Ford 7.3L Power Stroke (1999-2003) :: Oil Leak / Dripping At The Back And Bottom Of HPOP
Have another oil leak, just finished the pan flange gasket last weekend, made it 150 miles, now a new leak.
Took the spider out and everything on top, cleaned the valley up good, the fired the truck. HPO lines are good, but have a drip off the back and bottom of the HPOP, when I reach under it from the back, its right below the large 2 inch circle.
What this might be? was thinking possible orings somewhere under there where it seats, but its been 6 years since I replaced all the orings, don't remember exact layouts.
Ford 6.7L Power Stroke Diesel :: 2011 F350 - Air Water Intercooler Leak?
2011 6.7 F350 .... 120,000 miles ....I have been smelling anti-freeze for the last couple of months but have been unable to find a leak. Going through a minor amount of fluid but no indication on the ground ...
Searching deeper today I see the bottom of my intercooler is wet - remove the air hose and there is some fluid. I am assuming there is NOT supposed to be fluid in the air intake hose - correct?!?!
Any thoughts or history on these intercoolers letting-go and leaking internally?
Ford 6.0L Power Stroke Diesel :: Fuel Leak / Dripping On Top Of Engine At Filter
I'm dripping fuel on top of the engine at the fuel filter . Where the line ties into the filter canister , there is a small plate that's attached with small Allen screws its dripping between this plate and the canister .... I assume there is a gasket/oring that is causing it ...... What is the part number or correct description so I can go to ford dealer and get one.
2007 Ford 4X4. 6.0 diesel
Ford 6.0L Power Stroke Diesel :: Coolant Dripping Under Degas Bottle / Boot Oil Leak
I have coolant leaking from under my degas bottle. There was a spot on the driveway this morning and upon investigation, I saw a drip hanging from the bottom of the degas. No liquid on top at all. Where this is coming from? Bottom hose?
Also, the boot that connects the tube (right side while looking at front of truck) to the elbow that goes into the intake is leaking oil and making a mess. Whats the best way to fix? Remove boot, clean up, and put back on? Or replace boot? If replace, where can I get that boot?
Ford 6.7L Power Stroke Diesel :: Minor Oil Leak On Bottom Of Cylinder Under Oil Fill?
I was draining my separator and noticed some oil accumulating on the bottom of the cylinder head right under the oil fill on the drivers side. My truck is 12 days out of engine warranty.
It's last service was probably around a year ago when the engine was torn down to replace the exhaust valves per the TSB.
Ford 6.7L Power Stroke Diesel :: Secondary Cooling System Leak / Dripping From Center Of Engine Bay
Turns out I've lost nearly all of the coolant from my secondary cooling system and am trying to diagnose the problem.
Things I noticed:
-All of the hoses appear to be in good condition.
-Coolant is dripping from the center of the engine bay.
-After inspecting the turbo area, it appears the valley below the turbo is wet.
The intake manifold is still on the truck, so I haven't been able to get a better look. Is there anything else near the area I am describing that has coolant? My guess is the turbo water inlet?
Perhaps this : Coolant leak on the 6.7 Powerstroke diesel - YouTube...
Elantra XD (2001-06) :: Transmission Fluid Leak - Dripping Down Onto Passenger Side Half Axle
I have recently replaced the clutch, clutch master cylinder, clutch slave cylinder, Strut tower mounts and brakes on my 2002 Hyundai Elantra 5 speed. Everything is working properly but now I have a transmission fluid leak. I can not locate the exact location. It appears that it is dripping down onto the passenger side half axle where it connects at the transmission.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Fluid Leak On Top Of Trans
I was spraying undercoating yesterday and noticed a trans leak, it looks like its coming from the top of the trans. Not a lot of fluid just enough to coat the trans on top. I tried using an inspection mirror but i still cant see the leak.
View 4 RepliesFord 6.7L Power Stroke Diesel :: 2013 F350 - Pink Fluid Leak
Every morning I walk out into my driveway and I see several pink drips under the front of my truck. I assume this is the antifreeze, its not tranny fluid.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Checking Intercooler Coolant Levels?
I didn't realize the 6.7 had two places that you need to monitor your coolant level. I've kept an eye on my coolant reservoir for the rad due to radiator failures reported but just today noticed there was another one for the intercooler. Mine was quite low. I'm sure most of you knew it was there but for those that didn't, keep that baby topped up I can't imagine having a hot intercooler is good.
View 7 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 - Leak Around The Brake Fluid Reservoir
I have a new *to me* 2005 F250 and last night I noticed there is a leak around the brake fluid reservoir where it connects to the frame of the truck. Everything seems to be in good order not sure exactly whats causing the leak. It only when driving and for a short while after shutting the truck down, everything seems to be in good order but still it drips a lot.
View 9 RepliesFord 6.0L Power Stroke Diesel :: Transmission Fluid Leaking?
So, had a transmission fluid leak. Couldn't find the leak so I went to a transmission shop. The diagnosis is that a snap ring broke and resulted in a hole in my tranny, something about reverse gear pressures weakly designed snap ring.
Not too happy about this, being that I had thought that the transmission was the strong point of my truck... Is this common?
Ford 6.7L Power Stroke Diesel :: Muffled Pop Sound - Intercooler Boot Failure
I was pulling our 14k fiver home after a weekend at the lake and I heard a muffled pop sound. About a minute prior I had checked the gauges and everything was normal. It honestly sounded like a chinabomb tire on the ttrailer had popped. Puled over and all tires were good so I popped the hood .....
Here's the bottom half. Is this possibly a warranty item? 2011 with 61k. And no mods. Plus a lot of oil on everything is that normal?
Golf IV / Jetta IV :: Coolant Leak / Dripping From The Bottom Of Car
My 2000 Jetta 2.0 has a coolant leak. I searched and found a lot of mentions of the flange on the driver's side, and I have coolant dripping from the bottom of the car in a location that seems consistent with that, but I felt all around the flange and the hoses that are connected to it and it feels dry.
Where else could it be coming from? (yeah, I could jack it up climb under and look, but I haven't had time yet). I also seem to have an oil leak around the same location, but the dipstick tube was cracked near where it went in to the engine so I'm hoping that was the source of the oil.
Ford 6.7L Power Stroke Diesel :: 2016 F350 - White Crystals Around The Reductant Injector - DEF Fluid Leak
Recently while changing the oil, I noticed a great deal of white crystals around the Reductant Injector. This is the point where DEF is injected into the exhaust. There is a heat shield around the connection and that shield was moved up by the growing crystals.
The hose that connects to the injector is simply one of those press lock types, i.e., you press on either side of it to remove it, and it simply locks in place by pressing it on the tube. This is the point where it seems to be leaking.
I have been tracking my DEF usage pretty close and I seem to get around 4900 miles from five gallons of DEF. No towing whatsoever, daily commuter 30 miles a day.
It's a 2016 F350 6.7 PS with 12,000 miles.
Ford 6.0L Power Stroke Diesel :: 2004 - Automatic Transmission Blowing Fluid Out Under Load Only
I have an 04 F350 automatic blowing fluid out under load only. Had it serviced the first time it happened two weeks ago. They found no issues and replaced the fluid and filters. Drove truck about fifty miles, no load, no problems. Took her out this morning in tow/haul mode with load and made it about 20 minutes before I noticed it warming up. Pulled over and it is blowing fluid out the right side of the pan.
View 6 RepliesFord 6.0L Power Stroke Diesel :: 2004 F250 - Coolant Loss - Wet Spots On The Tube Coming From Intercooler To Turbo?
My friend is working on a 2004 6.0 F-250 and it has used 75% of the coolant in the overflow bottle in 5 days. Can't smell coolant either. The inside of the tailpipe is wet soot black and there are wet spots on the tube coming from the intercooler to the turbo at the turbo and the intercooler. He's thinking EGR cooler.
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Brake Fluid Dripping Onto Front Tire - Use Cruise Control?
OK, so a friend's F150 just went up in flames in his driveway and he told me that the problem was the hot link behind a plastic/ rubber barrier at the main brake cylinder. I had a recall notice on my old truck but since I left the US and took the truck I never paid much attention to it, thinking typical overkill. Now I already heard from another buddy who caught lit brake fluid dripping onto the front tire and got the fire out before it spread and looked up the info today. Looks like our trucks are affected. Best to unplug the harness that goes into the brake master cylinder will prevent this problem from occurring? I never use cruise where I am, the roads are too small and slow.
View 6 RepliesFord 6.0L Power Stroke Diesel :: Coolant Leaking On Back Of Motor On Both Sides
On our '04 Ex with 195 on the clock I've discovered a pretty good leak dripping. I crawled under it an coolant appears to be dripping off the back of both exhaust manifolds.
Less than 1000 miles ago we had an oil cooler and egr was pulled and freeze plugs installed by an excellent well respected 6.0 diesel shop. I don't think both gaskets could have blown at the same time creating two leaks. It runs fine, degas bottle still has coolant in it.
I've seen other threads that point to the heater core hose and more commonly the "orange" egr hose. It appears that an egr delete removes the hose - I think... but would that Blue / orange hose be there if the cooler was just capped and electrical unplugged?
The shop is going to look at it Monday but I'm trying to understand it better ahead of time.