 days. I open and close each door and hatch a couple times and it eventually goes away or I turn off vehicle and restart trying to clear message. How do I test and locate where the issue is coming from?
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Door Ajar Light Stays On All The Time When Engine Is Running
Here are some signs of the problem.
*Key fob does not work - battery is good.
*Interior overhead light works only on manual.
*Driver's auto door lock (with driver door open) will lock all four doors but the driver's door will automatically open back. To secure the truck I manually lock the driver's door.
*I replaced the driver's door 'ajar switch' with no results. The old switch was good after testing - normally closed until the ball is depressed then it goes to open.
*No codes.
*I just checked all the mini-fuses with a VOM and they are good.
*Could one of the relays be part of the problem?
I am curious if there is a scanner that can identify the bad door ajar switch if any?
From what I have read so far it appears the VSM (Vehicle Security Module) may be bad as a many of these 2002's complain of this problem and the VSM generally solves the issues. Are there folks other than the dealerships that can program the module if I purchase a new one and remove the old OEM one? Other than the inconvenience the truck runs fine other wise.
Ford 7.3L Power Stroke (1999-2003) :: Red Door Open Light Started Staying On
So my red door open light started staying on. Along with all the lights associated with the doors being opened. The lights don't always come on, but the dash lights stays. As a quick fix I just popped the bulbs out and went on my way. Tried lubing the doors. That didn't work. I started noticing it seemed to be related to when I was slowing down or turning.
I thought maybe it's my passenger leaning on the door around the turns. So I inspected all the doors, they latch fine and don't feel like they're open. Last night I was riding by myself, and I realized that it wasn't anyone leaning on the door. When I would slow down, at the same spot. I would hear a click and the lights by the doors would come on, as well as the light on the back of the cab over the bed.
It did it every time the whole way home. It was approx. 16-18 mph when it would click. It was the same spot each time but I couldn't really nail the exact speed and watch for deer. I originally thought I'd just replace the sensors in the doors, but idk if that'll work anymore since it seems to be affected by other factors.
Ford 7.3L Power Stroke (1999-2003) :: 2002 F250 - Airbag Light Is Staying On / Code 25
Just bought a 2002 F-250 4x4 Off-Road Crew Cab 7.3L and the airbag light is staying on. I have found out after the fact that the truck has been previously involved in a front end collision. The damage was to the passenger side front. I turn the ignition on, the airbag light will come on solid (just like all the rest, with the exception of the 4x4 and 4x4 low) then go out. Then it flashes slowly 2x then 5x, then goes out for a bit then repeats a few times before staying on. This tells me I am getting a code of 25. I have searched with no luck to narrow this issue down. Everything mechanically works, cruise, horn, etc. The only thing I can find wrong is when I engage the 4-wheel drive (floor shifter) the indicator lights do not illuminate in the instrument cluster. Neither the 4x4 nor the 4x4 low. I am unfamiliar with this truck, so I don't know where to began searching. I cant afford to take it to a dealer and I have children in the truck quite often, so I would like to remedy this very quickly.
View 9 RepliesFord Super Duty (1999-2016) :: 2002 F250 - Door Ajar Light Stays On / Power Locks On Driver And Passenger Door Not Working
Vehicle: 2002 f250 xlt 7.3 powerstroke reg. Cab
Issue: door ajar light stays on, power locks on driver and passenger door don't work, radio stays on after truck is off an door is opened.
Events leading up to issue: went to temporarily hook up a wolo dixie horn to see if it worked. Wanted to do it fast so I took + cable, tied one end to the battery terminal and then connected other end to dixie horn relay. I then grounded both negative wires to the truck. One ground on the frame the other I temporarily wrapped around a one of factory ground mounts under the dash. Immediately after doing this the problems stated above started.
How can I fix this. I need to fix this by tomorrow. I have a guy from Craigslist coming to look at the truck. Now the 4x4 issue.
Truck has zf6 manual and the electric 4wd select ****. Just thought I'd list this if it was needed to be known for solutions.
4x4 high light stays on in while 2wd all the time. 4 low will stay on after switching back to 4 high and 2wd but it goes out if I ether stop the truck shut it off then restart it. or back up and slam on the brakes. Also when in 4 high the front driveshaft won't spin. However It will spin when in 4 low.
Another random issue I'd thought I'd just list while I'm writing this.... Cruise control does not work. And when I press the "on" button and the "coast" button at the same time the horn honks.
Ford Super Duty (1999-2016) :: Door Ajar Light Staying On And Radio Not Shutting Off Upon Exiting The Truck
Truck '02 F250 SuperCab - I was having an issue with the door ajar light staying on and the radio not shutting off upon exiting the truck. After having no luck with the WD-40 fix, I replaced the door switch sensor on the driver's side door and disconnected the negative battery cable for a few minutes (maybe 5-10).
Problem solved or so I thought...a few days later (approximately 5) the door ajar light came back on and the radio did not shut off. I disconnected the negative cable and sure enough that fixed it...again The problem is that every few days I have to go thru this. I'm not sure if it's related or not, but the CD player has started giving me "error reading disc" on even brand new CD's.
Ford 7.3L Power Stroke (1999-2003) :: How To Disable Speaker For Door Ajar Alarm
I just purchased a 2000 F-250 (extended cab, extended bed); it's my first powerstroke as I owned an IDI prior to its purchase.
- How do I disable the speaker for the door ajar/seat belt/low fuel alarm? IT HAS TO GO!
- Also as a new powerstroke owner, are there any spare parts/sensors, etc. that I should keep handy, just in case? (ie. I always kept a spare glow plug relay in the IDI F250)...
Ford Excursion :: 2000 - Door Ajar Light Staying On
So my 2000 ex has the door ajar light on. I have narrowed it down to the drivers side rear door. I have sprayed wd40 and pb blaster into the latch and its still on.
I have taken the panel off and sprayed everything inside. I pulled apart the wires running inside the door and tried doing some experimenting with twisting wires together, Hoping to close off the circuit.
Prius (2004-09) :: Door Open (Ajar) Warning Light Staying On
My 08 Prius developed a hiccup yesterday. While driving down the interstate there was an occasional red flash from the dash. It would come and go so fast that by the time I could actually process it and focus it was gone. I had to stop by the dentist office as I was ready to walk out the door I heard a car in the parking lot with the horn/alarm sounding. I mentioned to the folks in the waiting room that someone alarm was going off. A lady replied that green Prius with the bike rack!
Sure enough it was mine! I was unable to find any causal factor. I left there and at my next stop, the horn/alarm started sounding just as I walked through the entrance door to Home Depot back to the parking lot. This time the Door Ajar/Open light on the dash was lit. I opened and closed all the doors and hatch. The Door Ajar light was still on I then manually manipulated all the door switches and opened/closed/slammed the hatch several times. No Joy I drove home.
About the only thing I was able to find was that it was probably the hatch, the switch is sealed within the locking/latch mechanism and that I could simply just unplug it. So I began troubleshooting.
After removing the rear hatch/floor, plastic bin, etc. I removed the plastic cover from around the latch (above the bumper not on the hatch lid), then removed the longer plastic cover that runs along the same area and provides the cover for the area between the rubber gasket and the inside of the hatch/floor area. Now I was able to see the latch mechanism and associated wiring (looking down toward the spare tire well). I also had the hatch light turned on (left side) which was easier to see than the Door/Ajar light on the dash.
I manually tripped the latch and the light flickered. I pressed down on the latch (hoping to put more pressure on the internal switch)…the light continued to flicker. Using a 10mm socket, I removed the latch, wiring retainers and disconnected the plug. The electrical plug, located about 8†to the left of the latch has 4 wires. The two on the bottom power the electrically operated latch and the two on top go to the Door Ajar switch (the one that is inside the latch assembly).
I noticed a little bit of corrosion and discoloration on one of the male pins (the plug that is connected to the latch end of the wiring). The female plug (connected to the car end of the wiring) also had some discoloration.
I plugged them back together and found that as I moved the wires/plug the light would flicker and change sometimes turning off. I unplugged it and connected my ohm meter (using small jumper wires with clips) to the two top (male) pins on the switch end of the plug. The switch tested fine. I even tested it with my homemade battery powered continuity light (wanting to test the switch under a load). I also wiggled the wires going into the plug itself, Perfect, no problems here! So, I determined the problem was truly with the plug itself. I also jumped the two female connectors with a short piece of wire (simulating the switch) and the light would come on (as it should have). OK, plug problem confirmed!
I cleaned the pins (both male and female), applied some dielectric compound and plugged it up. The light remained off for a few seconds then started flickering again! I could even hear a slight hissing sound coming from the plug (never a good sign). I tried tweaking the male pins (bending them slightly trying for a better connection) No Joy.
I clipped the wires (only the top two) from each end of the plug (red & white/black stripe wires coming from the latch).
Ford 7.3L Power Stroke (1999-2003) :: Battery Light Staying On After Alternator Replacement
Had a bad alternator, changed it, and now the battery lite stays on all the time..Changed the alternator again with a known good one, and the light is still on all the time..
View 14 RepliesFord Super Duty (1999-2016) :: 2003 F250 - Door Ajar Light Stays On When Driving
I bought a crew from a dealer, all the dome lights and cargo lights had the bulbs removed, so i put them back in and of coarse they all stayed on after you close the door, plus the door ajar light stays on when you are driving. I do notice the radio shuts off when you open the door after you turn off the ignition. Does that work on the same door switch, eliminating those?
Also are there switches on the rear doors also? Noticed that the radio isn't effected when you open a rear door. I tried to get the dealer to look at it a day after i took it home, a ford dealer at that, and they told me they tried to figure it out , and couldn't before they sold me the truck. Doesn't say much for their service department.
Ford 6.7L Power Stroke Diesel :: With Door Open Door Ajar Message Goes Away?
Having issues with the door switches. My driver door, when opened, will cause a quick "door ajar" message then go back to as if I closed the door. Only once have I closed the door to have the dome light stay on. Doesn't do it all the time but is more frequent with the cold weather setting in. I got the service truck next week so its a good time to bring it in for warranty work.....
View 6 RepliesFord Ranger / B-Series :: 1997 - Dome And Door Ajar Lights Staying On
The dome light and door ajar light on my 97 Ranger stay on. The switches are good, is there a relay or other device in the circuit?
View 9 RepliesFord - Explorer :: 2002 XLT - Door Ajar Light Stays On
i've got a 2002 explorer xlt and the door ajar light stays on. all the doors properly close. What would cause this ?
View 3 RepliesFord Excursion :: 2002 - Dash Light For Door Ajar Stays On
I own a 2002 excursion and my dash light for door ajar stays on, I pulled all of the contacts off the rear doors and hatch and found that there are no electric hook up to what I thought would be the contacts i needed to be looking at. So what relays the signal to my dash that the doors are in fact closed?
View 14 RepliesFord - Explorer :: 2002 XLT - Door Ajar Light And Bell Goes On And Off Randomly
My door ajar light & bell goes on and off at random. It's also setting off the alarm when the doors are locked. What might be causing this.
View 14 RepliesFord Excursion :: 2002 V10 - Constant Door Ajar Warning / No Dome Light On
Bought a '02 V10 gas 4wd Ex a week ago pretty cheap, and looking to fix a multitude of little issues.
I have been reading about the door ajar warning light issue, and mine alike has door ajar light always on. However, my dome/interior lights do not react to the opening of any doors/rear door hatch.
It's not out of the question that the last owner might have disconnected what he needed to to avoid fixing the problem and still use the truck. Where to start given I can't troubleshoot down to one particular door ajar sensor?
Ford 7.3L Power Stroke (1999-2003) :: Headlights Staying On With Switch Off
So was replacing my power steering pump get all done and my headlights start flickering and then stay on the switch is off it does have DRL on it but they have been unplugged for about 10 years what do I need to check
View 3 Replies