Ford 6.7L Power Stroke Diesel :: Squeak / Rattle Type Sound Coming From Front Driver Side Wheel
I'm having a squeak/rattle type sound coming from my front drivers side wheel (more rattle). It only happens when I go over a quick bump and happens going straight and while turning. 2012 f250. 87k miles. 4x4. I have a two inch block level (southern truck) up front..
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Steering Wheel Won't Turn With Brake Pedal Down?
I have an 04 6.0 psd and if I am stopped in drive with the brake pedal down I can't turn my steering wheel at all. If the truck is in park and my foot off the brake pedal I can turn the steering wheel both ways just fine. When I am driving I don't have any problems with the steering. I have checked the power steering fluid and it is full. This makes it kind of hard when I am trying to pull in and out of parking spots. What could be causing this and what the solution would be to fix it?
View 10 RepliesFord 6.7L Power Stroke Diesel :: F350 - Rear Parking Brake Sticking / Wheel Started Smoking Severely?
A few weeks back my rear drivers side wheel started smoking severely...when I stopped you could smell the brake material, feel the heat coming from the wheel, and lots of smoke. I speculated it was the parking brake that got hung up. I jiggled that cable around and then went around the block - no issue. Note: I did not leave the parking brake on.
It happened again a week later, but not as bad. I took it into the dealer today. They said heat was evident as it burned off a sticker on the disk or caliper hsg area. They have not determined yet if it is parking brake or caliper?
Ford 6.7L Power Stroke Diesel :: Squeak In Front Suspension
My new truck has developed a squeak in the front suspension every time you go over little dips and bumps in the road.Which is all the time.
View 3 RepliesFord 6.7L Power Stroke Diesel :: Rubbing / Squeak Noise While Driving
I have a weird rubbing/squeak noise from what it sounds like the rear. It occurs only after ive been driving for about an hour then it never goes away. Thought it was the pads so I put all new ones on. Maybe a bearing of some sort. I'm totally going nuts over this and cant pinpoint it!
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Squeak / Chirp From Front
2011 Ford F350, 69K miles... Just started, at about 30mph. I am hearing a Chirp from the front, speeds up when I speed up and goes away with brakes or slow below 30.
Friend thinks its the brake warning telling me its time for new. Bugging me. Just started. Never changed brakes.
Ford 6.7L Power Stroke Diesel :: 2012 - Squeak In Pillar Between Driver And Passenger Door
My 2012 Ford F350 Super Duty Crew Cab has a squeak in the pillar between the driver and rear door. Or at least that is where it seems to be coming from. It gets better and worse but it's driving me nuts. Any potential fixes?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Intermittent Squeak / Screech In Steering Column While Driving
So I've begun to notice an annoying intermittent squeak/screech in my steering column while driving, obviously aggravated by the rough roads we've got down here. I can silence it tho, if I push in/up real hard on the steering wheel, so I'm pretty confident there's some bushing or bearing in the steering column that needs some lube or maybe just outright replacement.
View 7 RepliesFord 6.7L Power Stroke Diesel :: DEF Warning Will Not Go Out
I have searched this problem and seen where some have vapor locked or whatever. Tried banging on the tank squeezing the hose etc. Last time warning came on I pulled in and tried to fill it up and it only took between 2 and 2.5 gallons. However the warning went away. This time same thing I know it has not been long enough for another fill maybe 2k miles. So I pulled in again and got just under two gallons in it.
Warning did not go out came home got on here and learned about above mentioned problem and solutions so went to Walmart and got a bottle. Tried to force feed it while tapping on tank and squeezing hose but probably not even a half gallon and still have the warning. I drive a lot so the 455 miles I have left wont last me long. I picked it up 10/23 with30 miles on it and I am right at 30k now. So am I stuck going to the stealership?
Ford 6.7L Power Stroke Diesel :: Reduced Engine Power Warning Message Pop Up
I have seen this pop up on the truck I think 3 times now over the first 4000 miles on the truck.
Usually it's when I'm on the highway around 70mph or so.
It comes on for a few seconds, then goes away. I do have an exhaust / tune on the car.
Ford 6.7L Power Stroke Diesel :: Reduced Engine Power Warning
Getting reduced engine power warning with no other lights on the dash and what is probably causing it. The truck is a 14 f450 cab and chassis model. I had just had it to the dealer for this problem and the check engine light was on and the said there were two sensors going bad on the exhaust so they changed them out and sent me on my way. Well after driving the truck around all day and not one issue it had just decided to set the rep warning again but did not set off any lights...
View 7 RepliesFord 6.7L Power Stroke Diesel :: Reduced Engine Power - Warning
Reduced Engine Power warning and fuel leak? While towing our 37 Fiver uphill a couple of days ago, the warning popped up along with the CEL. Indeed, the truck did lose a tremendous amount of power. When I found a safe place to stop, the diesel smell was terrible. Further inspection revealed that fuel was dripping down the side of the engine from somewhere above the oil filter. I limped along another 15 miles to the campground and unloaded the 5<SUP>th</SUP> wheel and brought the truck in to the dealer this morning. They aren't giving many details of their findings thus far. They say that they've talked to Ford engineers and that they'll have to put a dye into the fuel to detect the origin of the leak. They suspect the high pressure fuel pump, but by the time they remove enough "stuff" to get to the pump, they can't run the engine to witness the leak. This is my first Ford in 30 years behind the wheel and my first diesel. After 8k miles on the truck.....
View 14 RepliesFord 6.7L Power Stroke Diesel :: CEL / Low Fuel Pressure Along With Reduced Engine Power Warning
I just had my first fuel filter change (about 9,000 miles). After the shop changed both fuel filters with factory Ford ones, a check engine light came on and a "low fuel pressure" warning, along with a "reduced engine power" warning. It also stalls a lot and takes a long time to restart.
Obviously, they didn't do it right. I suppose there is air in the lines or something didn't go back together correctly.
My '06 seemed to purge itself, but this truck obviously won't. It is not even driveable to get it back to the station, to see if they can correct the problem.
The thing is, I watched them do it, so if someone can ask me the right questions as far as what I saw, maybe I can lick the issue in the driveway myself.
Ford 6.7L Power Stroke Diesel :: Changed Fuel Filters - Reduced Power And Low Pressure Warning
Changed the fuel filters. No issues in replacing.
Primed them by the book - key on 30 seconds 6 times
Now I have low pressure warning and reduced power.
All parts were FOMOCO...
Ford 6.7L Power Stroke Diesel :: DEF Warning Not Resetting
I purchased a 2011 F350 with the 6.7 with 65000 miles on it about a couple of months ago. I have put about 3000 miles on it so far about 600 of those pulling a 30' 5th wheel. Today my 800 mile DEF warning came on so I picked up a 2.5 gallon jug and it took all of it. The last little bit went really slow so I figured it was full. I had some running around to do and the warning did not reset after about 15 miles and 3 start and stops on the engine. I read that they really need to be topped off completely do I grabbed another 2.5 gallon jug and was able to get about another gallon in. I then drove it for about 10 more miles stooping and starting 2 more times. The warning has still not gone away. Do I just need to wait a little longer or is this an indication of something I need to be worried about?
View 10 RepliesFord 6.7L Power Stroke Diesel :: DEF Warning Won't Shut Off?
I just got 500 miles to empty message. On my next trip out I grabbed a 2.5 gallon at my local auto parts store. When I had 99.9 percent of the jug in, it actually started to spit back out. I got the rest in and figured I was done. It did seem strange that it only took 2.5 as I figured it was just about empty to get this message and 2.5 would only take me half way. Anyways, a few trips later and the message is still there. Do I have a bad level sensor or was it spitting out prematurely? Shouldn't 2.5 gallons have killed the warning even if it didn't fill it?
View 14 RepliesFord 6.0L Power Stroke Diesel :: Alternator Warning Light And Lose Power Steering Soon After Brakes Got Stiff
I just wanted to share with you all a cautionary tale about belt tensioners and idler pulleys. I am now a firm believer in installing the aforementioned items when you replace your drive belt. 15000 miles ago I replaced the drive belt and didn't heed the warning of some here on the forum.
For the last month or two I have noticed what sounded like road noise which I dismissed because I had just had new tires installed that had a more aggressive tread pattern than my previous tires, I also noted that the ECT had been a bit higher than normal, like running in the high 190's to low 200's on average.
Well while driving today I get the alternator warning light and lose power steering and soon after the brakes got stiff, this was followed by ever increasing ECT which got to 242* before I could get it off the road and shut down. It is too early to tell if the noises and the ECT temp rise were the result of this tensioner going out...
For what its worth the only tools required were a 10MM end wrench and a bit of skin to get the job done.
Ford 6.7L Power Stroke Diesel :: 2012 F250 Diesel Frequently Stalls Momentarily After Touch The Brake
My 2012 diesel frequently stalls momentarily after I touch the brake. This is very annoying as I drive in heavy traffic and often have to touch the brake then accelerate to merge into freeway traffic. The dealer service department said this was a 'feature' and not a flaw. Is there any way to eliminate this issue?
View 5 RepliesFord 6.7L Power Stroke Diesel :: Coolant Additive Low Warning
Got a warning Coolant additive low and checked the coolant reservoir is above the cold fill line on the big reservoir and on the small reservoir(near the Radiator neck) it also is above the fill line. What could the message be telling me? The second message is "Cleaning exhaust filter" and it come and goes. Is this a warning that I need to do something about?
View 7 Replies