Ford 6.7L Power Stroke Diesel :: Humming Noise When Shut Down Engine
My 6.7 makes a humming noise when i shut down my engine. Starts a little loud and gets softer at the end. it last maybe for a minute. But here's the catch if i stick the key back in the ignition it stops and as soon as i pull it out it starts again.
View 4 RepliesFord 6.7L Power Stroke Diesel :: Humming / Buzzing Noise From Engine Compartment
2011 F-250 Lariat with 38,000 miles. What is the cause or source of humming or buzzing noise from the under the hood that starts once I turn the truck off and close the door? Lasts from 3-4 minutes and only started noticing it in the last two thousand miles or so.
View 13 RepliesFord 6.0L Power Stroke Diesel :: Humming Noise From Front Right Side When Hit A Bump Going 65 MPH
So with the hurricane coming to my house I did the balljoints on my drivers side yesterday to prepare to evacuate today. Everything went smooth with no problems. Now fast forward to the drive to Orlando, I hit a bump going 65 and my front right side (ball joint replacement side) starts humming. I pull over and it stops, get out see nothing obviously wrong and start back on my way with no noise to speak of. It happened again and again I just slowed to almost a stop and it went away. Yesterday after the repair I took it on a trip through some crappy roads, the freeway, and all that to ensure she was safe with no problems. Maybe it is the bearing failing all of a sudden (it looked fine when I took it off). I have had a vibration at 55 consistently i think is the tires now that I replaced the ball joints (was waiting to have the tire shop check balance until after the repair) maybe that could be it?
View 3 RepliesFord 6.0L Power Stroke Diesel :: Turbo Is Whistling / Also Getting Humming Noise When Downshift At High RPMs
I have 2003 f250 6.0, had the turbo rebuilt and I put it back in, my turbo is whistling but I'm also getting a humming noise kinda sounds like a when u down shift at high rpm's idk what's going on, I try and power break as well to build up boost and the tires do not even spin...
View 4 RepliesFord 6.7L Power Stroke Diesel :: 2015 F250 - Buzzing / Whining / Gurgling Noise
I've got a stock '15 F250 6.7 w/ the Diesel Site FF67 fuel/water separator and a 50gal Titan Tank. I installed the filter + tank at the same time around 2 months ago; A few weeks ago, I started noticing an odd buzzing/whirring/gurgling noise (both while the truck was running, and while the fuel pump spins up right after turning the key on). I made a quick video of it this morning:
Ford F250 6.7 w/ Diesel site filter DFCM buzzing/whining - YouTube
I thought maybe it was a filter related problem (I got some little black plastic bits in the filter after installing the Titan Tank, despite my best efforts to clean it out thoroughly before installing) - so earlier this week, I replaced both stock fuel filters, and both filters in the DS filter. Didn't seem to affect the noise from the DFCM at all.
I guess my question is - does it sound like this is sucking in air? I've never found any leaking fuel (even after a 3000mi drive from TX to VA and back), and the truck has never complained about low fuel pressure as I've read that some others have run into. But I don't remember the DFCM/low pressure pump being this loud before I installed the new parts.
I spoke to the folks at DieselSite a day or two ago (those guys are great), and they mentioned that sometimes the Ford quick-release fittings work themselves a little loose from the fuel hose during the filter install, and that putting a hose-clamp around the hose+quick release fitting may solve this; I ordered from clamps from McMaster Carr that arrived today, so I may give that a try tomorrow just to see if it changes anything.
Ford 6.7L Power Stroke Diesel :: 2015 F450 - Gauge Not Moving - Tie Rods And Ball Joints Making Noise?
Pulled into the yard today after about a 20 mile haul with my 2015 f450 6.7.
I shut it down after pulling in, from what i knew everything was fine. 20 minutes later i started it codes and lights went off like the four of july. A wrench light, oil light, temp light and maybe even an obama light. The gauges did not even move. I shut it down, let it cool then after starting it only the CEL came on. I bought two new trucks in 2015 and both had front end alignments off. The f450 doors fill up with water when it rains.
One day after a rain I put my seat belt on and the seat belt was soaking wet. The cab corner where the seat belt spools up was full of water. The tie rods and ball joints started making sounds after 20k miles so i checked them to find they didn't have ANY grease in them!!!! The def fill tube broke off driving through a small dip in the road (i heard it pop). My first new truck....glad l have my 96 7.3.
Ford 6.7L Power Stroke Diesel :: Humming Sound After Shutdown
My 2011 is making a strange humming sound after shutdown. It seems to be related to the normal waste gate sound. I have a video....
View 12 RepliesFord 6.0L Power Stroke Diesel :: Humming Sound And The Pedal Vibrates
I am having an odd issue that i don't want to turn into a bigger one.
When I am sitting at a stop at idle and have the brake pressed i hear a humming sound and the pedal vibrates but when I am moving an press the brake it doesn't do it. Ive checked the pads all around they're fine brake fluid is fine it didn't start doing this till a few days ago.
I am just trying to figure this out before i end up going down the road one day and go to stop and have nothing there.
Ford 6.7L Power Stroke Diesel :: 2015 - Shaking Under Slight Load Due To A Small Incline And Loud Diesel Sound
So I have just over 14k on my 2015....... I love the truck but have had a few small issues. I had a water leak coming in from the roof that would leak through the grab handle. Nothing major dealer replaced one clearance light seal and they said the windshield needs to be re sealed.
Then I had a god awful irritating squeak in the dash..... It only does it late In the day when it's been hot. The dealer said it was a loose air bag. I have had the truck back a week and it's doing it again.
Those are little issues that will get resolved...... I hate having problems with a brand new vehicle but I understand it happens and that's what warranty is for.
I also reported a bad shake to the dealer...... The truck will shake very violently and have a very loud "diesel" sound. It's very specific at when it occurs. It has only done 4 times in the past 6 weeks including today. The odd thing is the 4 times it has done it has been the same time of day in the exact same spot on the exact same road!!!!
Basically I leave my office sit in some traffic and by the time I get to the parkway it has been35 minutes or so. Only happens in 6th at 60 which is roughly 1,400rpm a slight load due to a small incline and it shakes real bad! The typical "diesel" sound you get when under a load is very pronounced almost to a knock. It will continue to do this as you slowly increase throttle until it down shifts and then goes away. I also caught it doing it and I manually shifted to 5th and it went away.
Because of the rpm at which it happens with slight load only doing it in 6th I lean to a Trans issue and more so a converter problem. It feels like converter shutter. I just don't understand the engine sound.
I gave very descriptive info to the dealer..... Several techs drove it and could not duplicate. I just picked the truck back up last Thursday and the dash squeak is back and the shake happened yesterday and again today. So I am a bit irritated to say the least.
I really hate the fact that I know there is a problem but I also understand if a tech can't duplicate it he can't diagnose it. However today I did get a video of it with my phone so they will know I'm not making this crap up!
Ford 6.7L Power Stroke Diesel :: 2011 F250 - Fuel Pump Is Humming Really Loud?
I just recently bought a 2011 powerstroke f250 and while running I can hear the fuel pump humming pretty loud. Is this a possibility that it's going out? Or is this normal?
View 3 RepliesFord 6.7L Power Stroke Diesel :: 2015 - Low Fuel Pressure - Reduced Power?
1st diesel was a 1997 F350 dually (White Lightning). Upgraded last year to a 2015 F350 (The Rocket Sled)- the kids named it hahaha. Had to take the 6.7 (9200 miles) into the shop... Last Sunday I took the truck out and about 5 minutes from home I got the low fuel pressure warning. Pulled over and tried to purge air out of fuel system- the low pressure pump was making a terrible racket. Turned around and limped home- reduced power came on soon after. Parked it until I could get to the dealership on Tues. Long story short- dropped it off at the dealer (low pressure pump still making noise/ no low fuel waning, just CEL light).
Called to check status today- dealer can't seem to duplicate problem. Service advisor said if mechanic can't find anything wrong, service manager was going to take it out and try to duplicate. The is the 2nd time I've got the low fuel pressure warming. The first time (around 4000mi. ) was in winter- I changed out fuel filters and it went away. I was towing the 5th wheel. Just had to vent-I have to get this figured out. I wouldn't thing the filter could get clogged within 5k miles. Have a camping trip scheduled next week!!
Ford 6.7L Power Stroke Diesel :: 2015 - No Outside Temperature Display
I cannot believe outside temp is not available on 2015's...I don't see it on any screen or in the manual.
View 13 RepliesFord 6.7L Power Stroke Diesel :: 2015 - Subwoofer Not Working?
Why my subwoofer won't work? Dealer is stumped. Dealer changed out the speaker and amp. They have been waiting on the Ford Hot line for over a week to get a direction and nothing yet. The speaker does move ever so slightly on highest level.
View 12 RepliesFord 6.7L Power Stroke Diesel :: 2015 - Front End Grinding?
Since I bought my F350 last Jan. I have several times had prolonged instances of a severe grinding noise coming from the front end, seemingly the left side. At slow speed in a turn (shallow or steep) a horrible grinding sound is apparent as well as a vibration in the steering wheel. At 9k miles a dealer said it was the wheel bearings and replaced both sides. I now have 12.5K and it is worse than ever. My local dealer says it is normal but that has to be bull. It is is worse after I drop my fiver after towing. It is a 4x2 with the 6.7 diesel. I love the performance but this front end issue is a real problem.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2015 - Steering Too Sensitive?
With the break in complete on my 2015 f250 it seems as though the steering is extremely sensitive. I find that any slight movement or God forbid, (wind), it's hard to keep this truck in the lane without having to jerk on the wheel and fight it constantly.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2015 F350 Versus F450
I am on the market for a 2015 Ford F350 with an 11' Royal utility body on the back for my electrical contracting business.
Ford have come back to me and said I need a F450 as I am going with the supercab, the F350 can not handle the 11' utility body.
I have head that the F450 can cost more in Insurance and use more diesel. I contacted my insurance company and they said it wouldn't change to much, this is in CA.
Is there any differences between the F350 and F450 apart from the rear axle and larger brakes. Also if there a major difference in MPG.
I currently have a Ford F150 Limited and love it!
Ford 6.7L Power Stroke Diesel :: 2015 - Low Fuel Pressure Light Comes On
I know it's posted a few places but I have a reoccurring problem. Whenever my truck goes below 100 miles of remaining range the low pressure light comes on. Within 10 miles the reduced engine power comes on.
First time at 11k miles, at the dealership for 4 days, test fuel filter for crystallization, tested the diesel fuel, checked for leaks and then reset the codes and gave it back to me. Said it only popped the code for low bank 1 pressure.
Now 12,800 miles, driving home from work. 87 miles remain on range, pulled in a gas station and the low pressure light comes on. Threw 25 gallons in it and made it about 15 miles. Currently sitting in a Walgreens parking lot waiting for a tow truck with the low engine power light on. They will only tow it halfway to my house to a dealership since I am out of road side assistance range.
Circumstances right now, its 65 outside so it's not gelling like many other people. I can here the pump running and it spooled up real high when I tried to restart it but did not fire. Grabbed the code reader and it had 8 general codes all for low fuel bar pressure.
Pretty happy that I dropped almost 60k on a truck that hasn't even made it a year yet and not even 13k miles on it
Ford 6.7L Power Stroke Diesel :: 2015 - Trailer Brake Set To 10 To Work Well?
I have a 15 F350 DRW 6.7 pulling a 19K fiver with 8K axles and disc brakes, I have to have my brake controller set at 10 to get the brakes to work well. The pads are good, just bled the system using a power bleeder, controller is set to electric over hydraulic with max gain. Why I need to have the controller set to max?
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2015 - Changing Oil From Conventional To Synthetic?
New diesel owner looking for some info? Currently approaching 9k miles. My first oil change was done by the dealer. I was looking at my owners manual on what weight of oil to use. I am thinking of going to a 5w-40 oil but all seems to be synthetic. Do i need to do anything special if i am going to change from a conventional to synthetic?
View 7 Replies