Ford Fuel System :: Leak / Dripping On Top Of Engine At The Fuel Filter
I'm dripping fuel on top of the engine at the fuel filter . Where the line ties into the filter canister, there is a small plate that's attached with small Allen screws its dripping between this plate and the canister .... I assume there is a gasket/oring that is causing it ...... What is the part number or correct description so I can go to ford dealer and get one. It's a 2007 Ford 4x4 6.0 diesel.
View 2 RepliesFord 6.7L Power Stroke Diesel :: Leak From Top Fuel Filter
I got fuel running dn from top fuel filter it looks like an filter hasn't been changed in a long while what could have happen?
View 5 RepliesFord 6.0L Power Stroke Diesel :: Small Leak On Upper Secondary Fuel Filter
(E350 van)... I smelled diesel fuel inside the van tonight and used my flashlight to investigate the leak. The cover around the blue spring is damp.
Before I remove every again to gain access to the filter housing to fix the leak, what I am may encounter. Seems like a good time to do the blue spring upgrade. Can I access the egr valve to inspect and clean?
What are the possible areas to check for the leak? Sometimes finding little problems leads to finding big problems. When my FICM went out I discovered the battery terminal clamp was broke.
Ford 6.7L Power Stroke Diesel :: Secondary Cooling System Leak / Dripping From Center Of Engine Bay
Turns out I've lost nearly all of the coolant from my secondary cooling system and am trying to diagnose the problem.
Things I noticed:
-All of the hoses appear to be in good condition.
-Coolant is dripping from the center of the engine bay.
-After inspecting the turbo area, it appears the valley below the turbo is wet.
The intake manifold is still on the truck, so I haven't been able to get a better look. Is there anything else near the area I am describing that has coolant? My guess is the turbo water inlet?
Perhaps this : Coolant leak on the 6.7 Powerstroke diesel - YouTube...
Ford 6.0L Power Stroke Diesel :: Slow Fuel Drip Off The Housing For Fuel Filter On The Engine
I have a very slow fuel drip off the housing for the fuel filter on the engine. Can't see where it's coming from. It started sometime after I changed the filter a couple of months ago.
View 5 RepliesFord 6.0L Power Stroke Diesel :: 2005 F250 - Leak Appears To Be Coming From Secondary Fuel Filter Housing
I've got a leak that appears to be coming from the secondary fuel filter housing (the one in the engine compartment)... It's not coming from the filter, but from the side, where there are 4 allen bolts that attach a fitting to the side of the housing...Can I change out the gasket for that piece? I've already tightened the bolts, but the leak persists.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Top Of Engine Fuel Filter Part Number?
With an AD2 and no HFCM, need to have a part number for just the top of engine filter? All I can find (Motorcraft, AMSOIL, Racor) are the dual filter kits.
View 4 RepliesFord 6.7L Power Stroke Diesel :: Hissing Sound Coming From Engine Mounted Fuel Filter
I changed my fuel filters a couple weeks ago. When I opened the hood the other day i noticed a kinda hissing or sucking sound coming from the engine mounted fuel filter. I've watched epics video a couple time and think his made the same sound but not sure. I am just paranoid with all the hpfp problems. It runs fine and had no long starts or hesitation at all. Lemme know if you all have the same thing. I just can't remember if it sounded like that before. I have done the air purge properly and several times since changing the filters. I notice the sound while doing the air purge procedure with engine off and key on.
View 3 RepliesFord 6.0L Power Stroke Diesel :: Coolant Dripping Under Degas Bottle / Boot Oil Leak
I have coolant leaking from under my degas bottle. There was a spot on the driveway this morning and upon investigation, I saw a drip hanging from the bottom of the degas. No liquid on top at all. Where this is coming from? Bottom hose?
Also, the boot that connects the tube (right side while looking at front of truck) to the elbow that goes into the intake is leaking oil and making a mess. Whats the best way to fix? Remove boot, clean up, and put back on? Or replace boot? If replace, where can I get that boot?
Ford 6.0L Power Stroke Diesel :: Transmission Leak - Fluid Dripping On The Bottom Of Both Sides Of Intercooler
I've been having transmission fluid leak from my truck for a while now. Very slow leak. At first I thought it was a hard line and replaced it but it was still leaking. Then I think I found where it was coming from. It looks to be fluid dripping on the bottom of both sides of my intercooler? On both identical spots. I am guessing perhaps I had a crack on my transmission oil cooler and driving blew it into the fins of my intercooler. I took my old one off and couldn't visibly see one. I have a brand new trans cooler installed now. Haven't drove yet as I am waiting on brake parts? I couldn't think of anything else on why it would leak off the intercooler?
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: Fuel Leak / Dripping At Side Of Starter And Collecting At Low Point Of Metal Lines Down Below
I've got a late 99 7.3 truck that I just recently did a lot of work on. I installed a new turbo with bellowed up pipes and a new exhaust system and when I went to start it up it started leaking fuel in the back pretty badly. Initially I thought it was the banjo bolt or the passenger fuel line but looking at it more closely I realized that it's not coming from there. It's dripping all over the side of the starter and is collecting at the low point of the metal lines down below. I also saw small droplets coming out of the up pipe where it meets the manifold but it looked like nowhere near enough to produce the kind of leak I'm seeing, also I know fuel shouldn't be coming out of the up pipe to begin with. This is really annoying and I would like to drive my truck again.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Water In Fuel Light On After Changing Fuel Filter?
Changed fuel filters today. Now my water in fuel light is coming on. But the truck is not running any different no sputtering or anything. ????? Could this be human error
View 14 RepliesPassat (B7) :: Diesel Smell - Fuel Leak After Filter To Engine
The joys of owning a VW never ends...
Fuel line after the fuel filter going to the engine has sprung a leak...
Either way fuel line part number 561-130-307 is leaking wanted to give another heads up to people who are experiencing diesel smell inside the cabin...
Ford 6.7L Power Stroke Diesel :: Cracked Fuel Filter Twice?
Within the last month I've had 2 cracked fuel filters the filter up by the engine...
View 12 RepliesFord 6.7L Power Stroke Diesel :: New Oil Pan On / Rust In Fuel Filter
Well I finally had time to change out my composite oil pan to the metal one. Nothing was wrong with the old one but Ive seen the composite pans get hit by a rock and crack so I decide to get the metal one. It didnt take long once I had the oil drained and its very easy to get to. Once i had the old pan off I did find two piece of sludge stuck to the oil pickup screen, they had a sliver of aluminum in them. My oil reports have been coming back with high aluminum content so I am not really sure what to think being my motor had 33k miles on it now.
I also changed out the fuel filter and when I dropped the frame mounted filter I found about a teaspoon of rust in it. I'm not one to run my truck down to E but I admit I did so twice since the last filter change. Since I found the fuel filter kit for 60 buck(ford dealer wanted $140) I think I will move my fuel filter changes to 10k miles instead of 15k. Last but not least I also added SPE 6.7 Full Lock Diff Kit which allows the locked rear end to stay engaged past 20 mph. It was a simple 10 min installation with just a few wires and easy directions to follow
New oil pan
Composite pan
Old pan off and view of oil pickup
Two pieces of sludge that came off oil pickup screen
New pan on
Rust in the bottom
Ford 6.7L Power Stroke Diesel :: Oil And Fuel Filter Warning
While driving from SD to Chicago today 2 warnings popped up at the same time saying to change the oil and fuel filters. Had both done 2500 miles ago. Am I right that the Dealer just didn't reset these? I thought these were measured by miles and driving habits.
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Rear Main Seal Leak - Oil Dripping From The Top Of Engine
Took the torque converter cover off and this is what I see. Before I took it off the cover looked oily. Prev I replaced the EGR valve and some other sensors and there was oil on top of the engine. Does this look like a rear main seal or oil dripping from the top of the engine?
View 4 RepliesFord 6.7L Power Stroke Diesel :: 2013 - Changing Fuel Filter?
I was going to change the fuel filter on my truck yesterday, but couldn't figure out how the guard comes off. It has a bolt but it also has a rivet in it and looks like its all one piece so Id have to drill the rivet to remove. I tried to just spin the housing off.
View 8 RepliesFord 6.7L Power Stroke Diesel :: Fuel Filter Metal Debris
While I was changing the oil yesterday, I also changed the fuel filters. The primary filter had some debris that was confirmed by a magnet to be metal. I have seen a little bit of this all three times I have changed the filters. The filter itself is very clean, but there remains a small amount of metal slightly more coarse than filings.
I don't really have any concerns that it could be coming from the HPFP because that is after the secondary filter and would not be returned to the tank. Also anything from the HPFP would have fouled several injectors by now. I don't even think there is any iron in the pump.
I guess it could be useful to put a magnet in the water separator reservoir, but I don't even know what good that would do since the debris is large enough that it is being caught by the filter and of course the secondary filter is even less microns. It would just be nice to know where in the world this stuff comes from.