Ford 6.7L Power Stroke Diesel :: 2011 F350 - Lost Power Intermittently?
Currently truck is in the shop after having multiple episodes where it lost power. It has 47,000 miles on it. When pushing down gas pedal, just does not want to go. Very slow to shift through the gears and get to highway speed. Turbo was not there, and there was also a hard shift/jerking from 2nd - 3rd. Did notice the traction control sensor kick on a couple of times....which was just replaced since a hole rubbed through the wiring. (took it to Ford twice before they found the problem)
They told me today that the code generator said to look at wiring but they did not find anything (heard that before) and that the fuel is possibly contaminated with DEF. If that is the case, someone is messing with my truck! What I don't understand that if the DEF does turn out to be in the fuel tank, wouldn't we have the problem continuously and not intermittently over a month after driving thousands of miles and going through numerous tanks of fuel? We drive and average of 60 miles per day just for work, half interstate/city.
Ford 6.7L Power Stroke Diesel :: 2011 F250 - Spitting And Sputtering And Lost Power / Fuel Leak
We got "bad" gas in Feb, 2016, had to replace entire fuel system. Haven't driven the truck but 4000 miles. Last week, she started spitting and sputtering and lost power. We could see fuel pouring out. NO CEL. Towed (AAA has paid for itself several times over with this truck) to dealer that replaced the fuel system, still waiting to hear from them. Does this sound like it should be under the warranty for the work they did? We have averaged a huge repair bill about every 3-4 months on this truck, 2011 F250 Lariat, 8cyl, 6.7L, since we bought it 2 years ago.
View 1 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Motor Backfire Through Intake - All Boost Lost
Under light acceleration without any load. The motor backfired through the intake. Lost all boost. Other than the backfire noise the motor seems to be fine except for lack of power due to no boost. The motor has been serviced by Ford Dealer since new. All services have been done at 5K mile intervals. The last service was done at 60K miles. All filters had been changed at that time (oil, air and fuel).
I do have experience with turbo/ supercharged motors. My experience would tell me that the problem was with a lean condition at the time of the backfire. Plenty of fuel in the tank and no low fuel pressure warning. I have seen low fuel pressure warning in the past but it happened during the winter when temps were negative 40 degrees. The truck is still under extended warranty so I really don't have concerns regarding repair costs.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Lost One Gallon Antifreeze Coolant
Had my oil changed on my 2011 F350, and the tech said that I lost one gallon of antifreeze coolant. Where could the coolant have gone? We could not find a radiator or hose leak. I am afraid that the coolant somehow got into the engine oil, and may have damaged the engine. I have 46000 miles on the truck.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2013 - Fender Emblem Removal?
How to get the fender emblems off? I am talking about the F250 Lariat on the front fenders. I checked out the dealers schematics and it didn't work much.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Emblem Cracking / Starting To Peel And Bubble Up On The Front Grill
Just like our fleet of 06' F-150's, my emblem on my 2011 F250 is starting to peel and bubble up on the front grill. Every 06' had their rear and front emblems replaced close to 3 times until we just gave up and lived with it. I thought Ford fixed this problem? Going to the dealer tomorrow to get a warranty repair.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Blue Smoke When Warm / Smells Like Oil Not Diesel
Started today. 2004 with 235k miles. Owned for last 10k miles. Engine was recently studded, has egr delete and ccv bypass. Runs and starts fine. New Ford oil cooler too. Checked for codes. None for misfires, perdel are reading 0.
If it sits, on start up clear exhaust, as it warms, more blue smoke. Smells like oil not diesel.
Researched before asking and found leaking turbo seals can cause this. So we pulled the intercooler tube in front of the engine going to the intake expecting to find oil residue. Nice and dry. Was this the correct one to look at?
When we got the truck we had the dealer do a relative compression test and was within limits, it did need 1 injector that we replaced. What would be the next logical place to look?
Couple more points:
- Just changed oil last week, checked today, it was slightly over full.
- Coolant is fresh and has not changed level since we got it.
- Pulled fuel filter to see if any oil, but it was nice and clean.
Ford 6.7L Power Stroke Diesel :: 2006 - Oil Changed But Engine Oil Is Of Black Color?
Ok, so I have read on this subject and there are lots of posts about this being normal but why? What causes this? I have recently owned two 6.0's and neither of them had black oil even when I changed the oil! My last 6.0 a 2006 had oil that was nearly the same color out of the drain plug as the oil I was putting in! Why this happens on the 6.7.
View 10 RepliesFord 6.7L Power Stroke Diesel :: Tailgate Won't Sit Level When Opened?
I have noticed that the tailgate doesn't sit level when opened, the cables are too short for it to horizontal. The rear of the gate is 1-1/2" higher than the front. The cables need to be about a 1/2" longer for it to sit right.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Tailgate End Cap Molding Broken
Any luck reattaching tailgate end cap molding? Mine has a few broken tabs and is hanging on for dear life. But if I can reattach I would. I know I could drill a few holes and run in some self taping screws, but that would be quite ugly.
The tab(s) broke when lifting the heavy gate with the step closed one to many times. Using the left side now to close.
Part number 8C3Z9941018AA.
Item 2 in below image...
Ford 6.7L Power Stroke Diesel :: Tailgate Increasingly Hard To Open
My tailgate is getting increasingly hard to open (and it's not me getting weaker!). I now have to pull pretty hard towards the left side of the handle to get it open, whereas I used to just pull in the center without much effort and it'd fly open.
View 13 RepliesFord 6.7L Power Stroke Diesel :: Tailgate Rubbing On Right Quarter Panel
I just identified an annoying squeak as the right side of the tailgate, right at the hinge, rubbing on the section of the rear passenger side quarter panel (one with FX4 decal) where it curls around to the rear. Any way to easily adjust the tailgate slightly to the drivers side? When the tailgate is up, the gap is noticeably smaller on the passenger side, and when down, the edge of the tailgate rubs the edge of the quarter panel, paint to paint.
View 1 RepliesFord 6.7L Power Stroke Diesel :: Tailgate Latch Handle Stuck?
Backed up into a bush and it seems it was a little bit more stout than expected. There was a large branch that pushed my tailgate latch so far up now it's stuck. If you look at the pics below, there's a tab on the right hand side that was over extended and now stuck/holding the handle up. I'm a little reluctant to just try hitting it as hard as i can out of fear that I'll snap something.
View 5 RepliesFord 6.0L Power Stroke Diesel :: Blue Light On Dash?
Simple question for the group as I learn about my new B.O.A.T 6.0 diesel.
What is that blue light left of the steering column yet on the dash?
Ford 6.0L Power Stroke Diesel :: Blue Smoke On Startup?
two days ago i noticed First start in the morning the truck billows out blue smoke. In mean is enough that looks like an old 2 stroke dirt bike. Quite alarming. I've had HHS in for 4300 miles or so. I hope I did not mess the engine up by towing With the HHS in there. The injectors have been getting loud an indication that i need to change the oil again. The truck always gets louder when nearing oil change time. It reminds me of an old chevy with bad valve seals. Would turbo seals just go. The smoke goes away after driving maybe 2 min well i can't see it while driving. Truck runs smooth doesn't stutter or miss. It has been acting like the stiction is happening upon first starting after sitting for 6+ hours.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Blue Smoke At Idle?
I noticed a few puffs of blue smoke a while back as well as oil at the seam of the exhaust tubing. I attributed it to bad turbo oil seals and proceeded to rebuild the turbo. Changed oil at the same time from T6 to T5, 15-40. The blue smoke is quite a bit less, but still shows at idle and not all the time.
First start up of the day, slight haze. I leave the house when the oil temp gets above 100 and drive easy until it gets to 160. I will get a pretty good train of smoke until the oil temp gets above 180 at every stop while I'm idling. When the oil temp gets above 180, it will only smoke every 3rd or 4th stop at idle. If I hold the brake and get the RPM's over 1,000, the smoke dramatically decreases, if not completely dissipates.
I do have the CCV rerouted and am wondering if it is affecting the operation of the engine.
Ford 6.0L Power Stroke Diesel :: Slight Drip From The Blue EGR Hose?
So I recently had the head gaskets done at Ford. All is good but there is a slight drip from the blue EGR hose. It made a 3" circle on the driveway after 8 days. Coolant level is still fine. I really don't feel like dropping it back at Ford. Think I can just twist the hose to tighten it a bit or is a new hose in order? It is only 2 yrs old and was not replaced with the head gasket work.
View 10 RepliesFord 6.0L Power Stroke Diesel :: Burning Oil - Blue Smoke Under Any Load
2005 F250, 6.0, 60K miles, recently (within last 1K miles) had ARP studs, EGR delete and new oil cooler installed. Shortly after (5-6 weeks later) I noticed blue smoke under any load (taking off from red light, backing up) but not at idle or startup. Was using the "Performance" SCT canned tune after the stud install, but had the "65HP Tow" canned tune installed when I first noticed the smoke and now back to stock after noticed the smoke as a precaution. Everything else original except FICM, filters and batteries and use 5w40 Mobil 1 since new.
View 14 RepliesFord Super Duty (1999-2016) :: 2008 - How To Replace The Emblem On Tailgate
Odd thing happened. All of a sudden the factory emblem on my 2008 tailgate totally lost all of its blue and is now pure chrome. Happened just like that.
Anyway, is it screwed on and do I need to pull the panel on the tailgate to remove it? Here's the tailgate on my truck for reference.