Ford 6.7L Power Stroke Diesel :: 2013 - Clunking Noise Coming From Steering Column - Body Shift?
So my 2013 is making a strange noise that seems to be coming from the front end when turning and going over a bump. While riding with the Service Writer, we also felt that the noise could be coming from the rear of the truck. I think it's two seperate issues, he mentioned something about the rear end noise being "body shift". So two questions:
1. What a "clunking noise" would be coming from around the steering column.
2. What the heck is "body shift"?
Ford 6.7L Power Stroke Diesel :: 2011 - Hum Noise After Shut Down
My 2011 6.7 just started making a hum noise after shutdown. I've read that it might be the wastegate solenoid. Is there a TSB for this. My truck is tuned so hopefully my dealer will be tuner friendly.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 F350 - Losing Power - Rough Noise - Vibrating?
2011 F350 diesel with 10,000 miles. I have been experiencing problems with the truck loosing power, making rough running noise (pinging like an older diesel), and vibrating. As though the motor is bogging down. It usually occurs on small inclines or hills with the truck in higher gears and low rpms. It will also occur running on flat ground 65-70 mph. Had it occur once while turning the truck around in 1st gear and low rpms. Depressing the accelerator will bring the truck out of it.
This problem occurs randomly sometimes a couple of times a week to not at all. Took to dealer and they found no codes and of couse it didn't do it on the hour long test drive I took the mechanic on. However they did say they had two other owners come in with the same complaints, but could not get trucks to repeat the issue. Problem usually occurs in the hotter part of the day, maybe just coincidence. I had seen similar posts with this problem but no conclusions.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Whistling Noise At 75 MPH
I've got a 2011 F350 Lariat crew cab and when i get up to 75 mph with a cross wind, there is a whistling noise. it sounds like a turbulent whistle as if its blowing across the ribbed portion down by the wipers. I tried to get audio but for some reason my phone wont pick up the noise, but its extremely loud at times. Sometimes it will wake up the kids if they're napping in the back seat.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Thumping Noise Under Hood?
My 2011 F350 - 6.7 has developed this KRAZY thump, snap noise under the hood, loud enough to be heard inside the cab, and I cannot find out what the heck it is. It is not directly connected to the motor, you can rev it and the noise does not change. the thump is like, every few seconds or so, especially when the motor is cold. I am afraid this is a 2000 dollar noise and the truck is out of warranty.
View 8 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Typewriter Like Noise At 36k Miles?
So, I recently had my 4th oil change done at the dealer, just under 36k miles. Same dealer that has done /all/ service on my 2011. They used the same parts and materials as always, but this time there is a very noticeable "typewriter" sort of noise at idle. Much louder than the normal chatter, and not consistent - tick.... tick-tick... tick.... tick... tick tick tick... etc. The diesel tech shrugged it off: "Ford says it's nothing to worry about." As it has never happened before, and it sounded a /lot/ like lifter noise resulting from a low-oil condition, I asked him to put in another quart. He did, and the noise went away. Mostly.
Now I've only driven about 75 miles since the oil change, but the last time I drove it, I had the windows down and noticed what sounded like lifter noise again. Not the same pattern at idle. This time, it was under light acceleration and the frequency increased with engine speed. It's going back to the dealer in the morning. Not only for this, they're also on their third attempt in the past 2 weeks at fixing a squeak in the dash. But while it's in, I want this noise to go away.
In spite of all the posts about how this sort of noise it typical with new oil, and goes away in 10-2000 miles, I'm concerned. Nothing has changed other than the fresh oil and filter. In the last 3 oil changes, this condition never existed. Am I being reasonable?
Ford 6.7L Power Stroke Diesel :: 2011 - Turbo Noise At Exhaust
I have a 2011 that does not currently have the complete factory exhaust system on it and no muffler. With the nice weather I have been driving around with the windows down and hear a noise out of the exhaust that sounds like tires spinning on wet pavement when I let off the throttle or at some shifts of the transmission. Boost seems normal, and don't hear any noise while under load. I think it is just the VGT closing and making the noise. With deleted sys heard this noise in exhaust?
View 4 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Loud Squealing Noise With No Boost?
heard a loud squealing noise and now no boost. 2011 with 90k miles
whats my options and what would it cost.
1. replace with factory turbo
2. replace with upgraded turbo and tune?
Ford 6.7L Power Stroke Diesel :: 2011 - Drive Shaft Making Clicking Noise?
My buddy has a 2011 250 and is having some weird issues with a clicking noise. It started out when you put the truck in gear (D or R) and touch the gas it would click. Seems to be coming from the middle to rear part of the truck. Now it clicks when he's driving. This all started after he got 35's and a leveling kit. It's taller springs in the front and added a block in the rear. It has less than 15k on it.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 F250 FX4 - Whining Noise On Cold Start Up
When I start the cold engine mine makes a loud whining noise. I took it to the Ford dealer and they said that the sound is normal and that it's the turbo's. I think I'll take it to another ford dealership and get a second opinion, The service guy has the same truck as me and his was making the same noise on cold start up and they told him it was the turbo's also. Something's not right about the noise.
View 14 RepliesFord 6.7L Power Stroke Diesel :: 2011 F250 - Clicking Noise When Accelerating From A Stop?
I have a 2011 F250 6.7 Turbo Diesel I recently purchased. I am hearing a noise when accelerating from a stop. The only time I'm hearing it is when the window is down. The noise sounds like someone is tapping an aluminum pop can. It is easily reproducible as well. I decided to get under the truck and have my wife toggle the transmission from park to reverse. They noise does not occur unless one foot is placed on the brake and the accelerator is lightly pressed. (My wife had the opportunity to run me over and claim it as an accident but lucky me she decided not too). Below is a video. I had a hard time locating the noise. It sounds like it may be coming from the exhaust or drive shaft. The drive shaft does not spin when toggling from reverse to drive but the ticking noise can be simulated and heard when lightly pressing the gas while holding the brake. Something need lubed somewhere?
Clicking noise - YouTube ....
Ford 6.7L Power Stroke Diesel :: Clunking Under The Truck When Go Over Sharp Bumps
I know lots of you say these stock Rancho's suck, but I'm wondering if it's just the ride that improves? I have some clunking under the truck when I go over "sharp" bumps that normally I would say is something loose or maybe a bad ball joint...except I have it in the rear as well. Is that a symptom of these stock ranchos? I don't mind the stiff ride, it's the noise that's bothering me.
View 3 RepliesFord 6.7L Power Stroke Diesel :: 2014 F250 - Clunking Trans And TPS Fault
I just bought a new 2014 f250.
He says since he has purchased the truck the TPS sensor would occasionally go off saying there is issues with the tires. Tires are fine yet the light chimes on after being reset shortly. Been at the dealer for a week and they haven't really touched it I was wondering if there is any know issues.
Also my dad had the truck in 4x4 and when he puts the truck in park it made it a loud clunking noise. Ford is said there heavy duty line was full so they didn't look at that ethier. He needs the truck for the weekend so he is picking it up tomorrow, he will return it when he can but does this sound familiar as well?
Ford 6.0L Power Stroke Diesel :: Transmission Slipping - Clunking Intermittently While Shifting?
Hauled my last 2 cord of wood for the season, and I now have a pretty good 3-5 slip in and an intermittent bang/clunk when its shifting. So I've put this off for a long while now, and I want to fix it. I've done my research, and I don't really feel like I'm any further ahead than before I did my research.
I'm looking for recommendation's on what transmission and or kit is the best for my truck. I pull my 5er 10-15 times a year mostly up and down the east coast. We are looking to get a new 5er with a bunk house, my goal is to stay in the same weight neighborhood, I run 13-13,500 now depending on where we are going. The goal is to be able to get maybe another 3-5 years of use from the truck, maybe more, and then upgrade to a newer truck. So let me hear what you all recommend as I'm going crazy and probably over researching what I'm gonna do...as usual.
Ford 6.7L Power Stroke Diesel :: 2011 F250 - Fuel Gauge Inoperative After Put Gas In Diesel
Purchased 2011 3 weeks ago. Due to not paying attention, put gas in diesel. Had tank dropped and drained but after reassembly, fuel gauge inop. When turn ignition switch on, get normal sweep of all dash gauges but fuel gauge does not read. 2nd tech says sender okay, must be gauge. Dealer ssays if it sweeps, it isn't the gauge. 011 F250 6.7L.....
View 7 RepliesFord 6.7L Power Stroke Diesel :: Clunking In Front Brakes After Replacing Brake Pads And Turning Rotors
Ok so we just replaced our front and rear brake pads and had the rotors turned. Our rear brakes are fine but both our front brakes now make a clunking/popping noise when we brake.
View 4 RepliesFord 7.3L Power Stroke (1999-2003) :: Clunking Noise After Speed Dropped To 20 MPH
2001 ford excursion 7.3l diesel.
So I tried to go to work today but the truck said no. it started out fine then out of no where it felt as if someone slammed on the back brakes engine still revved up like normal just didn't want to go. speed dropped to 20mph then i heard a clunk. after that it was fine until it hit 20 mph again. it did the same thing again.
So I got mad at it thinking the trans went out gave it the beans and it shifts into all gears but did not feel like it had power. i did pull over and check the fluid looked a little orange. when got back in the truck i did notice the od off light blinking?? drove the truck home was shifting fine but hear this awesome sounded like a hand grenade rattling around underneath. when i got home notice fluid coming from the bell housing(out of the bottom).
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Loss Of Power And Stinks?
My uncle was pulling his fiver to the beach yesterday with his 2011 f-350 6.7. He lost power, the truck got very loud, and there is a very strong stale kerosene smell in the cab. Strong enough to require the windows be down for ventilation. He was able to limp on into the campground and has an appointment with the dealership Monday. The truck has 19,000 miles and is still covered under the extended warranty.
View 8 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Power Loss - No Boost And Codes?
Truck = 2011 F250 150,000 miles, no modifications, stock.
Truck lost power yesterday, no boost, and no codes. When driving on Friday, I started moving from a red light. The truck seemed very sluggish. Then I noticed it downshift going up a small hill that it never downshifts before. I looked, and noticed the turbo gauge at 0, no boost. I pulled over, turned it off, then restarted it, but still no boost, and the truck is very under-powered. I looked over the area, and do not notice any leaks, also no leaks underneath. I hooked up my OBD reader, and no codes., the boost gauge is on zero, and the truck has lost significant power. I no longer hear the turbo spooling.
I have spent the past several hours searching sites and forums (Started with FTE ), and it seems that most believe a restart of the truck has solved it for them. However, this is not the case for me, a restart, even after letting it sit overnight did not resolve the issue.
I did see one reference that replacing a NOX sensor solved their problem. This brings up some interesting truck history. Back in June 2017, my truck threw the following codes, P207F and P20EE.
P207F - Reductant Quality Performance
P20EE - SCR NOx Catalyst Efficiency Below Threshold (Bank 1)
The message said I have 200 miles until reduced power. Since it was a Friday, not much I could do at the time so I let it sit overnight, and then the next morning the message was gone. I plugged in the OBD reader and cleared the only remaining code (P20EE), and its been a very happy truck until yesterday.
So my question, can a bad NOX sensor cause the issue of loss of turbo boost, with no codes? Is there another possible cause?